 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1997 Saturn SW2 L4-1.9L DOHC VIN 7
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1997 Saturn.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1997 Saturn SW2 L4-1.9L DOHC VIN 7
AUGUST 2004 Recall - Horn Replacement
NOVEMBER 1998 Recall - Horn Defective
APRIL 1997 Recall - Ignition Cylinder Malfunction
Technical Service Bulletin Titles for 1997 Saturn SW2 L4-1.9L DOHC VIN 7
APRIL 2007 Tires - Proper Inflation Pressure Information
APRIL 2007 Body - Bumps or Rust Colored Spots in Paint
APRIL 2007 Body - Polypropylene Energy Absorber Replacement
APRIL 2007 Charging System - Low Voltage Display/Low/Dead Battery
APRIL 2007 Navigation System - Replacement Navigation Discs
APRIL 2007 Engine - Sealant Usage/procedures
MARCH 2007 Instruments - Reduced PRNDL Display Visibility
MARCH 2007 SRS - Front Passenger Seat Alteration Precautions
FEBRUARY 2007 Wheels/Tires - `Upsized` Wheel & Tire Information
FEBRUARY 2007 Engine, A/T - Shift/Driveability Concerns/MIL ON
JANUARY 2007 Locks - Key Code Securtiy Rules & Information
JANUARY 2007 Engine - Unnecessary Crankcase & Subsystem Flushing
JANUARY 2007 Body - Hem Flange Repair
JANUARY 2007 Tires - Radial Force Variation (RFV) Information
JANUARY 2007 A/T - Grinding/Growling In PARK On An Incline
DECEMBER 2006 Restraints - Availability of Seat Belt Extenders
DECEMBER 2006 Tools - Essential Service Tool Update # 9
DECEMBER 2006 OnStar - Analog-Only Systems Information
NOVEMBER 2006 Warranty - Claims Submission
NOVEMBER 2006 Engine - Unnecessary Flushing Services
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline Usage
NOVEMBER 2006 Info - Cancel TSB 05-00-89-005
NOVEMBER 2006 Tools - Essential Service Tool Update # 8
NOVEMBER 2006 M/T - Hydraulic Clutch Bleeding Procedure Improvement
OCTOBER 2006 A/T - Fluid Leaking From Vent
OCTOBER 2006 Lighting - Replacement Guidelines for Lamp Condensation
OCTOBER 2006 Power Steering - Diagnostic Tips
OCTOBER 2006 Emissions - OBDII I/M Readiness Testing
OCTOBER 2006 Body - Metal Panel Adhesive Bonding Information
OCTOBER 2006 Interior - Eliminating Unwanted Odors
OCTOBER 2006 Tires - Tread Puncture Repair Procedures
SEPTEMBER 2006 Wheel Alignment - Recommendations/Requirements
SEPTEMBER 2006 Wheels - Pitting/Brake Dust On Chrome Wheels
SEPTEMBER 2006 A/T - Creeps In Neutral/Binds In Reverse/Click/Whine
SEPTEMBER 2006 Fuel System - GM Fuel System Treatment Plus(R)
SEPTEMBER 2006 Body - Distortion On Outer Glass Surfaces
SEPTEMBER 2006 Body - Exterior Emblem Discoloration/Peeling/Blistering
SEPTEMBER 2006 Wheels - Changing Procedures/Precautions
AUGUST 2006 Cooling System - DEXCOOL(R) Leak Detection Dye
AUGUST 2006 M/T - Normal Operating Characteristics
AUGUST 2006 Tires - Original Equipment Tire Characteristics
AUGUST 2006 Cooling System - Coolant Recycling Information
AUGUST 2006 Engine Controls - MIL Function During I/M Testing
AUGUST 2006 Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
JULY 2006 A/C - Contaminated R134A Refrigerant
JULY 2006 Locks - Lock Cylinder Components
JULY 2006 Fuel System - E85 Fuel Usage Information
JUNE 2006 Windshield Wipers - Performance/Cleaning and Maintenance
JUNE 2006 Wheels - Aluminum Wheel Refinishing Recommendations
JUNE 2006 A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
MAY 2006 Fuel System - E85 Fuel Usage Recommendations
MAY 2006 A/T - Shift Lock Control Feature Function
MAY 2006 Electrical - Instrument Panel & General Wiring Repair
APRIL 2006 Audio System - Portable Audio Equipment Noise
APRIL 2006 Wheels/Tires - Slow Leaks From Aluminum Wheels
MARCH 2006 Body - Urethane Adhesives for Glass Applications
MARCH 2006 Electrical - Battery Charging Tips
MARCH 2006 Tires/Wheels - Wheel Weight Usage Precautions
