 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1994 Mercury Sable V6-232 3.8L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1994 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1994 Mercury Sable V6-232 3.8L
MARCH 2000 Recall - Airbag Deactivation Shunt Replacement
APRIL 1999 Recall - Speed Control Cable Modification
DECEMBER 1998 Recall - Subframe Plate Corrosion
MAY 1998 Recall - Headlamp Switch
APRIL 1997 Recall - Speed Control Cable Modifications
MARCH 1997 Recall - Engine Cooling Fan Motor Circuit
DECEMBER 1995 Recall - Engine Cooling Fan Circuit Modification
Technical Service Bulletin Titles for 1994 Mercury Sable V6-232 3.8L
FEBRUARY 2000 Campaign - Engine Head Gaskets
MAY 1998 Campaign - Head Gasket Failure, Extended Coverage
JANUARY 1995 Campaign - Keyless Entry System Transmitters
JUNE 1994 Campaign - Fuel Tank Contamination
Technical Service Bulletin Titles for 1994 Mercury Sable V6-232 3.8L
JULY 2006 A/T - Mercon V ATF Usage
SEPTEMBER 2003 Keyless Entry System - Service Tips
JULY 2003 A/T - Cooler Flushing Service Tips
APRIL 2003 Wipers/Washers - Wiper Motor Transfer Tips
OCTOBER 2002 Engine - Cylinder Head Straightedge Surface Check
OCTOBER 2002 A/C System - Diagnosis and Service Tips
SEPTEMBER 2002 A/T - Inadvertent Shift Interlock Disabling
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
JUNE 2002 Aluminum Engine - New Cleaners/Service Tips
FEBRUARY 2002 Engine - Aluminum Block/Head Machining
JANUARY 2002 Engine Head Gasket - Approved Replacement Procedures
JANUARY 2002 Engine Oil - Oil Recommendations/Applications
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Hood Lamp Switch - Revised
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
SEPTEMBER 1999 Brakes - Vibration/Inspection Service Tips
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
APRIL 1999 Speedometer - Needle Wavers And Sticks
APRIL 1999 Side Doors - Wind Noises
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
NOVEMBER 1998 Engine - Lean Driveability Symptoms
OCTOBER 1998 Exhaust System - Buzzing/Rattling Noise
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JULY 1998 A/T - Flushing Oil Cooler And Lines
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
MAY 1998 A/T - AX4N No 4th Gear/DTC`s P0734/P0761/648 Set
MAY 1998 Fuel Injectors - Non Warranty Reimbursement Testing
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Antilock Brakes - Cycling On Rough Roads
MARCH 1998 Brakes - Elimination Of Sanding Rotors And Drums
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Hub-Mount Brake Rotor Machining Equipment
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Rear Disc Brakes - Squealing Noise
MARCH 1998 Cooling System - Coolant Loss And/Or Overheating
FEBRUARY 1998 A/T - AX4S/AX4N New Transaxle Fluid
FEBRUARY 1998 A/T - Intermittent Neutral Condition/No Forward/Reverse
FEBRUARY 1998 Air Conditioning - Musty/Mildew Type Odors
NOVEMBER 1997 Remote Keyless Entry - Diagnostic Service Tips
NOVEMBER 1997 A/T - AX4S/AX4N Codes Stored After Replacement
OCTOBER 1997 Fuel System - Fuel Odor Inside Passenger Compartment
SEPTEMBER 1997 Brake and Rotor - Service Tips
SEPTEMBER 1997 Heater Core - On Car Pressure Test For Warranty Claim
