 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1991 Mercury Tracer L4-116 1.9L SOHC
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1991 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1991 Mercury Tracer L4-116 1.9L SOHC
JUNE 1993 Recall - Ignition Lock Cylinder Modification/Replacement
Technical Service Bulletin Titles for 1991 Mercury Tracer L4-116 1.9L SOHC
SEPTEMBER 1994 Campaign - Fuel Pump/Sender Wiring Modification
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
Technical Service Bulletin Titles for 1991 Mercury Tracer L4-116 1.9L SOHC
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Hood Lamp Switch - Updated Replacement Part
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
SEPTEMBER 2000 Door Latch - Switch Replacement Procedure Revised
JUNE 2000 Passive Restraint - Incorrect Information in Manual
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
DECEMBER 1999 Brakes - Grinding Noise/Roughness Felt
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
NOVEMBER 1998 Engine - Lean Driveability Symptoms
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JULY 1998 A/T - Flushing Oil Cooler And Lines
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Front Brakes - Squealing Noise Below 35 MPH
MARCH 1998 Front Disc Brakes - Knocking Noise When Braking Gently
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Vehicle - Towing Behind RVs Guidelines
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
DECEMBER 1997 Blower Motor - Chirping/Squeaking
AUGUST 1997 Rear View Mirror - Reattachment
MAY 1997 Brakes - Knocking/Hard Pedal/Squealing
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
JUNE 1996 A/T - 4EAT Assembly Replacement, Service Tip
MAY 1996 Fuel - California Reformulated Gasoline
APRIL 1996 Windshield Wipers - Wipers Streak or Clean Unevenly
JANUARY 1996 A/T - G4A-EL & F4EAT Trouble Code Identification
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
SEPTEMBER 1995 Temperature Gauge - Fluctuation/Inaccurate
AUGUST 1995 Glove Compartment - Improved Lock
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JUNE 1995 Steering Wheel - Shake/Vibration At Idle
JUNE 1995 Windshield - Material Usage Procedure
MAY 1995 Connector, DIS Ignition Revised
APRIL 1995 Wiper Motor - Upgraded Service Kits
MARCH 1995 A/C - Blower Motor Low Speed Ticking Noise
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
MARCH 1995 Ignition Lock Cylinder - Sticks/Binds/Grabs
MARCH 1995 Rear Doors - Wind Noise
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 A/T - G4A-EL, 4EAT Engagement Problems
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
DECEMBER 1994 Fuel Gauge - Reads Full/Engine Stalls/No Start
NOVEMBER 1994 A/T - Revised Line Pressure Readings
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
OCTOBER 1994 Wind Noise - Service Tips
AUGUST 1994 Rear View Mirror - Detaches From Windshield
JULY 1994 A/C Compressor - Service Tips
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 Door Glass - Binding/High Operating Efforts
JUNE 1994 Cooling System - Drain Procedure
JUNE 1994 Body - Front Valance Panel Missing or Loose
MAY 1994 Engine - Hard Start/Hesitation/Rough Idle
APRIL 1994 Fuel Injector Cleaner - Parts and Service Tips
FEBRUARY 1994 Water Leaks - Diagnostic Service Tips
JANUARY 1994 Fuel Pressure Regulator - Obsolete Part Return
JANUARY 1994 A/T - 4EAT, G4A-EL Engine Stalls In Drive
JANUARY 1994 A/T - G4AEL/4EAT DTC 60, 61, 62, or 63/Pinched Wires
JANUARY 1994 A/T - Low OR No Line Pressure Rise/Worn Throttle Cam
JANUARY 1994 A/T - Reverse Piston Return Spring Revised
JANUARY 1994 A/T - Slipping/Vehicle Does Not Move After Rebuild
DECEMBER 1993 Heated Backlite - Inoperative
NOVEMBER 1993 Body/Frame - Rattles and Squeaks/Service Tips
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Electrical - Troubleshooting Service Tips
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
OCTOBER 1993 A/T - Failsafe Modes
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
AUGUST 1993 A/T - G4AEL, G4AHL, F4EAT, F4AEL Shift Feel Complaints
JUNE 1993 Front Strut - Grinding Noise While Turning
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 A/T - G4A-EL, 4EAT Erratic Pressure Rise
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Electronics - Diagnostic Tools & Adapter Application
FEBRUARY 1993 Engine - Hesitation or Stall In Extreme Cold
JANUARY 1993 Brakes - High Pedal Effort/Too Much Pedal Travel
JANUARY 1993 Cooling System - Proper Fluid Concentrations
JANUARY 1993 A/T - F4EAT Diagnostic Information
DECEMBER 1992 Engine - Spark Knock On Acceleration or Cruise
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
NOVEMBER 1992 MIL ON/No Codes Set Explanation
NOVEMBER 1992 Noise/Rattles/Squeaks - Diagnostic Service Tips
SEPTEMBER 1992 A/T - Valve Body Disassembly/Assembly Revision
SEPTEMBER 1992 A/T - (4EAT and MTX) Gear Noise/Wear or Failure
SEPTEMBER 1992 A/T - 4EAT Assembly Replacement Service Tips