FEBRUARY 2006 Accessories - DTC`s P0300, P1380, P1381
FEBRUARY 2006 A/T - Fluid Cooler Flushing
JANUARY 2006 Engine - Surface Conditioning Disc Usage Prohibition
JANUARY 2006 Keyless Entry - Operational Characteristics
JANUARY 2006 Fuel System - Fuel Injector Maintenance Cleaning
DECEMBER 2005 Tires/Wheels - Nitrogen Gas Usage for Filling Tires
NOVEMBER 2005 Body - Paint-Less Dent Repair Recommendations
NOVEMBER 2005 A/C - New PAG Oil
OCTOBER 2005 Engine/Fuel System - Oil/Fuel Additive Recommendations
OCTOBER 2005 A/T - Diagnosing Fluid Leaks
OCTOBER 2005 A/T - Torque Converter Replacement
AUGUST 2005 Electrical - Harness Connection Inspection
JUNE 2005 A/C - Broken Rear Window Defogger Grid Detection
JUNE 2005 Fuel Pump - Special Warranty Extension Policy Expiration
APRIL 2005 Restraints - Child Seat Top Teather Attachment Kits
MARCH 2005 Brakes - Wheel Cylinder Inspection Guidelines
MARCH 2005 OnStar(R) - Dealer Kits No Longer Available
MARCH 2005 OnStar(R)/Cell Phone - Integration
FEBRUARY 2005 Cooling System - Aluminum Radiator/Heater Core Info.
FEBRUARY 2005 Restraints - Air Bag System Diagnostics
FEBRUARY 2005 Power Steering System - Noises/Leaks
JANUARY 2005 Audio System - CD/DVD Player Skips/Sluggish/Inoperative
OCTOBER 2004 Lighting - Damage To Polycarbonate Headlamp Lenses
SEPTEMBER 2004 A/C - R-134a System Flushing Procedures
AUGUST 2004 Body - Exterior Pinstripe/Vinyl Graphic Installation
JANUARY 2004 A/T - Shift Solenoid Service Applications
SEPTEMBER 2003 Brakes - Rear Brake Pulsation/Noise
MAY 2003 Engine Controls - No Start/Intermittent Stalling
MARCH 2003 Paint - Bumps or Iron Dust on Paint Surface
MARCH 2003 Engine - Remanufactured Engine Servicing
FEBRUARY 2003 Body - Rear Side Door Glass Inoperative/Falls Down
FEBRUARY 2003 Engine - Excessive Oil Consumption
JANUARY 2003 Cooling System - Coolant Discoloration Explanation
OCTOBER 2002 Body - Exterior Door/Windshield Glass Trim Peeling
MARCH 2002 Vehicle - Flat Towing Guidelines
FEBRUARY 2002 Front Cover Engine Mount Stud - New Design
DECEMBER 2001 Brakes - ABS DTC`s 47, 48, 51 Service Information
SEPTEMBER 2001 Sunroof - Diagnostics/Component Replacement
SEPTEMBER 2001 Sunroof Motor - Revised Timing Procedure
AUGUST 2001 Engine Cooling System - Sealer Usage
AUGUST 2001 Park Brake Lever - Button Replacement
JUNE 2001 Engine Mount - Measurements/Replacement Procedures
MAY 2001 A/T - MIL ON/DTC P0711 Set After Flat Towing
MAY 2001 EGR Valve - MIL ON/DTC P0401 Set
MAY 2001 Windows - Fogging In High Humidity Conditions
MARCH 2001 A/C - Odors On Vehicle Start Up
MARCH 2001 A/C - Odors at Vehicle Start Up
MARCH 2001 A/T - Harsh Shifts/No Shift/No TCC Operation
MARCH 2001 Drive Axle - Squeak/Squeal Noise
FEBRUARY 2001 Engine - Driveability Concerns/Cooling System DTC`s Set
DECEMBER 2000 Window Regulator - Binding/Clicking/Popping Noise
NOVEMBER 2000 Suspension - Chassis Lubrication Importance
OCTOBER 2000 Radio Antenna - Whistle Type Wind Noise
OCTOBER 2000 Right/Left Front Footwell Area - Water Leaks
OCTOBER 2000 Sunroof - Squeaks
JULY 2000 Firewall - Rattle Noise
JULY 2000 Rear Seat Back Trim - Updated Covers and Retainers
FEBRUARY 2000 A/C - Whistle at Highway Speeds with HVAC in Rec. Mode
DECEMBER 1999 A/C - Sizzling or Hissing Type Noise After Use
DECEMBER 1999 EVAP - Knocking or Rattle Noise at Right Front of Floor
NOVEMBER 1999 Audio System - A/M Band Noise
NOVEMBER 1999 Automatic Transaxle - Air Check Procedures
NOVEMBER 1999 Electrical - Numerous Systems Inoperative
NOVEMBER 1999 PDT - Maintenance Program Discontinuation
NOVEMBER 1999 Rear Compartment - Carpet Falls Down at Hinge Area
OCTOBER 1999 Door/Rocker Panel - Updated Service Information
