 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1991 Ford Truck F 150 4WD Pickup L6-300 4.9L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1991 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1991 Ford Truck F 150 4WD Pickup L6-300 4.9L
OCTOBER 2001 Recall - Firestone Tire Recall Supplement
JUNE 2001 Recall - Fuel Cross-Flow Extended Coverage
SEPTEMBER 2000 Recall - Firestone Tire Recall
NOVEMBER 1995 Recall - Ignition Switch Replacement
SEPTEMBER 1993 Recall - Cross Tank Fuel Flow Condition
Technical Service Bulletin Titles for 1991 Ford Truck F 150 4WD Pickup L6-300 4.9L
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
Technical Service Bulletin Titles for 1991 Ford Truck F 150 4WD Pickup L6-300 4.9L
JULY 2006 A/T - Mercon V ATF Usage
OCTOBER 2002 A/T - Torque Converter Access Plug Dislodges
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
AUGUST 1998 A/T - E4OD No 2nd - 3rd Gear Upshift
AUGUST 1998 A/T - Main Controls/Separator Plate/Gaskets Usage
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Steering/Suspension - Steady State Left Pull/Drift
MARCH 1998 Vehicle - Towing Behind RVs Guidelines
MARCH 1998 A/T - E4OD TCIL Flashing/DTC`s 62/628/1728 Stored
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
SEPTEMBER 1997 Universal Joint - Greasable Design Availability
SEPTEMBER 1997 A/T - E4OD Main Regulator Booster Service Tip
AUGUST 1997 Rear View Mirror - Reattachment
JUNE 1997 Driveline - Vibration/Noise at Highway Speeds
JUNE 1997 A/T - Low Transmission Fluid/Shift/Engagement Concerns
FEBRUARY 1997 Accessory Drive Belt - Comes Off Pulleys
FEBRUARY 1997 Frame - Rivet Replacement with Bolts Service Tip
FEBRUARY 1997 Frame - Popping or Creaking Noise
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
NOVEMBER 1996 Ball Joint - Clunk Noise From Front End
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
SEPTEMBER 1996 Engine - Hesitation/Rough Idle/Stall
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
JUNE 1996 Differential - Chatter On Turns
JUNE 1996 Tailgate - Chucking/Squeak/Rattle On Bumps
MAY 1996 Fuel - California Reformulated Gasoline
MARCH 1996 A/T - E4OD Reverse Clutch Piston and Seal Usage
JANUARY 1996 A/T - E40D Intermediate Servo Piston Redesigned
JANUARY 1996 A/T - E40D New Solenoid Bodies
JANUARY 1996 A/T - E40D No Cooler Flow
JANUARY 1996 A/T - E40D Shifts 1-2-3 Below 15 MPH
DECEMBER 1995 A/T - E4OD Direct Clutch Plate Usage Chart/Service Tip
DECEMBER 1995 Door Lock Cylinder - Loose in Replacement Door
NOVEMBER 1995 A/T - E4OD Redesigned Intermediate Band Apply Servo
NOVEMBER 1995 Ignition Switch - Key Hard To Rotate When Cold
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - E4OD Intermediate Brake Drum Assembly Service Tip
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 A/T - E4OD Harsh/Double Bump On Reverse Engagement
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
JUNE 1995 A/T - E40D Delayed Forward Engagement
JUNE 1995 A/T - E40D Revised Rear Case Bushing
APRIL 1995 Engine - Knocking Noise on Initial Start Up
APRIL 1995 Running Boards - Noise/Vibration Installation Tips
APRIL 1995 Wiper Motor - Upgraded Service Kits
MARCH 1995 A/T - E40D Overdrive One Way Clutch Tips
MARCH 1995 A/T - E4OD New Design Transmission Range Sensor
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
JANUARY 1995 A/T - E4OD Shift Concerns/DTC`s Set
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 Engine - Hesitation/Surge On Cruise/Light Acceleration
JANUARY 1995 Tailgate Applique - Cracks In Plastic Ford Letters
JANUARY 1995 A/T - Delayed Engagement, Shift Errors, MLPS Codes
JANUARY 1995 A/T - E40D ATF Leaking Out Vent
JANUARY 1995 A/T - E40D No Forward Engagement In O/D, 4-3 Flare Up
