 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
2002 Chevy Truck TrailBlazer 2WD L6-4.2L VIN S
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 2002 Chevy Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 2002 Chevy Truck TrailBlazer 2WD L6-4.2L VIN S
FEBRUARY 2006 Recall - Rear Side Door Latch Corrosion
NOVEMBER 2004 Recall - Tail/Stop Lamp Inspection/Replacement
JULY 2004 Recall - Windshield Wiper Defect
JUNE 2004 Recall - Front Seat Belt Retractor Defect
AUGUST 2003 Recall - Child Restraint Anchorage Information
MAY 2003 Recall - Theft Protection Non-Compliance
OCTOBER 2002 Recall - Rear Floor Pan Welds Missing
AUGUST 2002 Recall - Driver Air Bag Inspection/Replacement
MAY 2002 Recall - Fuel Filter Fitting Retainer Replacement
Technical Service Bulletin Titles for 2002 Chevy Truck TrailBlazer 2WD L6-4.2L VIN S
MARCH 2005 Campaign - Fuel Tank Replacement
AUGUST 2004 Campaign - Stop/Tail Lamp Inspection/Replacement
JUNE 2003 Campaign - Cylinder Bore Liner Cracking
Technical Service Bulletin Titles for 2002 Chevy Truck TrailBlazer 2WD L6-4.2L VIN S
MAY 2007 Engine - Broken Head Bolt/Main Cap Bolt Removal
MAY 2007 Fuel System - MIL ON/DTC`s Set/Driveability Problems
APRIL 2007 Body - Paint Chipping By Wheel Openings
APRIL 2007 Tires - Proper Inflation Pressure Information
APRIL 2007 Body - Bumps or Rust Colored Spots in Paint
APRIL 2007 Body - Polypropylene Energy Absorber Replacement
APRIL 2007 Charging System - Low Voltage Display/Low/Dead Battery
APRIL 2007 Navigation System - Replacement Navigation Discs
APRIL 2007 Engine - Sealant Usage/procedures
APRIL 2007 A/T - Dexron®-VI(R) Fluid Availability
APRIL 2007 Steering Gear - Stub Shaft bearing Kit Availability
APRIL 2007 Engine - Oil Consumption Guideline Info.
APRIL 2007 Body - Non-Approval of `Clipping` for Collision Repair
MARCH 2007 Instruments - Reduced PRNDL Display Visibility
MARCH 2007 Body - Door(s) Are Difficult To Close
MARCH 2007 OnStar(R) - GEN 4& 5 to GEN 6 Upgrade
MARCH 2007 OnStar(R) - Loses GPS/Can`t Renew Hands-Free Minutes
MARCH 2007 SRS - Front Passenger Seat Alteration Precautions
FEBRUARY 2007 Body - License Plate Pocket Gasket Out of Position/Loose
FEBRUARY 2007 A/T - Shift Lock Control Actuator Available
FEBRUARY 2007 Wheels/Tires - `Upsized` Wheel & Tire Information
FEBRUARY 2007 Engine, A/T - Shift/Driveability Concerns/MIL ON
JANUARY 2007 Locks - Key Code Securtiy Rules & Information
JANUARY 2007 Body - Hem Flange Repair
JANUARY 2007 Engine - In-Vehicle Cylinder Head Service Procedure
JANUARY 2007 Ignition System - MIL ON/Misfire DTC`s In Wet Weather
JANUARY 2007 Engine Controls - Aftermarket Accessory Usage
JANUARY 2007 Tires - Radial Force Variation (RFV) Information
DECEMBER 2006 OnStar(R) - Dual Mode System Information
DECEMBER 2006 Restraints - Availability of Seat Belt Extenders
DECEMBER 2006 A/T - Seemingly Slow `Garage` Shifts
DECEMBER 2006 A/T - Diagnostic Info on DTCs P0894/P1870
DECEMBER 2006 Drivetrain - Whine Noise from Rear Axle
NOVEMBER 2006 Brakes - Brake Warranty Service and Procedures
NOVEMBER 2006 Warranty - Claims Submission
NOVEMBER 2006 Engine - Unnecessary Flushing Services
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline Usage
NOVEMBER 2006 A/C - Rear Window Defroster Tab Repair
NOVEMBER 2006 Body - Liftgate Binding/Improper Fit/Rear Glass Broken
