 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1999 Chevy Truck K 2500 P/U 4WD V8-6.5L DSL Turbo VIN F
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1999 Chevy Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1999 Chevy Truck K 2500 P/U 4WD V8-6.5L DSL Turbo VIN F
APRIL 2006 Recall - Potential Front Wheel Speed Sensor Corrosion
APRIL 2006 Recall - Tailgate Support Cable Defect
JANUARY 2005 Recall - Front Wheel Speed Sensor Corrosion
Technical Service Bulletin Titles for 1999 Chevy Truck K 2500 P/U 4WD V8-6.5L DSL Turbo VIN F
APRIL 2007 Campaign - Fuel Injection Pump Warranty Extension
Technical Service Bulletin Titles for 1999 Chevy Truck K 2500 P/U 4WD V8-6.5L DSL Turbo VIN F
APRIL 2007 Tires - Proper Inflation Pressure Information
APRIL 2007 Body - Bumps or Rust Colored Spots in Paint
APRIL 2007 Body - Polypropylene Energy Absorber Replacement
APRIL 2007 Charging System - Low Voltage Display/Low/Dead Battery
APRIL 2007 Navigation System - Replacement Navigation Discs
APRIL 2007 Engine - Sealant Usage/procedures
APRIL 2007 A/T - Dexron®-VI(R) Fluid Availability
APRIL 2007 Engine - Oil Consumption Guideline Info.
MARCH 2007 Instruments - Reduced PRNDL Display Visibility
MARCH 2007 SRS - Front Passenger Seat Alteration Precautions
FEBRUARY 2007 Steering - Intermittent Reduced Steering Effort
FEBRUARY 2007 Diesel Fuel System - Additive Recommendations
FEBRUARY 2007 Wheels/Tires - `Upsized` Wheel & Tire Information
FEBRUARY 2007 Engine, A/T - Shift/Driveability Concerns/MIL ON
JANUARY 2007 Steering - Clunking Noises Felt in Steering Wheel
JANUARY 2007 Locks - Key Code Securtiy Rules & Information
JANUARY 2007 Body - Hem Flange Repair
JANUARY 2007 Tires - Radial Force Variation (RFV) Information
JANUARY 2007 Diesel Fuel System - Fuel Lubricity/Metal Contamination
DECEMBER 2006 Restraints - Availability of Seat Belt Extenders
DECEMBER 2006 OnStar - Analog-Only Systems Information
NOVEMBER 2006 Brakes - Brake Warranty Service and Procedures
NOVEMBER 2006 Warranty - Claims Submission
NOVEMBER 2006 Engine - Unnecessary Flushing Services
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline Usage
NOVEMBER 2006 M/T - Hydraulic Clutch Bleeding Procedure Improvement
OCTOBER 2006 Lighting - Replacement Guidelines for Lamp Condensation
OCTOBER 2006 Power Steering - Diagnostic Tips
OCTOBER 2006 Body - Metal Panel Adhesive Bonding Information
OCTOBER 2006 Interior - Eliminating Unwanted Odors
OCTOBER 2006 Tires - Tread Puncture Repair Procedures
SEPTEMBER 2006 Wheel Alignment - Recommendations/Requirements
SEPTEMBER 2006 Wheels - Pitting/Brake Dust On Chrome Wheels
SEPTEMBER 2006 A/T - Poor Performance/MIL ON/DTC P0757
SEPTEMBER 2006 Body - Distortion On Outer Glass Surfaces
SEPTEMBER 2006 Body - Exterior Emblem Discoloration/Peeling/Blistering
SEPTEMBER 2006 Wheels - Changing Procedures/Precautions
AUGUST 2006 Cooling System - DEXCOOL(R) Leak Detection Dye
AUGUST 2006 M/T - Normal Operating Characteristics
AUGUST 2006 Tires - Spare Tire Different Size Than Other Tires
AUGUST 2006 Tires - Original Equipment Tire Characteristics
AUGUST 2006 Cooling System - Coolant Recycling Information
AUGUST 2006 Diesel Fuel System - Low Sulfur Fuel Information
AUGUST 2006 Engine Controls - MIL Function During I/M Testing
AUGUST 2006 Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
JULY 2006 A/C - Contaminated R134A Refrigerant
JULY 2006 Interior - Loose/Unwanted Seat Movement
JUNE 2006 Windshield Wipers - Performance/Cleaning and Maintenance
JUNE 2006 Wheels - Aluminum Wheel Refinishing Recommendations
JUNE 2006 A/T - Dexron®(R) VI Fluid Availability
JUNE 2006 A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
JUNE 2006 Suspension - Squeak Noise From Rear of Vehicle
MAY 2006 A/T - Shift Lock Control Feature Function
MAY 2006 Drivetrain - Updated Transfer Case Speed Sensor Conn.
