 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1991 Mercury Sable V6-232 3.8L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1991 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1991 Mercury Sable V6-232 3.8L
APRIL 1999 Recall - Speed Control Cable Modification
DECEMBER 1998 Recall - Subframe Plate Corrosion
APRIL 1997 Recall - Speed Control Cable Modifications
JANUARY 1994 Recall - Engine/Transmission Subframe Modification
JULY 1993 Recall - Subframe Reinforcement Installation
JULY 1992 Recall - Storage Compartment Cover Latch Replacement
Technical Service Bulletin Titles for 1991 Mercury Sable V6-232 3.8L
NOVEMBER 1994 Campaign - A/T Repair/Replacement
MARCH 1992 Campaign - Engine Mount Inspection/Replacement
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
Technical Service Bulletin Titles for 1991 Mercury Sable V6-232 3.8L
JULY 2006 A/T - Mercon V ATF Usage
APRIL 2003 Wipers/Washers - Wiper Motor Transfer Tips
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Hood Lamp Switch - Revised
JUNE 2001 Front Wiper Motor - Erratic Operation
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
NOVEMBER 1998 Engine - Lean Driveability Symptoms
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JULY 1998 A/T - Flushing Oil Cooler And Lines
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Antilock Brakes - Cycling On Rough Roads
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
MARCH 1998 Cooling System - Coolant Loss And/Or Overheating
FEBRUARY 1998 A/T - AX4S/AX4N New Transaxle Fluid
NOVEMBER 1997 A/T - AX4S/AX4N Codes Stored After Replacement
OCTOBER 1997 Fuel System - Fuel Odor Inside Passenger Compartment
AUGUST 1997 Rear View Mirror - Reattachment
JANUARY 1997 Power Steering Hoses - Obsolete Part Return
DECEMBER 1996 Rear Tire - Inner Edge Wear
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
NOVEMBER 1996 Steering Wheel - Clicking Noise Heard When Turning
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
SEPTEMBER 1996 Suspension - Shudder On Acceleration From Standstill
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
AUGUST 1996 A/T - AX4S New Main Control Cover and Pan Gasket
JULY 1996 A/C System - Service TSB List
JULY 1996 Fuel Pump - Gurgles After Hot Restart
MAY 1996 Fuel - California Reformulated Gasoline
APRIL 1996 A/T - AX4S/AX4N Driveline Noises
MARCH 1996 Engine - Intermittent Hesitation/No Start/Stalling
FEBRUARY 1996 A/T - Revised GROB Spline Drive Joint
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
JANUARY 1996 A/T - AX4S (AXODE) Rear Sun Gear Bearing
JANUARY 1996 A/T - AXOD, AX4S (AXODE) Revised Forward Sprag Race
JANUARY 1996 A/T - AXODE Planetary Gear Set Failure/Lack of Lub
JANUARY 1996 A/T - Case Breakage at Rear Planet Support Snap-Ring
DECEMBER 1995 Engine - Rocker Arm Squeak/Chirp/Knock Noise
OCTOBER 1995 Air Bag Modules - Discolored/Marred Covers
OCTOBER 1995 Power Windows - Groaning Noise
SEPTEMBER 1995 Power Steering - Grunt And/Or Groan
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
SEPTEMBER 1995 Temperature Gauge - Fluctuation/Inaccurate
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 A/T - Revised Torque Converter Identification Codes
JULY 1995 Temperature Gauge - Reads Low/Erratic
APRIL 1995 Wiper Motor - Upgraded Service Kits
MARCH 1995 Blower Motor - Chirp/Squeak
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
FEBRUARY 1995 A/T - AX4S/AX4N TSS Sensor Air Gap Measurements Change
FEBRUARY 1995 A/T - AXODE/AXOD New Design Filter Service Tip
FEBRUARY 1995 Front Suspension - Rattling or Clunking Noise
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 Electronic Fuel Gauge - Erratic Readings
JANUARY 1995 A/T - AXOD/E Accumulator Springs Identification
JANUARY 1995 A/T - AXODE Erratic or High Line Pressure
JANUARY 1995 A/T - Delayed Engagement, Shift Errors, MLPS Codes
JANUARY 1995 A/T - Delayed or No Forward/Reverse, Shifts Out of Gear
JANUARY 1995 A/T - Drive Axle and Wheel Lug Nut Torque Specifications
JANUARY 1995 A/T - TCC Pulsing On/Off, High Line Pressure, No Codes