NOVEMBER 2006 M/T - Hydraulic Clutch Bleeding Procedure Improvement
OCTOBER 2006 Lighting - Replacement Guidelines for Lamp Condensation
OCTOBER 2006 Power Steering - Diagnostic Tips
OCTOBER 2006 Electrical - SES Lamp ON/DTC`s P0480/P0526/P1481/P1484
OCTOBER 2006 Emissions - OBDII I/M Readiness Testing
OCTOBER 2006 Body - Metal Panel Adhesive Bonding Information
OCTOBER 2006 Interior - Eliminating Unwanted Odors
OCTOBER 2006 Tires - Tread Puncture Repair Procedures
SEPTEMBER 2006 Wheel Alignment - Recommendations/Requirements
SEPTEMBER 2006 Wheels - Pitting/Brake Dust On Chrome Wheels
SEPTEMBER 2006 Fuel System - GM Fuel System Treatment Plus(R)
SEPTEMBER 2006 A/T - Poor Performance/MIL ON/DTC P0757
SEPTEMBER 2006 Body - Distortion On Outer Glass Surfaces
SEPTEMBER 2006 Body - Exterior Emblem Discoloration/Peeling/Blistering
SEPTEMBER 2006 Wheels - Changing Procedures/Precautions
AUGUST 2006 Cooling System - DEXCOOL(R) Leak Detection Dye
AUGUST 2006 M/T - Normal Operating Characteristics
AUGUST 2006 Suspension - Revised Shock Module Replacement
AUGUST 2006 Tires - Original Equipment Tire Characteristics
AUGUST 2006 Cooling System - Coolant Recycling Information
AUGUST 2006 Engine Controls - MIL Function During I/M Testing
AUGUST 2006 Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
JULY 2006 A/C - Contaminated R134A Refrigerant
JULY 2006 Fuel System - E85 Fuel Usage Information
JUNE 2006 Windshield Wipers - Performance/Cleaning and Maintenance
JUNE 2006 Wheels - Aluminum Wheel Refinishing Recommendations
JUNE 2006 A/T - Dexron®(R) VI Fluid Availability
JUNE 2006 A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
JUNE 2006 Body - Front Bumper Fascia Panel Wavy
MAY 2006 Fuel System - E85 Fuel Usage Recommendations
MAY 2006 A/T - Shift Lock Control Feature Function
MAY 2006 Electrical - Proper Jump Starting Procedure
MAY 2006 A/T - 2-3/3-2 Shift Clunk Noise
MAY 2006 Engine Controls - Reprogramming Warranty Coverage
MAY 2006 Electrical - Instrument Panel & General Wiring Repair
MAY 2006 Interior - Cargo Cover Handle is Broken
APRIL 2006 Audio System - Portable Audio Equipment Noise
APRIL 2006 Wheels/Tires - Slow Leaks From Aluminum Wheels
APRIL 2006 Cell Phone - Error Messages, Bulletin Cancellation
MARCH 2006 Body - Urethane Adhesives for Glass Applications
MARCH 2006 Steering - Steering Column Squeaking/Rubbing Noise
MARCH 2006 Audio System - Poor Radio Reception/Station Drifting
MARCH 2006 Battery, Charging System - Electrical Diagnostics
MARCH 2006 Electrical - Battery Charging Tips
MARCH 2006 Starting System - Engine No Start/No Crank Condition
MARCH 2006 Tires/Wheels - Wheel Weight Usage Precautions
FEBRUARY 2006 OnStar(R) - Incorrect Phone Number Assigned to Vehicle
FEBRUARY 2006 A/T - 4L60-E, 4L65-E, 4L70-E DTC P0756 Diagnostics
FEBRUARY 2006 Accessories - DTC`s P0300, P1380, P1381
FEBRUARY 2006 Body - Revised Liftgate Lock Cylinder Replacement
FEBRUARY 2006 Cooling System - Electro-Viscous Fan Clutch Operation
FEBRUARY 2006 Audio System - Radio Knob Availability
FEBRUARY 2006 OnStar(R) - Unable to Connect, Bulletin Cancellation
FEBRUARY 2006 A/T - Fluid Cooler Flushing
JANUARY 2006 Lighting - Center Mounted Stop Lamp Applique Loose
JANUARY 2006 Engine - Surface Conditioning Disc Usage Prohibition
JANUARY 2006 A/T - 4T65-E Fluid Leaks From Reverse Servo Cover