MAY 2006 A/T - 2-3/3-2 Shift Clunk Noise
MAY 2006 Brakes - Low Speed ABS Activation/No DTC`s Set
MAY 2006 Engine Controls - Reprogramming Warranty Coverage
MAY 2006 4WD/AWD Systems - Driveline Operating Characteristics
MAY 2006 Interior - Napped Seat Fabric Repair
MAY 2006 Electrical - Instrument Panel & General Wiring Repair
APRIL 2006 Audio System - Portable Audio Equipment Noise
APRIL 2006 Wheels/Tires - Slow Leaks From Aluminum Wheels
APRIL 2006 Body - Revised Hinged Side Window Replacement Procedure
MARCH 2006 Body - Urethane Adhesives for Glass Applications
MARCH 2006 Battery, Charging System - Electrical Diagnostics
MARCH 2006 Electrical - Battery Charging Tips
MARCH 2006 Tires/Wheels - Wheel Weight Usage Precautions
FEBRUARY 2006 A/T - 4L60-E, 4L65-E, 4L70-E DTC P0756 Diagnostics
FEBRUARY 2006 Accessories - DTC`s P0300, P1380, P1381
FEBRUARY 2006 Audio System - Radio Knob Availability
FEBRUARY 2006 A/T - Fluid Cooler Flushing
JANUARY 2006 Engine - Surface Conditioning Disc Usage Prohibition
JANUARY 2006 A/T - 4T65-E Fluid Leaks From Reverse Servo Cover
JANUARY 2006 Keyless Entry - Operational Characteristics
JANUARY 2006 Brakes - Low Speed (Below 5 MPH) ABS Activation
DECEMBER 2005 Tires/Wheels - Nitrogen Gas Usage for Filling Tires
NOVEMBER 2005 ABS - ABS Light ON/DTC`s C0265/C0201/U1041
NOVEMBER 2005 Body - Paint-Less Dent Repair Recommendations
NOVEMBER 2005 Body - Rubbing/Scratching When Operating Windows
NOVEMBER 2005 Drivetrain - Front Drive Axle Lubrication Update
NOVEMBER 2005 A/C - New PAG Oil
NOVEMBER 2005 Wheels - Correct Hub Cap Installation Procedure
OCTOBER 2005 Engine/Fuel System - Oil/Fuel Additive Recommendations
OCTOBER 2005 A/T - Diagnosing Fluid Leaks
OCTOBER 2005 A/T - Torque Converter Replacement
SEPTEMBER 2005 Electrical - A/T Stuck in 2nd/3rd Gear/MIL ON/DTC`s
AUGUST 2005 A/T - Cracked Case Diagnosis
AUGUST 2005 Electrical - Harness Connection Inspection
AUGUST 2005 Transfer Case - 1st & 2nd Clutch Hub & Apply Plate
JULY 2005 Body - Revised Tailgate Latch Bezel Replacement
JUNE 2005 A/C - Broken Rear Window Defogger Grid Detection
APRIL 2005 Body/Frame - Revised Crossmember/Body Bolt Service
APRIL 2005 Engine Controls - Revised DTC P0236
APRIL 2005 OnStar(R) - Cellular Antenna Replacement Parts
APRIL 2005 Restraints - Child Seat Top Teather Attachment Kits
APRIL 2005 Suspension - Revised Stabilizer Link Service/Torque
APRIL 2005 Brakes - Low Effort Parking Brake System Information
APRIL 2005 Electrical - Trailer Brakes Apply With Headlamps ON
MARCH 2005 Steering/Suspension - Revised Caster/Camber Adjustment
MARCH 2005 Brakes - Wheel Cylinder Inspection Guidelines
MARCH 2005 Drivetrain - Transfer Case Control Module Replacement
MARCH 2005 Body/Instruments - Outside Mirror Housings Come Loose
MARCH 2005 OnStar(R) - Dealer Kits No Longer Available
MARCH 2005 OnStar(R)/Cell Phone - Integration
MARCH 2005 Transfer Case - RTV Silicone Sealant Usage Precaution
FEBRUARY 2005 Cooling System - Aluminum Radiator/Heater Core Info.
