 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1992 Ford Truck Aerostar 2WD V6-245 4.0L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1992 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1992 Ford Truck Aerostar 2WD V6-245 4.0L
JUNE 1999 Recall - Accessory Power Circuit Relay Installation
FEBRUARY 1992 Recall - Front Door Latch Release Cable Replacement
Technical Service Bulletin Titles for 1992 Ford Truck Aerostar 2WD V6-245 4.0L
JULY 1994 Campaign - RABS Module Inspection/Replacement
Technical Service Bulletin Titles for 1992 Ford Truck Aerostar 2WD V6-245 4.0L
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
JULY 2003 A/T - Cooler Flushing Service Tips
SEPTEMBER 2002 A/T - Inadvertent Shift Interlock Disabling
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
JULY 2002 Engine - Noise/Vibration/No Crank/No A/T Engagement
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Engine - Carbon Knock On Acceleration
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
NOVEMBER 1998 Engine - Lean Driveability Symptoms
NOVEMBER 1998 Front Drive Axle - Fluid Leak From Vent
OCTOBER 1998 Exhaust System - Buzzing/Rattling Noise
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
MAY 1998 Fuel Injectors - Non Warranty Reimbursement Testing
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brake Service - Service Tips
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Vehicle - Towing Behind RVs Guidelines
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
FEBRUARY 1998 Paint - Procedure/Products For Plastic Service Parts
FEBRUARY 1998 Air Conditioning - Musty/Mildew Type Odors
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
DECEMBER 1997 Blower Motor - Chirping/Squeaking
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
SEPTEMBER 1997 Universal Joint - Greasable Design Availability
AUGUST 1997 Rear View Mirror - Reattachment
AUGUST 1997 Sheet Molding Composite - Body Repair
FEBRUARY 1997 Frame - Rivet Replacement with Bolts Service Tip
DECEMBER 1996 Sliding Door Latch - Damaged or Misadjusted
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
NOVEMBER 1996 Steering Wheel - Clicking Noise Heard When Turning
OCTOBER 1996 Mass Air Flow Sensor - Assembly Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Speedometer/Odometer - (Programmable) Pointer Waiver
SEPTEMBER 1996 A/C - New O Ring Applications
SEPTEMBER 1996 A/C O Ring - Availability and Applications
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
AUGUST 1996 Rear Axle - Whine/Howl At Light Throttle
JULY 1996 A/C System - Service TSB List
JULY 1996 Accessory Drive Belt - Squeal or Hoot Noise
JUNE 1996 Differential - Chatter On Turns
MAY 1996 Fuel - California Reformulated Gasoline
MAY 1996 Left Rear Tire - Rubs On Wheelhouse Inner Panel
MARCH 1996 Steering - Rapping or Clanging Noise
JANUARY 1996 Instrument Panel/Windows - Rattle/Buzz
JANUARY 1996 A/T - A4LD Bellhousing & Pump Interchange
JANUARY 1996 A/T - A4LD Malfunction Indicator Lamp Flashing, Code 24
JANUARY 1996 A/T - A4LD Support Ring Identification
JANUARY 1996 A/T - A4LD, 4R44E/4R55E Pump Interchangeability
DECEMBER 1995 Door Lock Cylinder - Loose in Replacement Door
NOVEMBER 1995 PCM - MIL ON/Code 124 Set
OCTOBER 1995 Air Bag Modules - Discolored/Marred Covers
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
AUGUST 1995 Air Conditioning - Poor Performance
AUGUST 1995 Body - Roof Panel and Drip Rail Repairs
AUGUST 1995 Replacement Sliding Door - Service Tip
JULY 1995 A/C Evaporator Core - On Vehicle Leak Test Requirement
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
MAY 1995 Connector, DIS Ignition Revised
MAY 1995 Cooling System - Coolant Loss
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 Rocker Panel - Front/Rear Rust Perforation
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 Electronic Fuel Gauge - Erratic Readings
JANUARY 1995 Rear Main Oil Seal Replacement - Service Tip
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Front Door Glass - Binds During Downward Travel
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
SEPTEMBER 1994 Sliding Door Weatherstrip - Worn or Damaged
SEPTEMBER 1994 Engine - Revised Torque Procedures and Specifications
AUGUST 1994 Rear View Mirror - Detaches From Windshield
AUGUST 1994 Heated Exhaust Gas Oxygen Sensor - Application Chart
AUGUST 1994 Speedometer - Recalibration Tips
JULY 1994 A/C Compressor - Service Tips