SEPTEMBER 1997 Radio - Am Band Static While Driving
AUGUST 1997 A/C Compressor - Moan
AUGUST 1997 Rear View Mirror - Reattachment
JULY 1997 Headlamps - Operate Intermittently
MAY 1997 A/C - Refrigerant Oil Refill Capacity
MAY 1997 Engine Cooling Fan Module - Service Information
APRIL 1997 EATC - Service Tips
DECEMBER 1996 Rear Tire - Inner Edge Wear
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Mass Air Flow Sensor - Assembly Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
SEPTEMBER 1996 A/C - New O Ring Applications
SEPTEMBER 1996 A/C O Ring - Availability and Applications
SEPTEMBER 1996 Suspension - Shudder On Acceleration From Standstill
AUGUST 1996 A/T - AX4S New Main Control Cover and Pan Gasket
JULY 1996 A/C System - Service TSB List
JULY 1996 Fuel Pump - Gurgles After Hot Restart
MAY 1996 Fuel - California Reformulated Gasoline
APRIL 1996 A/T - AX4S/AX4N Driveline Noises
MARCH 1996 Air Bag - Light Flashing/Diagnostic Code 51 Set
MARCH 1996 Engine - Intermittent Hesitation/No Start/Stalling
FEBRUARY 1996 A/T - AX4N Clicking Noise On Reverse Engagement
FEBRUARY 1996 A/T - Revised GROB Spline Drive Joint
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
JANUARY 1996 A/T - AX4S (AXODE) Rear Sun Gear Bearing
JANUARY 1996 A/T - AXOD, AX4S (AXODE) Revised Forward Sprag Race
JANUARY 1996 A/T - AXOD, AXODE, AX4S, AX4N Revised Spline Drive Joint
JANUARY 1996 A/T - Case Breakage at Rear Planet Support Snap-Ring
DECEMBER 1995 A/T - AX4N/AX4S Bonded Separator Plate Gaskets
DECEMBER 1995 Engine - Rocker Arm Squeak/Chirp/Knock Noise
NOVEMBER 1995 Wind Noise - Summary Of Known Repairs
OCTOBER 1995 Air Bag Modules - Discolored/Marred Covers
OCTOBER 1995 Power Windows - Groaning Noise
SEPTEMBER 1995 Power Steering - Grunt And/Or Groan
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
SEPTEMBER 1995 Temperature Gauge - Fluctuation/Inaccurate
AUGUST 1995 Transaxle Clutch - Clearance Revision
AUGUST 1995 A/T - AX4N Electronic Shift Solenoid Applications
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 A/T - AX4N Rear Planet Support Retaining Ring
JULY 1995 A/T - Revised Torque Converter Identification Codes
JULY 1995 Wheel Cover - Distorted or Melted
JULY 1995 A/T - AX4S Front Turbine Shaft O-Ring Change
JULY 1995 A/C Evaporator Core - On Vehicle Leak Test Requirement
JULY 1995 Temperature Gauge - Reads Low/Erratic
MAY 1995 Antenna - Warranty Manual Revision
MARCH 1995 Blower Motor - Chirp/Squeak
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
MARCH 1995 A/T - AX4S Rear Sun Gear/Drum Bearing Service
MARCH 1995 PCM - Application/Identification Chart
FEBRUARY 1995 A/T - AX4S/AX4N TSS Sensor Air Gap Measurements Change
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 Electronic Fuel Gauge - Erratic Readings
JANUARY 1995 Radiator - New Manufacturing Process
JANUARY 1995 Accelerator Cable - Diagnostic Procedure
JANUARY 1995 A/T - AXOD/E Accumulator Springs Identification
JANUARY 1995 A/T - AXODE Erratic or High Line Pressure
JANUARY 1995 A/T - Delayed Engagement, Shift Errors, MLPS Codes
JANUARY 1995 A/T - Delayed or No Forward/Reverse, Shifts Out of Gear
JANUARY 1995 A/T - Drive Axle and Wheel Lug Nut Torque Specifications
JANUARY 1995 A/T - TCC Pulsing On/Off, High Line Pressure, No Codes
