 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1991 Mercury Capri L4-1597cc 1.6L DOHC Turbo
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1991 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1991 Mercury Capri L4-1597cc 1.6L DOHC Turbo
JULY 1992 Recall - Replacement of Air Bag Module
JANUARY 1991 Recall - A/T Oil Cooler Line Replacement
Technical Service Bulletin Titles for 1991 Mercury Capri L4-1597cc 1.6L DOHC Turbo
DECEMBER 1991 Recall - Vehicle Emission Control Label Replacement
Technical Service Bulletin Titles for 1991 Mercury Capri L4-1597cc 1.6L DOHC Turbo
OCTOBER 1992 Campaign - Alternator Pulley and Belt Replacement
SEPTEMBER 1992 Campaign - Convertible Top Repair
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
Technical Service Bulletin Titles for 1991 Mercury Capri L4-1597cc 1.6L DOHC Turbo
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
MAY 1999 Motor Oil - Viscosity Grade Recommendation
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Vehicle - Towing Behind RVs Guidelines
JULY 1997 Hardtop - Retention Weldnut Thread Repair
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Mass Air Flow Sensor - Assembly Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
SEPTEMBER 1996 A/C - New O Ring Applications
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
MAY 1996 Convertible Top - Backlite Split/Cracked/Broken
MAY 1996 Convertible Top - Water Leaks
MAY 1996 Convertible Top Weatherstrip - Water Leaks
JANUARY 1996 A/T - G4A-EL & F4EAT Trouble Code Identification
OCTOBER 1995 Air Bag Modules - Discolored/Marred Covers
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
JANUARY 1995 A/T - Drive Axle and Wheel Lug Nut Torque Specifications
JANUARY 1995 A/T - G4A-EL, 4EAT Engagement Problems
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Convertible Top - Reduced Backlight Visibility
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
AUGUST 1994 Engine Timing Belt Guide Plate - Swish Noise
JULY 1994 R-12 Refrigerant - Substitutes
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
APRIL 1994 Weatherstrip - Improved Sealing
APRIL 1994 `A` Pillar - Water Leaks
JANUARY 1994 Convertible Top - Parts Supplement
JANUARY 1994 A/T - 4EAT, G4A-EL Engine Stalls In Drive
JANUARY 1994 A/T - G4AEL/4EAT DTC 60, 61, 62, or 63/Pinched Wires
JANUARY 1994 A/T - Low OR No Line Pressure Rise/Worn Throttle Cam
JANUARY 1994 A/T - Reverse Piston Return Spring Revised
JANUARY 1994 A/T - Slipping/Vehicle Does Not Move After Rebuild
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Hydraulic Lash Adjusters - Ticking Noise
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
OCTOBER 1993 Turn Signal Lever - Will Not Stay Engaged On RH Turn
OCTOBER 1993 A/T - Failsafe Modes
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Windshield Wipers - Fuse Blows In Freezing Temperatures
AUGUST 1993 A/T - G4AEL, G4AHL, F4EAT, F4AEL Shift Feel Complaints
JULY 1993 Front Window Channel - Water Leaks
JUNE 1993 Interior Door Handle - Breaks
JUNE 1993 A/T - G4A-EL, 4EAT Erratic Pressure Rise
MARCH 1993 Electronics - Diagnostic Tools & Adapter Application
FEBRUARY 1993 Temperature/Oil Pressure Gauges - Erratic Readings
JANUARY 1993 `Star Tester` - Proper Hook Up Procedure
JANUARY 1993 Cooling System - Proper Fluid Concentrations
JANUARY 1993 A/T - F4EAT Diagnostic Information
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
SEPTEMBER 1992 A/T - 4EAT Diagnostic Information Revised
SEPTEMBER 1992 A/T - 4EAT Diagnostic Steps Revision
SEPTEMBER 1992 Engine - Hesitation/Stall/Stumble On DRIVE Engagement
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
AUGUST 1992 Engine - Metallic Ticking/Noise
JUNE 1992 Speedometer - Inoperative or Inaccurate
MAY 1992 Heater Air Intake - Water Leaks To Interior
APRIL 1992 Fuel Filler Cap - Separation
APRIL 1992 Plastic Credit Card Keys - Cutting Procedure
MARCH 1992 Engine Cooling Fan/A/C - Inoperative
FEBRUARY 1992 Locks/Ignition - Dealer Cut Keys Won`t Work In Ignition
FEBRUARY 1992 Convertible Top - Roof Bow Vinyl Flap Detached from Top