JANUARY 2006 Keyless Entry - Operational Characteristics
JANUARY 2006 Fuel System - Fuel Injector Maintenance Cleaning
DECEMBER 2005 Tires/Wheels - Nitrogen Gas Usage for Filling Tires
DECEMBER 2005 Suspension - Air Suspension Leak Diagnosis Addition
DECEMBER 2005 Interior - Front Floor Carpet Wet
DECEMBER 2005 Audio System - Vinyl Roofs Affect Radio Performance
DECEMBER 2005 Restraints - Seat Belt Retractor Jamming Prevention
NOVEMBER 2005 ABS - ABS Light ON/DTC`s C0265/C0201/U1041
NOVEMBER 2005 Body - Paint-Less Dent Repair Recommendations
NOVEMBER 2005 A/C - New PAG Oil
NOVEMBER 2005 OnStar(R) - Programming Replacement Modules
OCTOBER 2005 Engine - New Cylinder Bore Sleeve Replacement Procedure
OCTOBER 2005 Engine/Fuel System - Oil/Fuel Additive Recommendations
OCTOBER 2005 Wipers/Washers - Serviceable Wiper Motor Components
OCTOBER 2005 A/T - 4L60-E/4L65-E Harsh 1-2 Upshift Diagnosis
OCTOBER 2005 A/T - Diagnosing Fluid Leaks
OCTOBER 2005 Steering - Hissing Noise From Steering Column
OCTOBER 2005 A/T - Torque Converter Replacement
SEPTEMBER 2005 Electrical - A/T Stuck in 2nd/3rd Gear/MIL ON/DTC`s
AUGUST 2005 A/T - Cannot Remove Key From Ignition Lock Cylinder
AUGUST 2005 A/T - Cracked Case Diagnosis
AUGUST 2005 A/C - Intermittently Inoperative/Poor Performance
AUGUST 2005 Electrical - Harness Connection Inspection
AUGUST 2005 Body - Popping Noise When Rolling Up Window
JUNE 2005 A/C - Broken Rear Window Defogger Grid Detection
JUNE 2005 A/C - Slow to Cool in Hot/Humid Conditions
MAY 2005 Body - Front/Rear Side Door Glass is Scratched
APRIL 2005 A/C - Mode Door Actuator Tool
APRIL 2005 Brakes - Revised Caliper Mounting Bolt Torque Spec.
APRIL 2005 Suspension - Front/Rear Rattle/Pop/Snap Noise on Bumps
APRIL 2005 OnStar(R) - Cellular Antenna Replacement Parts
APRIL 2005 Restraints - Child Seat Top Teather Attachment Kits
APRIL 2005 Engine Controls - Underhood Ticking Noise
MARCH 2005 Brakes - Wheel Cylinder Inspection Guidelines
MARCH 2005 Emissions - DTC P0440/P0455/P0442 (EVAP) Diagnostics
MARCH 2005 OnStar(R) - Incorrect Position Reported
MARCH 2005 OnStar(R)/Cell Phone - Integration
MARCH 2005 Lighting - Headlamps Flicker Momentarily While Driving
FEBRUARY 2005 Cooling System - Aluminum Radiator/Heater Core Info.
FEBRUARY 2005 Audio System - Rear Headphone Ear Pads Worn/Damaged
FEBRUARY 2005 A/T - New/Reman A/T Identification
FEBRUARY 2005 Instruments - GPS System Performance Degradation
FEBRUARY 2005 Restraints - Air Bag System Diagnostics
JANUARY 2005 Body/Interior - Front Floor Carpet Wet
JANUARY 2005 Brakes - Park Brake Shoe Retaining Clip Kit
DECEMBER 2004 Battery - Specification Label Clarification
DECEMBER 2004 A/T - 4L60/65E No Reverse/2nd or 4th Gear
DECEMBER 2004 Suspension - Boom/Rumble Heard at Highway Speeds
NOVEMBER 2004 Body - Liftgate Glass Binds/Won`t Open Fully
OCTOBER 2004 Body - Squeeze Type Resistance Spot Welding/Equipment
OCTOBER 2004 Lighting - Damage To Polycarbonate Headlamp Lenses
SEPTEMBER 2004 A/C - R-134a System Flushing Procedures
SEPTEMBER 2004 Electrical - Intermittent Interior Electrical Concerns
AUGUST 2004 A/C - Dual Zone A/C Control Battery Draw Explanation
AUGUST 2004 A/T - Transmission Mount Availability
AUGUST 2004 Wipers/Washers - Rear Wiper Does Not Clean Well
JULY 2004 Engine Controls - Above Normal Temp. Gauge Readings