OCTOBER 1999 MIL ON - DTC P0300/P0301-P0304, Misfire Diagnosis
SEPTEMBER 1999 A/C - New R&R Liquid Line to TXV or Suction Line to TXV
SEPTEMBER 1999 Remote Keyless Entry/Security System - Inoperative
AUGUST 1999 Engine Controls - Intermittent Lack of Power
AUGUST 1999 MIL ON - DTC P0340/P0341, Cam Sensor Circuit
JULY 1999 Engine - Mobile Lift Table
JULY 1999 Seat to Floor Panel Attachment - Stripped/Detached
JUNE 1999 Battery - New Charger
JUNE 1999 Engine (Internal) - Cleaning Products
APRIL 1999 Drivetrain - Design Changes to Differential Components
APRIL 1999 Ignition Coil - Available as a Service Part
APRIL 1999 Instruments - Car Runs Out of Fuel , Low Fuel Lamp OFF
APRIL 1999 Suspension - Design Changes to Strut Assemblies
APRIL 1999 Windshield - Rattle/Pop/Clicking On Rough Roads
MARCH 1999 Interior - Vehicle Vibration Between 48-54 MPH
MARCH 1999 M/T - Gear Rattle
MARCH 1999 Trap-Resistant Trunk Kit - Installation Procedure
FEBRUARY 1999 Carpet - Exposed Edges at Door Openings
FEBRUARY 1999 Wiper Arm (Rear) - Corroded To Motor Shaft
JANUARY 1999 Engine - Manual Update Regarding Piston Installation
JANUARY 1999 Locks - Ignition Lock Cylinder Coding Update
JANUARY 1999 Sunroof - Sunshade Material Separates From Sunroof
DECEMBER 1998 A/T Control Solenoid Valve - Design Changes
DECEMBER 1998 Aftermarket Cassette-Type Portable CD Adapters
DECEMBER 1998 Engine Controls - Tools to Retrieve Mode 6 Data
DECEMBER 1998 Headlamp - Assemblies May Rattle/Vibrate
DECEMBER 1998 Sunroof - Water Leaks Into Headliner
DECEMBER 1998 Tools - Required for Valve Guide Inspection
NOVEMBER 1998 Door Window (Front) - Clunking Noise When Operated
NOVEMBER 1998 Door/Weatherstrip - Corrosion/White Deposits
NOVEMBER 1998 Engine - Information on Remanufactured Cylinder Heads
NOVEMBER 1998 Rear Exterior Door Panel - Not Tight Against Structure
NOVEMBER 1998 Steering - Revised Inner Tie Rod Service Procedures
OCTOBER 1998 A/T - MIL ON with No DTCs After Transaxle Replacement
OCTOBER 1998 Seats - Revised Torque Specification for Front Adjuster
OCTOBER 1998 Steering Wheel - Revised Torque Specification
SEPTEMBER 1998 A/C - Loss of Airflow from A/C Outlets After Highway Use
SEPTEMBER 1998 Child Restraint Seat - Top tether Hardware Package
SEPTEMBER 1998 Door - Rattle, Buzz and/or Clunk from Front Door
SEPTEMBER 1998 Exhaust System - Pop Noise From Underbody At Idle
SEPTEMBER 1998 M/T - Knocking or Rattle Noise from Front of Vehicle
SEPTEMBER 1998 Power Steering - Pump Drive Shaft Seal Leak
SEPTEMBER 1998 Tires - Vehicle Code Regarding Tire Chain Disclosure
AUGUST 1998 Airbags - Supplemental Inflatable Restraint Switch Kits
AUGUST 1998 Front Fender - Possible Paint Chipping
AUGUST 1998 Rear Window Area - Creaks
JULY 1998 A/C - Changes to Oil Charge for R134a Compressors
JULY 1998 A/T Clutch Plate Assembly - Service Information
JULY 1998 Computers & Controls - PCM/ABS Module EEPROM Listing
JULY 1998 Engine - No Crank/Various Instrument MIL Lights ON
JULY 1998 Horn - Blows (Sounds) Inadvertently or is Inoperative
MAY 1998 A/C - Rattle/Buzz During Steady Throttle 1500-2500 RPM
MAY 1998 A/T Case Assembly - Fluid Leaks
MAY 1998 Radio - Ignition Static During Cold Engine Starts
APRIL 1998 A/C Hose - Rattles in Engine Compartment at Idle
APRIL 1998 Clicking, Ticking or Rubbing Noise from Odometer
APRIL 1998 M/T - Quill Bearing Seal Tool J43270
MARCH 1998 Door/Glass - Will Not Go Up or Down/Rattles
MARCH 1998 Interior - Replacement of Door Panel Inserts
FEBRUARY 1998 Air Bags - Update Regarding On-Off Switches
FEBRUARY 1998 Steering - Clunk/Rattle/Buzz Noise From Front
FEBRUARY 1998 Sunroof Sunshade - Binds/Rattles In Tracks
FEBRUARY 1998 Suspension - Rattle/Click from Rear When Turning
DECEMBER 1997 EGR System - MIL ON/EGR DTC`s Stored.