FEBRUARY 2005 A/T - New/Reman A/T Identification
FEBRUARY 2005 Instruments - GPS System Performance Degradation
FEBRUARY 2005 Restraints - Air Bag System Diagnostics
FEBRUARY 2005 Body - Pick Up Box Damaged by Aftermarket Accessories
FEBRUARY 2005 Body - Pick Up Box Reinforcement Installation
DECEMBER 2004 A/T - 4L60/65E No Reverse/2nd or 4th Gear
NOVEMBER 2004 Drivetrain - Transfer Case Clutch Shimming
OCTOBER 2004 Lighting - Damage To Polycarbonate Headlamp Lenses
SEPTEMBER 2004 A/C - R-134a System Flushing Procedures
AUGUST 2004 A/C - Low Pressure Switch Diagnosis
JULY 2004 Wheels - Plastic Wheel Nut Covers Loose/Missing
JULY 2004 Battery - Parasitic Drain
JUNE 2004 Brakes/Wheels - Excessive Debris Build Up
JUNE 2004 A/C - Loss of Mode or Temperature Control
JUNE 2004 Body - Windshield Area Wind Noise
JUNE 2004 Engine - New Long Block Installation Precaution
APRIL 2004 Suspension - Rear Leaf Spring Slap or Clunk Noise
APRIL 2004 Engine - Serpentine Drive Belt Wear Information
MARCH 2004 Drivetrain - Wheel Drive Shaft Nut Torque Revision
FEBRUARY 2004 Body - Front/Rear Door Power Windows Inoperative
FEBRUARY 2004 A/T - 4L65E, 4L60E, 4L60, 200-4R Oil Pump Spring
FEBRUARY 2004 Ignition Switch - Intermittent No Crank/Dead Battery
NOVEMBER 2003 A/T - 4L60-E Oil Pump Identification
OCTOBER 2003 A/C - Unnecessary Compressor Replacement
AUGUST 2003 4X4 System - Front Wheels Slip in Four Wheel Drive
JULY 2003 Steering - Revised Service Procedures
JULY 2003 A/C - Catastrophic Compressor Failure Debris Removal
JUNE 2003 Audio System - Tweeter Rattles in Front Door(s)
JUNE 2003 Lighting - DRL Bulb Replacement
JUNE 2003 A/T - Oil Cooler Flushing Frequently Asked Questions
JUNE 2003 A/T - Shift Stabilization/Tow/Haul Mode Feature
MAY 2003 Drivetrain - Revised Transfer Case Service Procedures
MAY 2003 Drivetrain - Transfer Case Output Shaft/Oil Pump
MARCH 2003 A/C - Automatic A/C Functional Description
MARCH 2003 A/C - System Sealers/Leak Detection Guidelines
FEBRUARY 2003 A/T - Oil Cooler Flushing/Flow Check Procedures
FEBRUARY 2003 Drivetrain - Noise/Vibration/Leaks/Slipping in 4WD
JANUARY 2003 Body - Weatherstrip Maintenance
JANUARY 2003 Wheels/Tires - Wheel Weight Usage
OCTOBER 2002 A/T - Intermittent Downshift/Slip/Cycling Diagnosis
SEPTEMBER 2002 Drivetrain - New Transfer Case Output Bearing Tool
SEPTEMBER 2002 Interior - Console Lid Hard to Open/Close
JULY 2002 Interior - Lock Lever Comes Loose From Door Trim Panel
JUNE 2002 A/T - Serial Number/Site Code Locations/Identification
JUNE 2002 ABS - Wheel Speed Sensor Replacement Revision
JUNE 2002 Computers & Controls - DTC`s Set When Replacing Modules
JUNE 2002 Engine - Identification Information
MAY 2002 Tie Rod (Inner) - Replacement Procedure Revision
APRIL 2002 Transfer Case - DTC B2725 Manual Update
APRIL 2002 Transfer Case Switch - `Service 4WD` Indicator ON
MARCH 2002 A/T - 4L60-E Harsh 1-2 Gear Upshift/MIL/SES/CEL ON
