 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1999 Chevrolet Malibu V6-191 3.1L VIN M SFI
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1999 Chevrolet.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1999 Chevrolet Malibu V6-191 3.1L VIN M SFI
JANUARY 2006 Campaign - T/S/Hazard Switch Warranty Extension
Technical Service Bulletin Titles for 1999 Chevrolet Malibu V6-191 3.1L VIN M SFI
APRIL 2007 Tires - Proper Inflation Pressure Information
APRIL 2007 Body - Bumps or Rust Colored Spots in Paint
APRIL 2007 Body - Polypropylene Energy Absorber Replacement
APRIL 2007 Charging System - Low Voltage Display/Low/Dead Battery
APRIL 2007 Navigation System - Replacement Navigation Discs
APRIL 2007 Engine - Sealant Usage/procedures
APRIL 2007 A/T - Dexron®-VI(R) Fluid Availability
APRIL 2007 Engine - Oil Consumption Guideline Info.
MARCH 2007 Instruments - Reduced PRNDL Display Visibility
MARCH 2007 SRS - Front Passenger Seat Alteration Precautions
FEBRUARY 2007 Wheels/Tires - `Upsized` Wheel & Tire Information
FEBRUARY 2007 Engine, A/T - Shift/Driveability Concerns/MIL ON
JANUARY 2007 Locks - Key Code Securtiy Rules & Information
JANUARY 2007 Body - Hem Flange Repair
JANUARY 2007 Tires - Radial Force Variation (RFV) Information
JANUARY 2007 A/T - Grinding/Growling In PARK On An Incline
DECEMBER 2006 Restraints - Availability of Seat Belt Extenders
DECEMBER 2006 OnStar - Analog-Only Systems Information
NOVEMBER 2006 Brakes - Brake Warranty Service and Procedures
NOVEMBER 2006 Warranty - Claims Submission
NOVEMBER 2006 Engine - Unnecessary Flushing Services
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline Usage
NOVEMBER 2006 M/T - Hydraulic Clutch Bleeding Procedure Improvement
OCTOBER 2006 A/T - Fluid Leaking From Vent
OCTOBER 2006 Lighting - Replacement Guidelines for Lamp Condensation
OCTOBER 2006 Power Steering - Diagnostic Tips
OCTOBER 2006 Emissions - OBDII I/M Readiness Testing
OCTOBER 2006 Body - Metal Panel Adhesive Bonding Information
OCTOBER 2006 Interior - Eliminating Unwanted Odors
OCTOBER 2006 Tires - Tread Puncture Repair Procedures
SEPTEMBER 2006 Wheel Alignment - Recommendations/Requirements
SEPTEMBER 2006 Wheels - Pitting/Brake Dust On Chrome Wheels
SEPTEMBER 2006 Fuel System - GM Fuel System Treatment Plus(R)
SEPTEMBER 2006 Body - Distortion On Outer Glass Surfaces
SEPTEMBER 2006 Body - Exterior Emblem Discoloration/Peeling/Blistering
SEPTEMBER 2006 Wheels - Changing Procedures/Precautions
AUGUST 2006 Cooling System - DEXCOOL(R) Leak Detection Dye
AUGUST 2006 M/T - Normal Operating Characteristics
AUGUST 2006 Steering - Tilt Wheel/Column Fastener Troque Revision
AUGUST 2006 Tires - Original Equipment Tire Characteristics
AUGUST 2006 Cooling System - Coolant Recycling Information
AUGUST 2006 Engine Controls - MIL Function During I/M Testing
AUGUST 2006 Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
JULY 2006 Vehicle - Recreational (Dinghy) Towing Information
JULY 2006 A/C - Contaminated R134A Refrigerant
JULY 2006 Fuel System - E85 Fuel Usage Information
