 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1997 Ford Truck Explorer 2WD V6-245 4.0L SOHC VIN E EFI
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1997 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1997 Ford Truck Explorer 2WD V6-245 4.0L SOHC VIN E EFI
OCTOBER 2001 Recall - Firestone Tire Recall Supplement
DECEMBER 2000 Recall - Sway Bar Link Replacement
DECEMBER 2000 Recall - Throttle Body Replacement
SEPTEMBER 2000 Recall - Firestone Tire Recall
JULY 2000 Recall - Daytime Running Lamp Non-Compliance
MARCH 2000 Recall - Airbag Deactivation Shunt Replacement
MARCH 1999 Recall - Speed Control Cable Replacement
MAY 1998 Recall - Negative Cable (Ground) Jump Starting Location
FEBRUARY 1998 Recall - Aftermarket Towing Harness Installation
Technical Service Bulletin Titles for 1997 Ford Truck Explorer 2WD V6-245 4.0L SOHC VIN E EFI
MARCH 1997 Recall - Fuel Vapor Management Valve Faulty
Technical Service Bulletin Titles for 1997 Ford Truck Explorer 2WD V6-245 4.0L SOHC VIN E EFI
JULY 2001 Campaign - Cam Chain Guide Additional Warranty Coverage
APRIL 2001 Campaign - Front Cam Chain Guide Extended Coverage
NOVEMBER 2000 Campaign - Camshaft Chain Tensioner & Intake Gasket
SEPTEMBER 2000 Campaign - Supplemental Tire Inflation Label
SEPTEMBER 2000 Campaign - Sway Bar Link Extended Coverage
JANUARY 1999 Campaign - Throttle Body Plate Sticks Closed
FEBRUARY 1998 Campaign - Fuel Gauge/Sender Assembly
OCTOBER 1997 Campaign - Oil Pump Drive Assembly Replacement
Technical Service Bulletin Titles for 1997 Ford Truck Explorer 2WD V6-245 4.0L SOHC VIN E EFI
JANUARY 2007 Steering - Mercon V(R) Fluid Usage
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
NOVEMBER 2006 A/T - 5R44E/5R55E Part Level Change/Compatibility
OCTOBER 2006 A/C - Heater Core Electrolysis/Leakage
SEPTEMBER 2006 Engine - Reman Engine Head Gasket Identification
JULY 2006 A/T - Mercon V ATF Usage
DECEMBER 2004 Engine Controls - General PCM Programming Procedures
NOVEMBER 2003 A/T - No 2nd, 3rd Gear/No Engine Braking/DTC`s Set
OCTOBER 2003 Emissions - MIL ON/DTC`s Stored/Check Fuel Cap Lamp ON
SEPTEMBER 2003 Keyless Entry System - Service Tips
JULY 2003 A/T - Cooler Flushing Service Tips
DECEMBER 2002 Drivetrain - Neutral Tow Availability
NOVEMBER 2002 Engine Controls - Engine Surge/Rolling Idle/DTC`s Set
OCTOBER 2002 Engine - Cylinder Head Straightedge Surface Check
SEPTEMBER 2002 A/T - Inadvertent Shift Interlock Disabling
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
JUNE 2002 Aluminum Engine - New Cleaners/Service Tips
FEBRUARY 2002 Engine Control - MIL ON, DTC P0300 or P0301 Set
FEBRUARY 2002 Engine - Aluminum Block/Head Machining
JANUARY 2002 Engine Head Gasket - Approved Replacement Procedures
JANUARY 2002 Engine Oil - Oil Recommendations/Applications
JANUARY 2002 Wheels/Tires - Road Force Measurement Equipment
DECEMBER 2001 Engine - Oil System Priming Procedures
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Hood Lamp Switch - Revised
OCTOBER 2001 Driveability - Vacuum Leak Detection
MAY 2001 Wire Harness - Terminal Repair Kit
MAY 2001 Emissions/Engine Controls - Driveability Diagnosis
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
NOVEMBER 2000 Accelerator Pedal Bracket - Cracks or Fatigues
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
OCTOBER 2000 Climate Control - Blower Control Service Tips
OCTOBER 2000 Fuel Pump - Driveability Lack of Fuel Pressure
MAY 2000 A/T Cooler - Fluid Leaks at Radiator
DECEMBER 1999 Engine - Knocking Noise From Left Side at Start Up
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Locks - Lock Service Packages Available
NOVEMBER 1999 EVAP - DTC`s P0442/P0455/MIL ON/No Driveability Concerns
NOVEMBER 1999 Engine - No Start/Parked On Incline w/Nose Down
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
OCTOBER 1999 Blower Motor - Burning Odor/Smoke/Rustling Noise
OCTOBER 1999 Front Bumper Bracket - Replacement Tip
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
SEPTEMBER 1999 Brakes - Vibration/Inspection Service Tips
SEPTEMBER 1999 A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
JULY 1999 A/T - Transmission Flush and Fill Tool Available
JUNE 1999 Comprehensive Noise/Vibration/Harshness Procedure
JUNE 1999 Paint - Rough Texture
JUNE 1999 Engine - MIL Lamp ON/DTC`s P0171/P0174/P1131/P1151
MAY 1999 A/T - 4R70W (Remanufactured) Delayed or No 2-3 Upshift
MAY 1999 A/C - Erratic or Insufficient Temperature Control
MAY 1999 Interior Door Trim Panel - Replacement Tip