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 A/T -AXOD/AXODE/AX4S Gear Engagement Concern
NOVEMBER 1994 Front Struts - Clicking Noise On Bumps
NOVEMBER 1994 Heated Windshield - Conversion to Regular Windshield
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
OCTOBER 1994 A/T - AX4S/AXOD New Lube Tubes
OCTOBER 1994 Fuel Tank - Fuel Slosh Noise
OCTOBER 1994 A/T - AXOD/AXODE/AX4S Retaining Ring Orientation
OCTOBER 1994 A/T - AXODE/AX4S No Gear Engagement/Noise
SEPTEMBER 1994 EATC - Blend Door Intermittently Goes to Full Heat
SEPTEMBER 1994 A/C - Evaporator Core Replacement
AUGUST 1994 Rear View Mirror - Detaches From Windshield
AUGUST 1994 Heated Exhaust Gas Oxygen Sensor - Application Chart
AUGUST 1994 Power Steering Hose - Service Kits
JULY 1994 A/C Compressor - Service Tips
JULY 1994 A/T - AXODE Transmission Exchange Program
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 Fuel Tank - Obsolete Part Return
MAY 1994 A/T - AXODE Shift Concerns/Possible DTC
MAY 1994 Engine - Rocker Arm Squeak/Chirp/Knock
MAY 1994 Lower Intake Bolt/Stud - Revised Torque Procedure
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
APRIL 1994 Evaporator Core - Replacement
MARCH 1994 A/T - AXOD/AXODE/AX4S Leak At Torque Converter
JANUARY 1994 A/C - Manifold and Tube Assembly Replacement
JANUARY 1994 Fuel Pressure Regulator - Obsolete Part Return
JANUARY 1994 A/T - AXOD/E Erratic Shifts
JANUARY 1994 A/T - Delayed Forward Engagement/Servo Apply Lip Seals
JANUARY 1994 A/T - Forward Sprag Upgrade
JANUARY 1994 A/T - Modification to Improve Gear Lubrication
DECEMBER 1993 Disc Brakes - Vibration During Brake Application
DECEMBER 1993 Heated Backlite - Inoperative
DECEMBER 1993 Power Steering System - Noisy
DECEMBER 1993 Rear Tension Strut - Clunk or Rattle
DECEMBER 1993 Starter Solenoids and Drives - Obsolete Parts Return
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
OCTOBER 1993 Brakes - Vibration/Rotor Wobble Service Tips
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
OCTOBER 1993 A/T - Failsafe Modes
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
AUGUST 1993 Accelerator Cable - Clicking Noise/Vibration
AUGUST 1993 A/T - AX4S/AXODE Redesigned Rear Lube Tube
JULY 1993 Deposit Resistant Fuel Injectors - Identification
JULY 1993 A/C Compressor - Growling Noise
JULY 1993 Bumper - Loose or Unattached Ends
JULY 1993 Front Suspension - Grunt/Popping Noise While Turning
JULY 1993 Rear Door - High Closing Effort
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Engine - Stalls/Hesitates/Long Cranking Times
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
JUNE 1993 A/T - AXOD/E Electrical Diagnostic Information
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Front Seat - Feels Loose
FEBRUARY 1993 Ignition Switch Lock/Steering Lock - Difficult Operation
JANUARY 1993 Lower Rear Door Hinge/Check - Loose/Noisy
JANUARY 1993 Power Door Lock - Inoperative
JANUARY 1993 Cooling System - Proper Fluid Concentrations
JANUARY 1993 Variable Assist P/S - High Steering Effort
DECEMBER 1992 A/T - AXOD/AXODE End Play Specification
DECEMBER 1992 A/T - AXOD/AXODE Revised Direct One Way Clutch
DECEMBER 1992 A/T - AXODE Chain Cover Kit
DECEMBER 1992 A/T - AXODE No 2nd Gear/Extended 1-2 Shifts
DECEMBER 1992 A/T - AXODE No Forward & No Reverse Gears
DECEMBER 1992 A/T - AXODE No Shifts/Harsh or Extended Shifts
DECEMBER 1992 A/T - AXODE Whine From the Front Planetary Gear
DECEMBER 1992 A/T - AXODE/AXOD Revised Turbine Shaft Seal Ring
DECEMBER 1992 A/T - Delayed Shift During 3-2 Downshifts
DECEMBER 1992 A/T - Improved Design Oil Pump Gasket
DECEMBER 1992 A/C - FX15 Clutch Application Chart
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
DECEMBER 1992 A/T - AXODE Uncontrollable Lock Up
NOVEMBER 1992 A/C Compressor - Oil Recovery & Measuring Procedure
NOVEMBER 1992 EATC Blend Door - Intermittenly Goes to Full Heat
NOVEMBER 1992 MIL ON/No Codes Set Explanation
NOVEMBER 1992 Digital Fuel Gauge - Displays CO Error Code
NOVEMBER 1992 A/T - AXODE Check Ball Locations