JUNE 2006 Windshield Wipers - Performance/Cleaning and Maintenance
JUNE 2006 Wheels - Aluminum Wheel Refinishing Recommendations
JUNE 2006 A/T - Dexron®(R) VI Fluid Availability
JUNE 2006 A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
MAY 2006 Fuel System - E85 Fuel Usage Recommendations
MAY 2006 A/T - Shift Lock Control Feature Function
MAY 2006 Engine - Rear Crankshaft Main Seal Oil Leaks
MAY 2006 Engine Controls - Reprogramming Warranty Coverage
MAY 2006 Electrical - Instrument Panel & General Wiring Repair
APRIL 2006 Audio System - Portable Audio Equipment Noise
APRIL 2006 Wheels/Tires - Slow Leaks From Aluminum Wheels
MARCH 2006 Body - Urethane Adhesives for Glass Applications
MARCH 2006 Battery, Charging System - Electrical Diagnostics
MARCH 2006 Electrical - Battery Charging Tips
MARCH 2006 Tires/Wheels - Wheel Weight Usage Precautions
FEBRUARY 2006 Accessories - DTC`s P0300, P1380, P1381
FEBRUARY 2006 Audio System - Radio Knob Availability
FEBRUARY 2006 A/T - Fluid Cooler Flushing
JANUARY 2006 Engine - Surface Conditioning Disc Usage Prohibition
JANUARY 2006 A/T - 4T65-E Fluid Leaks From Reverse Servo Cover
JANUARY 2006 Keyless Entry - Operational Characteristics
JANUARY 2006 Fuel System - Fuel Injector Maintenance Cleaning
DECEMBER 2005 Tires/Wheels - Nitrogen Gas Usage for Filling Tires
NOVEMBER 2005 Body - Paint-Less Dent Repair Recommendations
NOVEMBER 2005 A/C - New PAG Oil
OCTOBER 2005 Engine/Fuel System - Oil/Fuel Additive Recommendations
OCTOBER 2005 A/T - Diagnosing Fluid Leaks
OCTOBER 2005 A/T - Torque Converter Replacement
AUGUST 2005 Electrical - Harness Connection Inspection
JUNE 2005 A/C - Broken Rear Window Defogger Grid Detection
APRIL 2005 OnStar(R) - Cellular Antenna Replacement Parts
APRIL 2005 Restraints - Child Seat Top Teather Attachment Kits
MARCH 2005 Brakes - Wheel Cylinder Inspection Guidelines
MARCH 2005 Brakes - Revised System Specifications
MARCH 2005 OnStar(R) - Dealer Kits No Longer Available
MARCH 2005 OnStar(R)/Cell Phone - Integration
FEBRUARY 2005 Cooling System - Aluminum Radiator/Heater Core Info.
FEBRUARY 2005 A/T - New/Reman A/T Identification
FEBRUARY 2005 Instruments - GPS System Performance Degradation
FEBRUARY 2005 Restraints - Air Bag System Diagnostics
DECEMBER 2004 A/T - 4L60/65E No Reverse/2nd or 4th Gear
OCTOBER 2004 Lighting - Damage To Polycarbonate Headlamp Lenses
SEPTEMBER 2004 A/C - R-134a System Flushing Procedures
SEPTEMBER 2004 Brakes - Creaking Noise On Slow Speed Braking
AUGUST 2004 Lighting - Stop/Tail Lamps Inoperative/Water Inside
JULY 2004 Wheels - Plastic Wheel Nut Covers Loose/Missing
JULY 2004 Battery - Parasitic Drain
JUNE 2004 Fuel - Top Tier Detergent Gasoline Information
JUNE 2004 Engine - New Long Block Installation Precaution
APRIL 2004 Engine - Serpentine Drive Belt Wear Information
FEBRUARY 2004 A/T - 4L65E, 4L60E, 4L60, 200-4R Oil Pump Spring
NOVEMBER 2003 A/T - Shift Flare/DTC`s Set/SES Lamp ON
OCTOBER 2003 A/C - Unnecessary Compressor Replacement
OCTOBER 2003 Steering - New Outer Tie Rods/Replacement Procedure
OCTOBER 2003 Instruments - Fuel Gauge Needle Reset Procedure