JULY 2004 Wheels - Plastic Wheel Nut Covers Loose/Missing
JULY 2004 Battery - Parasitic Drain
JUNE 2004 Fuel - Top Tier Detergent Gasoline Information
JUNE 2004 Body - Liftgate Glass Unlatches On Bumpy Roads
JUNE 2004 Body - Rattle Under Hood
JUNE 2004 Engine - New Long Block Installation Precaution
MAY 2004 Body - Metal Panel Bonding Additional Material
MAY 2004 Lighting - Tail Lamp(s) Inoperative
MAY 2004 Engine - Redesigned Oil Pick-Up and Front Cover
MAY 2004 Engine Controls - SES Lamp ON/ DTC`s Set
MAY 2004 A/T - 4L60-E/4L65-E New Pump/Seal/Case/Service
MAY 2004 Engine Controls - MIL ON/Delayed Downshift/Fan Noise
APRIL 2004 Brakes - Rear Caliper Mounting Bolt Torque Revision
APRIL 2004 Engine - Serpentine Drive Belt Wear Information
MARCH 2004 Engine - Balancer Hub Application/Service Precaution
FEBRUARY 2004 A/T - 4L65E, 4L60E, 4L60, 200-4R Oil Pump Spring
FEBRUARY 2004 Ignition Switch - Intermittent No Crank/Dead Battery
JANUARY 2004 Body - Corrosion Protection for Metal Panels
JANUARY 2004 A/C - Clicking Noises From The Instrument Panel
JANUARY 2004 A/T, Exhaust - Rattling Noise From Under the Vehicle
JANUARY 2004 A/C - Control Knob Replacement Availability
DECEMBER 2003 Engine Controls - Hesitation/Idle Fluctuation
DECEMBER 2003 Body - Rattle from Front of Vehicle
DECEMBER 2003 Steering Wheel - Removal Procedure Revision
NOVEMBER 2003 Engine - Piston Application/Usage
NOVEMBER 2003 A/T - 4L60-E Oil Pump Identification
OCTOBER 2003 A/C - Unnecessary Compressor Replacement
OCTOBER 2003 Interior - Power Memory Seat Inoperative
OCTOBER 2003 Engine Controls - Hesitation/Stall/Harsh A/T Upshifts
SEPTEMBER 2003 Body - Door Mirror Actuator Replacement
JULY 2003 Audio/A/C - Settings Change While Driving
JULY 2003 A/C - Catastrophic Compressor Failure Debris Removal
JUNE 2003 Engine Controls - SES Lamp ON/DTC P0135 Set
JUNE 2003 Body - Information On Expandable Acoustic Foam
JUNE 2003 A/T - Oil Cooler Flushing Frequently Asked Questions
JUNE 2003 A/T - Shift Stabilization/Tow/Haul Mode Feature
JUNE 2003 Body - Liftgate Glass Hard to Close
MAY 2003 A/C - Intermittently Inoperative/Blows Warm Air
MAY 2003 A/C - Stops Blowing Cold Air/Cycles ON and OFF
MAY 2003 Lighting - Headlamp Low Beam Socket Replacement
APRIL 2003 Body - BCM Delayed Locking Feature Explanation
MARCH 2003 Keyless Entry - System Inoperative
MARCH 2003 A/C - Automatic A/C Functional Description
MARCH 2003 A/C - System Sealers/Leak Detection Guidelines
FEBRUARY 2003 A/T - Oil Cooler Flushing/Flow Check Procedures
FEBRUARY 2003 Drivetrain - `Service 4WD` Indicator ON/DTC B2725 Set
JANUARY 2003 Body - Weatherstrip Maintenance
JANUARY 2003 Computers/Controls - Module Configuration/Setup
DECEMBER 2002 A/C - Revised Compressor Oil Balancing Procedure
DECEMBER 2002 Audio System - Whine/Buzz Noise on Acceleration
DECEMBER 2002 Body - Door Glass Molding Discoloration
DECEMBER 2002 Drivetrain - Differential Carrier Replacement Update
DECEMBER 2002 Wipers/Washers - Revised Rear Wiper Diagnostics
NOVEMBER 2002 Instruments - Gauges Inoperative/Read Zero at Times
OCTOBER 2002 Body - Erratic Outside Rearview Mirror Operation
OCTOBER 2002 Body - Moonroof Sunshade Damage Prevention
OCTOBER 2002 Engine - Oil Leak at Oil Pressure Switch
OCTOBER 2002 Exhaust - Exhaust Noise/Leak