JANUARY 1995 A/T - E40D No Upshifts or Harsh Upshifts/4th Gear Starts
JANUARY 1995 A/T - E40D Pump Modifications
JANUARY 1995 A/T - E40D Pump Upgrade
JANUARY 1995 A/T - Intermediate Accumulator Regulator Filter & Spring
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 A/T - E4OD Upgrade Ball Bearing Center Support Kit
NOVEMBER 1994 A/T - E4OD Upgraded Transmission Components
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
OCTOBER 1994 A/T - E4OD Upgraded Overdrive Planet Assembly
OCTOBER 1994 A/T - E4OD Vehicle Does Not Move
OCTOBER 1994 Air Conditioner Vacuum Tank - Replacement Tip
AUGUST 1994 Rear View Mirror - Detaches From Windshield
AUGUST 1994 Heated Exhaust Gas Oxygen Sensor - Application Chart
JULY 1994 A/C Compressor - Service Tips
JULY 1994 Accelerator Cable - Service Procedures/Tips
JULY 1994 Passenger Seat Back - Rattles When Unoccupied
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 A/T - E40D/ATX Transmission Exchange Program
MAY 1994 Accessory Drive Belt - Chirp or Squeal Noise
APRIL 1994 Frame/Crossmember - Snapping/Popping Noise
APRIL 1994 Fuel Injector Cleaner - Parts and Service Tips
APRIL 1994 A/T - E4OD/C6 Low One-Way Clutch Service Tips
JANUARY 1994 Accessory Drive Belt - Noise/Excessive Wear
JANUARY 1994 A/T - E40D Delayed Engagements
JANUARY 1994 A/T - E40D Extension Housing Bushing Failure
JANUARY 1994 A/T - E40D No Converter Engage, 2nd & 4th Gear Starts
JANUARY 1994 A/T - E40D Vibration When TCC is Applied
JANUARY 1994 A/T - Preventing Front Planetary Gear Failure
JANUARY 1994 A/T - Stacked Shifts/No Kickdown/OD Cancel Inoperative
DECEMBER 1993 Power Steering System - Noisy
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 A/T - AOD Diagnostic Information
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Engine - Stalls On Initial Start-Up
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
OCTOBER 1993 A/T - Failsafe Modes
SEPTEMBER 1993 A/T - E40D Adhesive Repair Kit Availability
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Cab Back Panel - Booming Type Noise
SEPTEMBER 1993 Paint - Peel Repair Procedures Update
AUGUST 1993 Brake Computer Module - Obsolete Service Part Return
AUGUST 1993 Rear Anti-Lock Brakes - Adverse Characteristics
AUGUST 1993 M/T - ZF M5OD HD Obsolete Yoke Nut return
AUGUST 1993 A/T - E40D Overdrive Planetary Failure
JULY 1993 Antilock Brakes - Service Tips
JULY 1993 Deposit Resistant Fuel Injectors - Identification
JULY 1993 Steering - Alignment Service Procedure
JUNE 1993 A/T - E40D Clunk Shifting to Drive or Reverse
JUNE 1993 A/T - E40D Bellhousing Leaks
MAY 1993 Brakes - Sticking/Binding/Grabbing
MAY 1993 Engine - Buzz/Rattle/Low End Knock
MAY 1993 Engine - Rough Idle or Stumble
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Paint to Match Parts - Generic Paint Procedure
MARCH 1993 Steering Gear - Leak At the Input Shaft
FEBRUARY 1993 Rear Brakes - Grab When Cold
JANUARY 1993 A/C - Poor Heating or Cooling Performance
JANUARY 1993 Engine - Hard Starting/Lack of Power
JANUARY 1993 Engine - Low End Knock Under Load
JANUARY 1993 Cooling System - Proper Fluid Concentrations
JANUARY 1993 Pitman Arm - High Steering Efforts In Right Hand Turn
DECEMBER 1992 A/C - FX15 Clutch Application Chart
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
NOVEMBER 1992 A/C Compressor - Oil Recovery & Measuring Procedure
NOVEMBER 1992 MIL ON/No Codes Set Explanation
NOVEMBER 1992 A/T - E40D Front Seal Blow Out
NOVEMBER 1992 A/T - E40D Intermediate Sprag Rotation
SEPTEMBER 1992 A/C Clutch - Slips At High Ambient Temperature
SEPTEMBER 1992 EGR Valve Sensor - Obsolete Service Part Return
SEPTEMBER 1992 A/C - Vacuum Hose Colors Revised
SEPTEMBER 1992 A/T - E40D Case, Separator Plate, and Valve Body I.D.