DECEMBER 1994 A/C - Release of R134a Fluorescent Dye
DECEMBER 1994 A/T - AX4S/AX4N DTC`S P0500/P1785/P1784 Set
DECEMBER 1994 Engine - No Crank Condition
DECEMBER 1994 Throttle Position Sensor - Function and Diagnostic Tips
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 A/T - AX4S Transaxle Exchange Program
NOVEMBER 1994 A/T -AXOD/AXODE/AX4S Gear Engagement Concern
NOVEMBER 1994 Front Brakes - Thumping/Clacking Noise While Braking
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
OCTOBER 1994 Exhaust System - Sulfur Smell/Rotten Egg Odor
OCTOBER 1994 A/T - AX4S/AXOD New Lube Tubes
OCTOBER 1994 Fuel Tank - Fuel Slosh Noise
OCTOBER 1994 A/C - Oil Visible At Spring Lock Couplers
OCTOBER 1994 A/T - AXOD/AXODE/AX4S Retaining Ring Orientation
OCTOBER 1994 A/T - AXODE/AX4S No Gear Engagement/Noise
SEPTEMBER 1994 Ignition Switch - Harness Connector Non-Mating
AUGUST 1994 Rear View Mirror - Detaches From Windshield
AUGUST 1994 A/T - AX4S/AX4N Shift Concerns/Damage
AUGUST 1994 Engine - Lack of Power/Hesitation/Stumble/Stall
AUGUST 1994 Heated Exhaust Gas Oxygen Sensor - Application Chart
JULY 1994 A/C Compressor - Service Tips
JULY 1994 Power Door Lock Actuators - Service Part Return
JUNE 1994 ATC/EATC - Cold Engine Lockout Operation
JUNE 1994 Fuel Tank - Obsolete Part Return
JUNE 1994 Glove Compartment Door - Opens Quickly
MAY 1994 Engine - Rocker Arm Squeak/Chirp/Knock
MAY 1994 Headliner - Objectionable Odor
MAY 1994 Lower Intake Bolt/Stud - Revised Torque Procedure
MAY 1994 Seat Sensor Switch - Causes Lock Malfunction
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
APRIL 1994 Evaporator Core - Replacement
APRIL 1994 Rear Window Area - Squeaking Noise
MARCH 1994 A/T - AX4N Service Procedure For Orange Tagged Units
MARCH 1994 A/T - AXOD/AXODE/AX4S Leak At Torque Converter
MARCH 1994 Antilock Brakes - Pedal Feels Like It Has Extra Travel
FEBRUARY 1994 A/T - AX4S Torque Converter Revision
FEBRUARY 1994 Remote Keyless Entry System - Service Tips
JANUARY 1994 A/C - Manifold and Tube Assembly Replacement
JANUARY 1994 EATC - Blower Motor Inoperative In Automatic Mode
JANUARY 1994 A/T - AX4S Orange Do Not Service Tag
JANUARY 1994 Fuel Pressure Regulator - Obsolete Part Return
JANUARY 1994 A/T - AXOD/E Erratic Shifts
JANUARY 1994 A/T - Forward Sprag Upgrade
JANUARY 1994 A/T - Modification to Improve Gear Lubrication
DECEMBER 1993 Heated Backlite - Inoperative
DECEMBER 1993 Power Steering System - Noisy
DECEMBER 1993 Rear Tension Strut - Clunk or Rattle
DECEMBER 1993 Starter Solenoids and Drives - Obsolete Parts Return
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Paint - Codes/Cross References
NOVEMBER 1993 Paint - Codes and Supplier Stock Numbers
NOVEMBER 1993 Remote Keyless Entry System - Service Highlights
NOVEMBER 1993 Blower Speed Control - Enhancement/Changes
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine - Lack of Power/Hesitation/Stumble/Stalls
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
OCTOBER 1993 A/T - Failsafe Modes
JUNE 1993 A/T - AXOD/E Electrical Diagnostic Information
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1990 A/T - Engine Vacuum Testing
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
|