SEPTEMBER 1992 A/T - 4EAT Harsh 1-2 or 3-4 Gear Upshift
SEPTEMBER 1992 A/T - Slipping or Harsh Upshifts
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
AUGUST 1992 Engine - Metallic Ticking/Noise
JULY 1992 Door Lock Controller - Sticks In the Up/Down Position
JULY 1992 MIL ON In Cold Weather/Code 15 Set
JULY 1992 Sunroof Wind Deflector - Damage
JUNE 1992 Low Speed Cooling Fan Relay - Manual Revision
JUNE 1992 Speedometer - Indicates High Speed When Cold
MAY 1992 A/C System - Insufficient Cooling
MAY 1992 Moon Roof Sunshade - Rattles
APRIL 1992 Plastic Credit Card Keys - Cutting Procedure
MARCH 1992 Glove Compartment - Poor Fit/Rattle
MARCH 1992 Steering Wheel/Column - Scraping Noise
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
FEBRUARY 1992 EEC IV - Self Test Codes and MIL Service Tips
JANUARY 1992 A/T - Electronic Transmission Repair Process Chart
JANUARY 1992 A/T & M/T - 4EAT/MTX Gear Noise/Wear/Failure
JANUARY 1992 Rear Brakes - Squealing Noise
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 Ignition Pinpoint Tests - Service Tips
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
OCTOBER 1991 Defroster - Warm Air May Flow Into the Floor Area
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 Base Idle RPM - Adjustment Unnecessary
JULY 1991 Door Speakers - Buzzing/Distorted Sound
JULY 1991 Air Conditioning Diagnostics - Manual Revision
JULY 1991 Automatic Transaxle Diagnostics - Revision
JULY 1991 Brake Operation Warning Light - Manual Revision
JULY 1991 Charging System Diagnosis - Revision
JULY 1991 Charging System Warning Light - Manual Revision
JULY 1991 Cigar Lighter Diagnosis & Schematic - Revision
JULY 1991 Engine Cooling System Diagnostics - Revision
JULY 1991 Fuel Gauge/Low Fuel Warning Light - Revision
JULY 1991 Gauges - Manual Revision
JULY 1991 Heating/Defrosting Diagnostics - Manual Revision
JULY 1991 Horn Diagnosis and Testing - Manual Revision
JULY 1991 Instrument Panel Lighting - Manual Revision
JULY 1991 Interior/Exterior Lighting System - Revision
JULY 1991 Miscellaneous/Warning Devices - Manual Revision
JULY 1991 Moon Roof Diagnostics - Revision
JULY 1991 Power Door Lock Diagnosis - Revised
JULY 1991 Power Window Diagnostics - Revision
JULY 1991 Rearview Mirror Diagnostics - Revision
JULY 1991 Seat Belt Diagnostics - Manual Revision
JULY 1991 Steering Column Switches -Manual Revision
JULY 1991 Window Washer Diagnostics - Revision
JULY 1991 Windshield Wiper Diagnostics - Revision
JULY 1991 Front Seat Shoulder Belt - Jams Up
JULY 1991 Horn - Intermittent/Inoperative
JULY 1991 Engine Control Systems - Diagnosis Revision
JUNE 1991 Engine - Tappet Orientation Revision
JUNE 1991 Octane Adjust Shorting Bar - Revised Procedures
JUNE 1991 Speedometer Cable - Removal/Installation Revision
JUNE 1991 Speedometer Cable - Ticking or Squealing Noise
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
MAY 1991 Interior Door Handle - Inoperative
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Front Seat Shoulder Strap - Locks Up In Retractor
APRIL 1991 A/T - 4EAT Harsh Upshifts and Slips During Upshifts
MARCH 1991 Manual Antenna - Service Procedures Revision
MARCH 1991 Service Manual - Modifications/Revisions
MARCH 1991 Windshield Wipers - Torque Value Revision
MARCH 1991 A/T - Electronics Diagnostic and Repair Chart
MARCH 1991 Electric Rear Window Defroster - Inoperative
FEBRUARY 1991 Door Lock Bezel - Rattles
FEBRUARY 1991 A/C Clutch - Intermittent or Inoperative
FEBRUARY 1991 A/T - G4A-EL/4EAT Low Pump Pressure
FEBRUARY 1991 A/T - G4A-EL/4EAT Repeated Reverse Clutch Failure
JANUARY 1991 Radiator Mounts - Vibration/Noise At Idle
JANUARY 1991 A/T - 4EAT Harsh 1st to 2nd or 3rd to 4th Gear Upshift
JANUARY 1991 Front Hub - Snapping Noise At Slow Speed
JANUARY 1991 Luggage Compartment Trim Panel - Pops Off
DECEMBER 1990 A/T Selector Lever Torque - Revision
DECEMBER 1990 EEC IV Pinpoint Test H - Manual Correction
DECEMBER 1990 Body - Roof Sheet Metal Vibration When Closing Doors
DECEMBER 1990 Cowl - Creaking Noise
NOVEMBER 1990 Instrument Panel - Loud Ticking Noise
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 Wheel Cover - Installation Tip
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 A/T - Band Servo Adjusting Procedure Revised
SEPTEMBER 1990 A/T Torque Specifcation - Manual Revisions
SEPTEMBER 1990 Electrical/Vacuum Schematics - Manual Revision
SEPTEMBER 1990 Kickdown Cable - Adjustment/Pressure Specification
SEPTEMBER 1990 Lower Ball Joint Checking Procedure - Revised
SEPTEMBER 1990 Power Steering Pump Installation - Revised
SEPTEMBER 1990 Timing Belt Adjusting Procedure - Revised
AUGUST 1990 EEC IV Quick Test - False `DYN RSP` Message
AUGUST 1990 A/T - G4A, 4EAT Pressure Tap Locations
AUGUST 1990 A/T - G4A, 4EAT Sprag Rotation
AUGUST 1990 A/T - G4A, 4EAT Valve Body Identification
MAY 1990 Engine - Tapping Noise
MARCH 1990 EDIS System Diagnostic Procedures - Manual Revision
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
|