DECEMBER 1997 Front Strut - Creak/Squeak/Pop Noise on Bumps
DECEMBER 1997 Keyless Entry - Reduced Range Above 95 F. Interior Temp.
NOVEMBER 1997 Exhaust - Hoot or Moan Noise During Steady Throttle
NOVEMBER 1997 Keyless Entry/Security System - Information
OCTOBER 1997 Ignition Cylinder - Ignition Key Will Not Rotate
SEPTEMBER 1997 Keyless Entry/Security System - Programming Instructions
AUGUST 1997 Antenna Mast - Whistle or Groaning Noise
AUGUST 1997 Back-Up Lamp - Revised Electrical Schematic
AUGUST 1997 Dome Lamp/Security System - Stays ON/Will Not Arm
JULY 1997 A/T - Delay/Harsh Engagement Diagnosis
JULY 1997 Battery and Generator - Revised Diagnostics
JULY 1997 High Mount Stoplamp - Squeak/Rattle Noise
JULY 1997 PCM - MIL ON/DTC P0171 in PCM Memory
JULY 1997 Tools - Essential Service Tool Update #4
JUNE 1997 A/C - Odor at Vehicle Start Up
JUNE 1997 A/T Input Shaft - Design Changes
JUNE 1997 Generator and Engine Wiring Harness - Design Changes
JUNE 1997 MIL ON - Intermittent Loss of Power To Accessories
JUNE 1997 Main Body Wire Harness Assembly - Service Information
MAY 1997 Differential Bearings - Design Changes
MAY 1997 Differential End Play Checking - Information Update
MAY 1997 Engine/Exhaust - New Exhaust Manifold Gasket
APRIL 1997 Blower Relay - Service Manual Update
APRIL 1997 Differential/Pinion Gear Shaft - Design Changes
MARCH 1997 Keyless Entry/Security System - Service Information
MARCH 1997 M/T - Intermittently Pops Out of, or Sticks in 5th Gear
FEBRUARY 1997 Air Bag - Telltale ON with DTC 61 Set
FEBRUARY 1997 Air Bag System - Lamp ON/DTC 24 Stored in Memory
JANUARY 1997 A/T - Whining Noise in All Gears
JANUARY 1997 Antitheft - Intermittant No Crank During Cold Temps
JANUARY 1997 Paint - Exterior Color Code & Cross Reference
DECEMBER 1996 Cruise Control - Drops Out Intermittently & May Not Set
DECEMBER 1996 Locks - Second Design Lock System ID/Description
NOVEMBER 1996 A/T - Updated Oil Pump Output/Line Pressure Test
NOVEMBER 1996 Instruments - Cluster Assembly Rattle or Buzz Noise
NOVEMBER 1996 MIL ON - DTC P0741, TCC Actuator
OCTOBER 1996 Electrical - Fusible Link Color Correction & Change
OCTOBER 1996 Sunroof - Switch Assembly Removal & Installation Update
SEPTEMBER 1996 Policy - Core and Failed Parts Return Programs
AUGUST 1996 A/T - New Torque Converter Housing/Oil Pump Wear Plate
AUGUST 1996 Brakes - New Bolt Torque Retention Compound for Caliper
AUGUST 1996 Brakes - Noise/Pulsation From Front
NOVEMBER 1988 Battery - Diagnosis and Charging
|