MARCH 2002 Drive Shaft - Acceleration Launch Shudder
MARCH 2002 Drum Brakes - Revised Component Specifications
MARCH 2002 Engine - New Prelube Tool
FEBRUARY 2002 Warranty - Parts Return Program Explained
JANUARY 2002 A/C - Loss of Mode/Temperature Control
JANUARY 2002 A/T - New Design Reaction Shell Thrust Washer
JANUARY 2002 Ignition Lock Cylinder - Revised Replacement Procedure
DECEMBER 2001 Tires - Sidewall Damage
NOVEMBER 2001 Rear Axle Ring & Pinion Gear Sets - 2 Cut vs. 5 Cut
OCTOBER 2001 A/T - Core Return Product Feedback Form
OCTOBER 2001 Center Front Floor Console Lock & Key - Availability
OCTOBER 2001 EVAP System - Monitor Strategy
OCTOBER 2001 Pickup Box Side Panel Rear Braces - Revised
OCTOBER 2001 Side Access Door - Squeak or Scraping Noise
SEPTEMBER 2001 Antitheft System - Lamp ON/Stall/No Start/DTC B2960 Set
SEPTEMBER 2001 RKE Transmitter - Correct Use of Labor Operation R4490
SEPTEMBER 2001 Transfer Case - Bump/Clunk Update
JUNE 2001 Audio System - Clearing `CLN` Message From Display
JUNE 2001 Diagnostic Worksheet - Usage
JUNE 2001 Driveshaft - Launch Shudder On Acceleration
JUNE 2001 Front Seat Belt - Retractor and Buckle Replacement
JUNE 2001 PCM/BCM Replacement - DTC`s B001/B1271/B1780 Set
JUNE 2001 Seat Belt System - Collision Replacement Guidelines
JUNE 2001 Security System - Lamp ON/DTC B2960 Set
MAY 2001 A/C - Odor Emission in Hot Weather
MAY 2001 Key/Key Number/Security Chip - Replacement
MAY 2001 Park/Neutral Switch - Connector Hard to Remove
MAY 2001 Tires - Bumper To Bumper Warranty Coverage
APRIL 2001 A/T - 4L60 E Revised Valve Body/Spacer/Gaskets
APRIL 2001 A/T - 4L60E Valve Body/Spacer/Gasket Kit Reference
APRIL 2001 A/T - 4L60E/4L80E, Cold Weather Performance
APRIL 2001 A/T - Service Procedure Changes
APRIL 2001 Heating, A/C - Passenger Side of Vehicle Colder/Warmer
APRIL 2001 Radio Display - Error Code Diagnosis/Repair
APRIL 2001 Special Tools - Power Steering System Analyzer
FEBRUARY 2001 M/T - Comes Out Of Gear
FEBRUARY 2001 Torque Converter - Bolt Design Update
NOVEMBER 2000 Suspension - Chassis Lubrication Importance
SEPTEMBER 2000 A/C Performance/Leaks - Diagnostic Procedure
SEPTEMBER 2000 Outside Rear View Mirror - Housing Turns Chalky/Dull
SEPTEMBER 2000 Quarter Glass - Wind Noise
AUGUST 2000 A/T - DTCs P0716 & P0717 Procedure Revised
AUGUST 2000 Cross Line - Warranty Information
AUGUST 2000 Fuel - Injection Pump Exchange Program Expanded
AUGUST 2000 Rear Wheel Mud Flap - Availability
JUNE 2000 PCM - Returned Product Feedback Program
MAY 2000 A/C - Refrigerant Recovery/Recharge Equipment
MAY 2000 A/T - 4L80E Engine Stalls and/or Surges at Stop
MAY 2000 Battery - Testing and Replacement
MAY 2000 Brake Fluid - Level & Filling Recommendations
MAY 2000 EVAP System - Service of Connectors
APRIL 2000 Warranty - GM Dealer Parts Procurement
MARCH 2000 Wheel Alignment Specifications - Revised