MAY 1999 Motor Oil - Viscosity Grade Recommendation
MAY 1999 PCM - Harsh Downshift From 3-1/Hesitates/Lacks Power
APRIL 1999 Side Doors - Wind Noises
MARCH 1999 A/T - Cold Fluid Level Checking
MARCH 1999 PCM - Reprogramming Out of Vehicle
FEBRUARY 1999 Windshield - Water Leaks
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Composite Fuel Rail - Service Tip
DECEMBER 1998 Front Seat Back - Recliner Lever Bent
DECEMBER 1998 Interior Trim - Vinyl Surface Repair Tips
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
NOVEMBER 1998 A/C - Condensate Drips Onto Passenger Floor
NOVEMBER 1998 A/C - Lack Of Temperature Control
NOVEMBER 1998 A/T - Multiple DTC`s Stored Diagnosis
NOVEMBER 1998 Air Intake Tube - Contacting Hood Insulator
NOVEMBER 1998 Engine - Lean Driveability Symptoms
OCTOBER 1998 Exhaust System - Boom/Grunt/Groan/Moan/Vibration
OCTOBER 1998 Throttle Body - Hesitation/Surge/Sticky Accelerator
OCTOBER 1998 Exhaust System - Buzzing/Rattling Noise
OCTOBER 1998 Power Seat Switch - Button Comes Off
SEPTEMBER 1998 Paint - Materials For After Warranty/Warranty Repairs
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
SEPTEMBER 1998 Steering - Drift/Pull/Tire Wear/Poor Ride Quality
AUGUST 1998 Floor Mat - Installation Procedure Service Tip
AUGUST 1998 Evaporative Emission Canister - Components Availabilit
JULY 1998 ABS - False Activation/DTCs Stored/Grinding/Whining
JULY 1998 Steering Column - Clunking Felt Rocking Steering Wheel
JULY 1998 Relays - Multiple Electrical Concerns
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
JUNE 1998 Transfer Case - Water Ingestion Through Vent Tube
MAY 1998 Fuel Injectors - Non Warranty Reimbursement Testing
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - Elimination Of Sanding Rotors And Drums
MARCH 1998 Hub-Mount Brake Rotor Machining Equipment
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 A/T - 4R44E/5R55E Whistling/Hissing Noise At Idle
FEBRUARY 1998 Paint - Surface Defect Removal Without Repainting
FEBRUARY 1998 Air Conditioning - Musty/Mildew Type Odors
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
JANUARY 1998 Bumper - Rust Staining
JANUARY 1998 Exhaust - Booming Noise 700-800 RPM On Cold Startups
JANUARY 1998 Lamp Outage Module Housing/Components - Melting
JANUARY 1998 Trailer Wiring - Lamp Outage Module Damage
DECEMBER 1997 Console - CD Player Skips/Squeaks/Vibration
NOVEMBER 1997 A/C - Temperature Control Inoperative
NOVEMBER 1997 Remote Keyless Entry - Diagnostic Service Tips
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
OCTOBER 1997 Clutch - Hard to Depress/Premature Slave Cylinder Wear
OCTOBER 1997 EGR DPFE Sensor - Voltage Range Revision
OCTOBER 1997 Transfer Case - Shudder/Binding In Tight Turns
SEPTEMBER 1997 Universal Joint - Greasable Design Availability
SEPTEMBER 1997 Heater Core - On Car Pressure Test For Warranty Claim
SEPTEMBER 1997 PCM - MIL ON/DTC P0446 Set
SEPTEMBER 1997 A/T - 5R55E Extension Lube Orifice Missing
SEPTEMBER 1997 Cooling System - Thump Noise/Gauge Fluctuation
AUGUST 1997 Engine Block Heater - Coolant Leak
AUGUST 1997 Rear View Mirror - Reattachment
JULY 1997 A/T - 5R55E/4R44E New Direct Clutch Steel Plates
JULY 1997 A/T - Overdrive Drum Speed Sensor Deleted
JULY 1997 PCM - MIL ON/DTCs P0133 and P0153 In Memory
JUNE 1997 Throttle Body - Whoosh Noise Heard on Acceleration
JUNE 1997 Rear Washer Pump - Schematic Revision
MAY 1997 A/T - AODE/4R70W Erratic/Prolonged 1-2 Shift
MAY 1997 Remote Antitheft Personality Transmitter - Reprogramming
MAY 1997 A/C - Refrigerant Oil Refill Capacity
MAY 1997 A/C - Insufficient Cooling/ Compressor Failure
APRIL 1997 PCM - Reprogramming Tips
APRIL 1997 EATC - Service Tips
MARCH 1997 Exhaust System - Booming Noise/Vibration at Idle
FEBRUARY 1997 Frame - Rivet Replacement with Bolts Service Tip
FEBRUARY 1997 A/C - R134a Tracer Dye and Three O Ring Spring Couplers
FEBRUARY 1997 Remote Keyless Entry - Inoperative
FEBRUARY 1997 Transfer Case - Shudder/Binding Diagnostics
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
NOVEMBER 1996 New Digital Transmission Range Sensor - Service Tip
OCTOBER 1996 Mass Air Flow Sensor - Assembly Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
SEPTEMBER 1996 A/C - New O Ring Applications
SEPTEMBER 1996 A/C O Ring - Availability and Applications
SEPTEMBER 1996 Paint - Codes and Colors/Cross Reference
AUGUST 1996 A/T - 5R55E Orange Tag Service Procedure
AUGUST 1996 A/T - 5R55E Features and Components Description
|