JULY 2003 A/C - Catastrophic Compressor Failure Debris Removal
JUNE 2003 A/T - Oil Cooler Flushing Frequently Asked Questions
APRIL 2003 Suspension - Front Suspension Clunk/Rattle Noise
MARCH 2003 A/C - Automatic A/C Functional Description
MARCH 2003 A/C - System Sealers/Leak Detection Guidelines
MARCH 2003 A/T - 4T40-E/4T45-T Engineering Changes
MARCH 2003 Brakes - Brake Rotor Lateral Runout Correction
MARCH 2003 Brakes - Front Disc Brake Pulsation
MARCH 2003 Drivetrain - Revised Wheel Drive Shaft Replacement
FEBRUARY 2003 A/T - Oil Cooler Flushing/Flow Check Procedures
FEBRUARY 2003 Drive Axles - Improved Axle Nut Availability
FEBRUARY 2003 Engine - Polymer Coated Service Pistons
JANUARY 2003 Body - Weatherstrip Maintenance
DECEMBER 2002 A/T - 4T45E Engineering Changes/Overhaul Revisions
DECEMBER 2002 Engine - Piston Pin Removal/Installation Revision
OCTOBER 2002 Engine - Rocker Arm Bolt Tightening Specification Update
AUGUST 2002 Body - Rear Compartment Molding Loose/Broken
AUGUST 2002 Engine - Crankcase Flushing Recommendations
JULY 2002 Engine Controls - Revised DTC P0101
JUNE 2002 A/T - Serial Number/Site Code Locations/Identification
JUNE 2002 Computers & Controls - DTC`s Set When Replacing Modules
JUNE 2002 Engine - Identification Information
JUNE 2002 Engine Controls - MIL ON/Multiple DTC`s Set
APRIL 2002 Body - Water Leaks to Interior/Trunk
APRIL 2002 Brakes - Revised Specifications
APRIL 2002 Intake Manifold (Lower) - Revised Installation
MARCH 2002 Engine - New Prelube Tool
FEBRUARY 2002 Fuel Gauge - Revised Diagnostic Procedure
FEBRUARY 2002 Suspension - Front/Rear Squawking Noise
FEBRUARY 2002 Warranty - Parts Return Program Explained
JANUARY 2002 PCM - Intermittent Communication or DTC Codes Stored
DECEMBER 2001 Ignition Lock Cylinder/Switch - Replacement Revision
DECEMBER 2001 Tires - Sidewall Damage
NOVEMBER 2001 EVAP System - Special Tool Usage
OCTOBER 2001 A/T - Core Return Product Feedback Form
OCTOBER 2001 EVAP System - Monitor Strategy
SEPTEMBER 2001 Cooling Fan - Revised Ground Circuit Information
SEPTEMBER 2001 Fuel Injectors - Hard Starts/Poor Driveability/Misfire
SEPTEMBER 2001 RKE Transmitter - Correct Use of Labor Operation R4490
AUGUST 2001 Instrument Panel Compartment - Lock Replacement
AUGUST 2001 Passenger Front Seat - Rattles When Unoccupied
JUNE 2001 Diagnostic Worksheet - Usage
JUNE 2001 PCM/BCM Replacement - DTC`s B001/B1271/B1780 Set
JUNE 2001 Seat Belt System - Collision Replacement Guidelines
MAY 2001 A/C - Odor Emission in Hot Weather
MAY 2001 Hood - Will Not latch
MAY 2001 Key/Key Number/Security Chip - Replacement
MAY 2001 Tires - Bumper To Bumper Warranty Coverage
APRIL 2001 A/T - 4T40E/4T45E, Oil Pump Drive Inspection
APRIL 2001 A/T - Service Procedure Changes
APRIL 2001 Front Brake Pads - Correct Installation Procedure
APRIL 2001 Special Tools - Power Steering System Analyzer
FEBRUARY 2001 Instrument Panel - Cross Car Trim Plate Gap
FEBRUARY 2001 Rear Door - High Swing Effort
JANUARY 2001 Brake Pedal - Clunk/Rattle Noise