JULY 1994 Accelerator Cable - Service Procedures/Tips
JULY 1994 Exhaust System - Sulfur/Rotten Egg Smell
JULY 1994 Passenger Seat Back - Rattles When Unoccupied
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 Engine - Multiple Oil Leaks
MAY 1994 A/T - A4LD One Way Clutch Service
MAY 1994 Headliner - Objectionable Odor
APRIL 1994 Temperature Gauge - Reads High
MARCH 1994 A/T - A4LD Servo Cover Heat Shield
JANUARY 1994 A/T - A4LD Cooler Line Fittings
JANUARY 1994 A/T - Binding Condition In Park
JANUARY 1994 A/T - E40D Second Gear Starts
JANUARY 1994 A/T - Pump Damage After Overhaul
DECEMBER 1993 Heated Backlite - Inoperative
DECEMBER 1993 Power Steering System - Noisy
DECEMBER 1993 Starter Solenoids and Drives - Obsolete Parts Return
DECEMBER 1993 A/C and Accessory Drive Belt - Breakage/Squeal
DECEMBER 1993 Front Disc Brakes - Popping/Clunking Noise
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
NOVEMBER 1993 Parking Brake - Does Not Ratchet On First Application
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
AUGUST 1993 Brake Computer Module - Obsolete Service Part Return
AUGUST 1993 Rear Anti-Lock Brakes - Adverse Characteristics
AUGUST 1993 A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
AUGUST 1993 A/T - A4LD Premature Converter Bushing Failure
JULY 1993 Antilock Brakes - Service Tips
JULY 1993 Deposit Resistant Fuel Injectors - Identification
JULY 1993 A/T - Increase In RPM During Light Throttle 2-3 Upshifts
JULY 1993 Bumper - Loose or Unattached Ends
JULY 1993 Muffler - Corrodes Prematurely
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
MAY 1993 Brakes - Sticking/Binding/Grabbing
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
APRIL 1993 A/T - A4LD 4-3 Gear Flare, No Engagement in O/D
MARCH 1993 A/T - Shift Selector Indicates Incorrect Gear
MARCH 1993 Fuel Line - Knocking Noises
JANUARY 1993 Cooling System - Proper Fluid Concentrations
DECEMBER 1992 A/C - FX15 Clutch Application Chart
DECEMBER 1992 Cooling Fan Blade - Revised Design Available
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
DECEMBER 1992 Fuel Pump - Noise/Whine
DECEMBER 1992 A/T - A4LD No Reverse
NOVEMBER 1992 A/C Compressor - Oil Recovery & Measuring Procedure
NOVEMBER 1992 MIL ON/No Codes Set Explanation
NOVEMBER 1992 Digital Fuel Gauge - Displays CO Error Code
OCTOBER 1992 Rear Brakes - Squeal Noise When Cold
SEPTEMBER 1992 A/C Clutch - Slips At High Ambient Temperature
AUGUST 1992 A/C Compressor - Oil Recovery/Measuring Procedures
AUGUST 1992 Front Seat - Clunks On Acceleration/Stops/Turns
AUGUST 1992 Noise/Vibration/Ride Harshness - Diagnostic Chart
AUGUST 1992 A/T - A4LD No 4th Gear
JULY 1992 Front Brakes - Popping or Clunking Noise
JULY 1992 Rear Seat Headphone Speaker - Control Knob Available
JUNE 1992 A/C Compressor - Noise
JUNE 1992 Nylon Fuel Lines - Servicing Procedure
JUNE 1992 Rear Wiper/Washer Circuit - Repeatedly Blows Fuses
MAY 1992 Emission Control - Part/System Name Standardization
MAY 1992 Fuel System - Fuel Stabilizer For Extended Storage
MAY 1992 Wipers - Clicking During Intermittent Operation
APRIL 1992 Front End Alignment - Service Procedures
APRIL 1992 Plastic Credit Card Keys - Cutting Procedure
MARCH 1992 Air Bag Driver`s Side - Intermittent Fault Codes 6/32
MARCH 1992 Paint - Rough Texture and/or Orange/Rust Dots
FEBRUARY 1992 A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
FEBRUARY 1992 A/T - A4LD Converter Channel Spring Addition
FEBRUARY 1992 Paint Codes - New Identification Labels
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
FEBRUARY 1992 EEC IV - Self Test Codes and MIL Service Tips
JANUARY 1992 Four Wheel Drive (4 X 4) - General Information
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
DECEMBER 1991 Ignition System Diagnostics - Revision
NOVEMBER 1991 Front Door Trim Panel - Removal Precautions
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
SEPTEMBER 1991 Brake Hoses - Wet Appearance
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 A/T - A4LD No Movement After Rebuild
JULY 1991 A/T - A4LD No Reverse After Rebuild
MAY 1991 Rear Seat Shoulder Safety Belts - Usage/Stowage
MARCH 1991 A/T - Slips or No 3 or Reverse, 2-3 Flare
OCTOBER 1990 A/T - Engine Vacuum Testing
JUNE 1990 A/T - A4LD Front Seal Blow Out
MAY 1990 A/T - A4LD Slipping or Soft Shifts After Rebuild
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JANUARY 1985 A/T - A4LD/C3 Front Pump Support Inspection
|