OCTOBER 2002 Interior - Console Power Outlet Cover/Seat Interference
OCTOBER 2002 Interior - Revised Moonroof Sunshade Replacement
SEPTEMBER 2002 Communication Module - Revised Service Procedure
SEPTEMBER 2002 Electronic Ignition - Service Manual Diagnosis Update
SEPTEMBER 2002 Interior - Passenger Seat Belt Too Tight
AUGUST 2002 Body - Front Fascia is Loose
AUGUST 2002 Electrical - Intermittent Multiple Malfunctions
AUGUST 2002 Engine - Crankcase Flushing Recommendations
JULY 2002 A/C - Inoperative Rear A/C Controls, DTC B0150
JULY 2002 Body Control - Update of Some Control Module DTC`s
JUNE 2002 A/T - Serial Number/Site Code Locations/Identification
JUNE 2002 Body - Assist Step Skid Pad Warping
JUNE 2002 Computers & Controls - DTC`s Set When Replacing Modules
JUNE 2002 Engine - Identification Information
MAY 2002 Body/Frame - Roof Rack Wind Noise
MAY 2002 Engine - New Flywheel to Crankshaft Bolts
MAY 2002 Instruments - OnStar(R) Module Cover Retainer Tab Broken
MAY 2002 Interior - Headliner Sags at Rear of Sunroof
MAY 2002 OnStar (R) - DTC U1500 Manual Update
APRIL 2002 Engine - Revised Harmonic Balancer
APRIL 2002 Rearview Mirrors (Outside) - Uncommanded Movement
MARCH 2002 Engine - New Prelube Tool
MARCH 2002 GM Oil Life System (TM) - Resetting
FEBRUARY 2002 Warranty - Parts Return Program Explained
JANUARY 2002 Electrical - No Start/Multiple Systems Inoperative
JANUARY 2002 Engine - Correct RTV Sealer Usage
JANUARY 2002 Heater - Insufficient Heat To Driver`s Feet
JANUARY 2002 Ignition Lock Cylinder - Revised Replacement Procedure
DECEMBER 2001 A/T - Slipping/Missed Shifts Diagnostic Tips
DECEMBER 2001 Onstar(R) - Antenna Coupling Revised Procedures
DECEMBER 2001 Tires - Sidewall Damage
NOVEMBER 2001 Cigarette Lighter - Inoperative
NOVEMBER 2001 Engine - Oil Filter Usage
NOVEMBER 2001 HomeLink(R) Transmitter - Programming Difficulties
NOVEMBER 2001 Radio - Erratic or Intermittent Operation
NOVEMBER 2001 Rear View Mirrors (Outside) - Click or Ratchet Sound
OCTOBER 2001 A/T - Core Return Product Feedback Form
OCTOBER 2001 Driver Information Center - Setting Language Options
OCTOBER 2001 EVAP System - Monitor Strategy
OCTOBER 2001 Radio Speakers - Intermittent, Random Noises
OCTOBER 2001 Spare Tire - Lowering Information
SEPTEMBER 2001 Luggage Carrier - Windnoise
SEPTEMBER 2001 RKE Transmitter - Correct Use of Labor Operation R4490
AUGUST 2001 Door Edge - New Protection
AUGUST 2001 Navigation System - Unable to Connect to OnStar(R)
JUNE 2001 Audio System - Clearing `CLN` Message From Display
JUNE 2001 Diagnostic Worksheet - Usage
JUNE 2001 PCM/BCM Replacement - DTC`s B001/B1271/B1780 Set
JUNE 2001 Power Steering - Whine Noise on Start Up
JUNE 2001 Seat Belt System - Collision Replacement Guidelines
JUNE 2001 Tools - Flywheel Holding Tool, Modification
MAY 2001 A/C - Odor Emission in Hot Weather
MAY 2001 Instrument Panel - Erratic Indicators/Gauges/Pointers
MAY 2001 Key/Key Number/Security Chip - Replacement
APRIL 2001 A/T - Service Procedure Changes
APRIL 2001 A/T - Tech 2 Shift Adapt Clearing
APRIL 2001 Radio Display - Error Code Diagnosis/Repair
APRIL 2001 Special Tools - Power Steering System Analyzer
MARCH 2001 Rear Axle - Exchange Program
FEBRUARY 2001 Front Axle - Special Policy For Service
JANUARY 2001 Engine - Exchange Program
NOVEMBER 1988 Battery - Diagnosis and Charging
|