NOVEMBER 2000 Rear Suspension - Creak/Pop Noise
NOVEMBER 2000 Suspension - Chassis Lubrication Importance
SEPTEMBER 2000 A/C Performance/Leaks - Diagnostic Procedure
SEPTEMBER 2000 A/T - PWM Filter Removal
SEPTEMBER 2000 Outside Rear View Mirror - Housing Turns Chalky/Dull
AUGUST 2000 Cross Line - Warranty Information
JUNE 2000 A/T - 4T40-E/4T45-E Forward Clutch Piston Change
JUNE 2000 PCM - Returned Product Feedback Program
MAY 2000 A/C - Refrigerant Recovery/Recharge Equipment
MAY 2000 Battery - Testing and Replacement
MAY 2000 Brake Fluid - Level & Filling Recommendations
MAY 2000 EVAP System - Service of Connectors
APRIL 2000 Front Seat Shoulder Belt - Slow to Retract
APRIL 2000 Rear Seat Area - Road/Water Noise
APRIL 2000 Warranty - GM Dealer Parts Procurement
JANUARY 2000 Air Bag (SIR) On-Off Switch Kits, New Parts and Service
JANUARY 2000 Engine - Running Hot And/Or Loss of Coolant
JANUARY 2000 Trap Resistant Trunk Kit - Function/Installation
DECEMBER 1999 A/T - 4T40-E/4T45-E No Third and Fourth Gear
DECEMBER 1999 Battery - Testing & Replacement
DECEMBER 1999 Door Handle - Cold Air Entering Vehicle
NOVEMBER 1999 Accessory Receptacle/Cigar Lighter - Inoperative
NOVEMBER 1999 IP Dimmer Control - Proper Setting
NOVEMBER 1999 PROM - Powertrain Control Module Reprogramming
NOVEMBER 1999 Tires - Improper/Recommended Tire Pressure
OCTOBER 1999 A/T - New Solenoid Testing Kit
OCTOBER 1999 Cassette Player - Cleaning and Maintenance
OCTOBER 1999 Cooling - Radiator Repair/Replacement Guidelines
OCTOBER 1999 Seats - Premature Wear of Leather Material
OCTOBER 1999 Warranty - Generator Replacement
SEPTEMBER 1999 Warranty - Labor Time Guide Updates, 09/99
JULY 1999 Chime - Sounds When Key is Removed From Ignition
JUNE 1999 Radio - Weak FM Reception/No AM Reception
JUNE 1999 Warranty - OE Chrome Plated Aluminum Wheel ID
MAY 1999 Warranty - Deletion of Equipment
APRIL 1999 Bucket Seatback - Premature Wear of Leather Material
APRIL 1999 Instrument Panel - Upper Surface Reflection
APRIL 1999 SIR Light - Operation/Diagnostics/Repair
MARCH 1999 Battery - Insulator Replacement & Caution
MARCH 1999 Battery - Testing Equipment Explained
MARCH 1999 Cooling System - Coolant Leak
MARCH 1999 SIR - Operating Vehicle with Warning Light On
FEBRUARY 1999 Brakes - Squealing Noise Coming From Front
JANUARY 1999 Front/Rear Door - High Opening or Closing Effort
DECEMBER 1998 Instrument Cluster - Identification Information Revised
DECEMBER 1998 Warranty - Notice of Delayed Start Process
NOVEMBER 1998 Tools - Adjuster Locknut Wrench
NOVEMBER 1998 Tools - Power Steering Bleeder Adapter
OCTOBER 1998 Alignment - Latest Available Specifications
OCTOBER 1998 Door Handles - On White Painted Vehicles Turning Yellow
OCTOBER 1998 New Windshield/Glass Urethane Adhesive Caulking Kit
SEPTEMBER 1998 PCM Connector - Information on New Service Kits
SEPTEMBER 1998 Speedometer - Determining Accuracy
AUGUST 1998 Vehicle - Service Manual Delivery on Compact Disc (CD)
JUNE 1996 Warranty - Goodwrench® Service Lifetime Service Guarantee
NOVEMBER 1988 Battery - Diagnosis and Charging
|