JANUARY 1992 A/T - Electronic Transmission Repair Process Chart
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
DECEMBER 1991 Pressure Switch Voltage Check/Inspection - Revision
DECEMBER 1991 A/T - 4EAT Delayed Shift With Neutral Between Shifts
DECEMBER 1991 Radiator Hoses/Thermostat Housing - Coolant Leaks
NOVEMBER 1991 Dealer Installed A/C - Fan Power Lead Wire Relocation
NOVEMBER 1991 Front Speaker - Buzzing Noise
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 Convertible Top - Sides Appear to Be Loose
OCTOBER 1991 Accessory Hardtop - Fit And Alignment
OCTOBER 1991 Convertible Top - Rear Window Scratched
OCTOBER 1991 Upper/Lower Radiator Hoses - Coolant leaks
SEPTEMBER 1991 Convertible Top - Fabric Tears At Top of B Pillar
SEPTEMBER 1991 Convertible Top/Hardtop - Base Part Numbers
SEPTEMBER 1991 Engine - Hard Start or Long Crank Condition
AUGUST 1991 A/C Compressor Clutch - Cycles Erraticly
AUGUST 1991 Air Cleaner - Pop Noise/Contacts Transmission
JULY 1991 A/C Service & Diagnostics - Revision
JULY 1991 A/T 4EAT Diagnostics - Manual Revision
JULY 1991 Charge Indicator Diagnostics - Manual Revision
JULY 1991 Clutch Switch Diagnosis/Testing - Revision
JULY 1991 Engine Coolant Temperature System - Revision
JULY 1991 Fuel Level Indicating System - Manual Revisions
JULY 1991 Heater & Ventilation Diagnostics - Revision
JULY 1991 Instrument Cluster Diagnostics - Manual Revision
JULY 1991 Interior Lamps Diagnostic Information - Revision
JULY 1991 Lighting System - Revised Diagnostic Information
JULY 1991 Oil Pressure Indicating System - Manual Revision
JULY 1991 Parking/Marker/Tail Lamp - Diagnostics Revision
JULY 1991 Tachometer Diagnostics - Manual Revision
JULY 1991 Turbo Boost Indicator - Revised Diagnostics
JULY 1991 Turn Signal & Hazard Flasher - Diagnostics Revision
JULY 1991 Warning Indicators - Manual Revision
JULY 1991 Engine Control Systems - Diagnosis Revision
JUNE 1991 Oil Pressure Specification Chart - Revision
JUNE 1991 Backlite - Separates From Convertible Top
JUNE 1991 Front Door Window - Slow Rise Time
MAY 1991 Door Window - Operating Mechanism Binding/Noisy
MAY 1991 Alignment/Tires - Drift or Pull to the Right
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 Outside Rear View Mirrors - Rattle or Vibrate
MAY 1991 A/C - R12 Refrigerant Service Tips
MAY 1991 Air Bag Module - Deployment Doors Marred
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Engine Hydraulic Tappet - Rattling Noise
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Alignment Specifications - Revisions
MARCH 1991 A/T - Electronics Diagnostic and Repair Chart
FEBRUARY 1991 Engine Mount/Suspension - Knocks/Rattles
FEBRUARY 1991 A/T - G4A-EL/4EAT Low Pump Pressure
FEBRUARY 1991 A/T - G4A-EL/4EAT Repeated Reverse Clutch Failure
JANUARY 1991 Stop Lamp Switch - Adjustment Procedure
JANUARY 1991 Sun Visor - Replacement Color Availability
JANUARY 1991 Front/Rear Alignment Specifications - Revision
JANUARY 1991 M/T - Shift Lever Separates From Housing
DECEMBER 1990 A/T - 4EAT Diagnosis Revision
DECEMBER 1990 Headlamp System Test Step D12 - Manual Correction
DECEMBER 1990 Door Glass - Water Leaks/Poor Operation
NOVEMBER 1990 Air Bag System - Rescuer`s Guide
NOVEMBER 1990 Convertible Top - Rattles/Squeaks
NOVEMBER 1990 Engine - Hesitation Stall On Driveaway
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 Bumper Insert Molding - Bulges At Outer Ends
OCTOBER 1990 Convertible Top - Flipper Door Failure
OCTOBER 1990 Speed Control - Delayed Engagement Tips
OCTOBER 1990 Wiring Harness - Diode Testing/Replacement Procedure
OCTOBER 1990 Convertible Top - Damages Windshield Weatherstrip
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Front Seat Back Foam Pad - Visible At Seat Pivot
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Luggage Compartment Lamp - Will Not Shut Off
AUGUST 1990 A/T - G4A, 4EAT Pressure Tap Locations
AUGUST 1990 A/T - G4A, 4EAT Sprag Rotation
AUGUST 1990 A/T - G4A, 4EAT Valve Body Identification
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
|