SEPTEMBER 1992 A/C Clutch - Slips At High Ambient Temperature
SEPTEMBER 1992 A/T - AXODE Air test Plate Modification
SEPTEMBER 1992 Brake Pedal - Slow or Does Not Completely Return
SEPTEMBER 1992 Climate Control System - Wiring Circuit Color Revised
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
AUGUST 1992 A/C Compressor - Oil Recovery/Measuring Procedures
JULY 1992 A/T - AXODE Updated Lubrication Tubes
JUNE 1992 Engine Mount - Obsolete Parts Return
JUNE 1992 Starter Motor Brushes - Replacement Revision
JUNE 1992 Brakes - Roughness/Runout Check
JUNE 1992 Speedometer - Indicates High Speed When Cold
MAY 1992 Rear Stabilizer Bar - Grunting Noise
APRIL 1992 Plastic Credit Card Keys - Cutting Procedure
MARCH 1992 Air Bag Driver`s Side - Intermittent Fault Codes 6/32
MARCH 1992 A/T - ATX Planetary Gear Interchange
MARCH 1992 A/T - AXOD/E No Forward or Slips in Forward Gears
FEBRUARY 1992 A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
FEBRUARY 1992 Radio - Buzz/Whine and Ignition Noise
FEBRUARY 1992 A/T - AXOD/E 44T4`s and 125`s Chain Stretch
JANUARY 1992 A/T - Electronic Transmission Repair Process Chart
JANUARY 1992 A/T - AXODE/AODE Reference Manuals
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
DECEMBER 1991 ABS Pump Speed Sensor Pin Numbers - Revision
DECEMBER 1991 Audio System - Manual Revision
DECEMBER 1991 Remote Liftgate Release - Reference Deletion
DECEMBER 1991 A/T - AXOD E Check Ball Locations
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
OCTOBER 1991 Engine Mount - Clunking Noises On Acceleration
OCTOBER 1991 Engine - Lack Of Power When Speed Control Is Engaged
SEPTEMBER 1991 Power Window Regulator - Counterbalance Spring
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 Tie Rod End - Service Tips
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JUNE 1991 PCM - MIL ON/Codes 173 And/Or 177 Set
JUNE 1991 A/T - AXODE Diagnostics Revision
JUNE 1991 IDM and Spark Timing Diagnosis - Manual Revision
JUNE 1991 Ignition System - Diagnostic Procedures Revision
JUNE 1991 Instrument Panel - Removal/Installation Revision
JUNE 1991 SEFI Electrical Schematic - Manual Revision
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
MAY 1991 Air Bag Module - Deployment Doors Marred
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Front Disc Brake Rotor - New Design
APRIL 1991 Heater - Poor Performance In Extreme Cold
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Antilock Brake System - Test Step A5 Update
MARCH 1991 Antilock Brake Testing - Manual Revisions
MARCH 1991 Front Engine Mounts - Revised Service Procedure
MARCH 1991 Refrigerant System Leak Testing - Manual Update
MARCH 1991 A/T - Electronics Diagnostic and Repair Chart
MARCH 1991 Paint - Color Code Chart Revision
MARCH 1991 Electric Rear Window Defroster - Inoperative
FEBRUARY 1991 Steering Wheel - Clicking Noise When Turning
JANUARY 1991 Intake Manifold - Revised Torque Specifications
DECEMBER 1990 EEC IV Pinpoint Test H - Manual Correction
DECEMBER 1990 Keyless Entry System - Connector Color Codes Revised
DECEMBER 1990 Inside Rear View Mirror - Removal/Installation
DECEMBER 1990 Speakers - Ignition Noise/Alternator Whine
DECEMBER 1990 Speed Control - Diagnostic Tips
NOVEMBER 1990 Air Bag System - Rescuer`s Guide
OCTOBER 1990 Audio Systems - Authorized Service Centers
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 Engine - Oil Fill Capacities
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
FEBRUARY 1990 A/T - ATX Bind-Up In Reverse
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - ATX New Design Lip Seals
AUGUST 1989 A/T - Math Formulas Part I
MARCH 1989 A/T - ATX Governor Filter
NOVEMBER 1988 A/T - ATX Torque Converter Differences
MARCH 1988 A/T - ATX No Movement In Any Direction
JANUARY 1988 A/T - Installation Of In-Line Fluid Filter & Flow Test
OCTOBER 1987 A/T - ATX Late or No Upshift
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
APRIL 1987 A/T - ATX Planetary Gear Design Changes
OCTOBER 1986 A/T - ATX Erratic Upshifts Sometimes No Upshift
|