JANUARY 2000 Air Bag (SIR) On-Off Switch Kits, New Parts and Service
JANUARY 2000 Diesel Engine - Hard Start/Gray or White Smoke
JANUARY 2000 Engine - Running Hot And/Or Loss of Coolant
DECEMBER 1999 Battery - Testing & Replacement
NOVEMBER 1999 Accessory Receptacle/Cigar Lighter - Inoperative
NOVEMBER 1999 IP Dimmer Control - Proper Setting
NOVEMBER 1999 PROM - Powertrain Control Module Reprogramming
NOVEMBER 1999 Rear Side Door - Alignment Procedure
NOVEMBER 1999 Tires - Improper/Recommended Tire Pressure
OCTOBER 1999 A/T - 4L60E TECH II Diagnostic Tool
OCTOBER 1999 A/T - New Solenoid Testing Kit
OCTOBER 1999 Cassette Player - Cleaning and Maintenance
OCTOBER 1999 Clutch - Housing Noise/Clutch Won`t Engage
OCTOBER 1999 Cooling - Radiator Repair/Replacement Guidelines
OCTOBER 1999 Doors (Front) - Noisy/Binding/Won`t Stay Open.
OCTOBER 1999 Warranty - Generator Replacement
SEPTEMBER 1999 Brakes - Lead/Pull & Front Brake Wear
SEPTEMBER 1999 Transfer Case - Improved Automatic Transfer Case Fluid
SEPTEMBER 1999 Warranty - Labor Time Guide Updates, 09/99
JUNE 1999 A/T - Revised Turbine Shaft Seal Installer
JUNE 1999 Drivetrain - Rear Axle Lubricant Compatibility & Usage
JUNE 1999 Sunshade - Replacement Availability
JUNE 1999 Warranty - OE Chrome Plated Aluminum Wheel ID
MAY 1999 Engine - Revised Rocker Cover Sealing Procedure
APRIL 1999 Transfer Case - Use of Heat to Remove Fill/Drain Plugs
APRIL 1999 CD Changer - Will Not Eject CD
APRIL 1999 Instrument Panel - Upper Surface Reflection
APRIL 1999 SIR Light - Operation/Diagnostics/Repair
APRIL 1999 Steering - Squeak Noise in Column
APRIL 1999 Transfer Case - Four Wheel Drive Inoperative
MARCH 1999 A/T - 4L60-E DTC P1870 Diagnosis
MARCH 1999 Battery - Insulator Replacement & Caution
MARCH 1999 Battery - Testing Equipment Explained
MARCH 1999 SIR - Operating Vehicle with Warning Light On
DECEMBER 1998 Instrument Cluster - Identification Information Revised
DECEMBER 1998 Warranty - Notice of Delayed Start Process
NOVEMBER 1998 A/T - 1-2 Accumulator Piston/Outer Spring Replacement
NOVEMBER 1998 Tools - Adjuster Locknut Wrench
NOVEMBER 1998 Tools - Power Steering Bleeder Adapter
OCTOBER 1998 Alignment - Latest Available Specifications
OCTOBER 1998 Drivetrain - Recommended Axle Lubricant
OCTOBER 1998 New Windshield/Glass Urethane Adhesive Caulking Kit
OCTOBER 1998 RKE - Information on Reduced Range/Operation
SEPTEMBER 1998 DTC P1404 (False Low EGR Valve Pintle Position) Signals
SEPTEMBER 1998 Engine - Extended Cranking Time During Hot Restart
SEPTEMBER 1998 PCM Connector - Information on New Service Kits
SEPTEMBER 1998 Speedometer - Determining Accuracy
AUGUST 1998 Vehicle - Service Manual Delivery on Compact Disc (CD)
JUNE 1998 Owner`s Manual/Diesel Supplement - Differentiation
JUNE 1996 Warranty - Goodwrench® Service Lifetime Service Guarantee
NOVEMBER 1988 Battery - Diagnosis and Charging
|