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
AUGUST 1992 A/C Compressor - Oil Recovery/Measuring Procedures
AUGUST 1992 A/C O Ring Seal - New Design
AUGUST 1992 Engine - Stall During Initial Start Up After Long Soak
AUGUST 1992 Steering - Pulls Left When Braking
AUGUST 1992 A/T - E40D Case Damage During Pump Removal
AUGUST 1992 A/T - E40D Indexing Manual Valve After Rebuild
JULY 1992 Engine - Cooling Concerns and/or Vibration
JUNE 1992 Starter Motor Brushes - Replacement Revision
JUNE 1992 Nylon Fuel Lines - Servicing Procedure
JUNE 1992 Speedometer - Indicates High Speed When Cold
MAY 1992 Fuel System - Fuel Stabilizer For Extended Storage
MAY 1992 A/T - E40D Check Ball Locations
APRIL 1992 Axle - Rear Axle Wheel Hub Oil Leaks
APRIL 1992 Engine - Stalls On Transmission Gear Engagement
APRIL 1992 Plastic Credit Card Keys - Cutting Procedure
APRIL 1992 A/T - E40D Rebuild Tips
MARCH 1992 Power Steering Gear - Fluid Leaks
FEBRUARY 1992 A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
FEBRUARY 1992 Front Drive Axle - Identification Tags
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
FEBRUARY 1992 EEC IV - Self Test Codes and MIL Service Tips
FEBRUARY 1992 A/T - Check ABS Excitor Ring During Differential Rebuild
FEBRUARY 1992 A/T - E40D Overdrive Sprag Rotation and Installation
JANUARY 1992 Diesel Engine - Redesigned Flywheel Bolts
JANUARY 1992 EVAP System - MIL ON/Codes 171/173/179 Set
JANUARY 1992 A/T - E40D In Line Service Check Valve Usage
JANUARY 1992 A/T - E4OD Forward Clutch Piston Spring
JANUARY 1992 A/T - E4OD Proper Stoplamp Circuit Splicing
JANUARY 1992 A/T - E4OD Turbocharger/Supercharger Incompatible
JANUARY 1992 A/T - Electronic Transmission Repair Process Chart
JANUARY 1992 Driveline - Modification Guidelines
JANUARY 1992 M/T - M5HD Increased/Uneven Clutch Pedal Efforts
JANUARY 1992 Four Wheel Drive (4 X 4) - General Information
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
DECEMBER 1991 Heater Hose Illustration Headings - Revision
DECEMBER 1991 A/T - E4OD Delayed Initial Forward Engagement
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 Trailer Brake Controller - Stoplamp Circuit Installation
NOVEMBER 1991 Fuel Tank - Installation Precautions
NOVEMBER 1991 A/T - Buzzing Noise/Missing Cup Plugs
NOVEMBER 1991 A/T - E40D Burned Overdrive Section
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
OCTOBER 1991 Steering/Suspension - Pull/Drift Diagnostic Procedure
OCTOBER 1991 Air Conditioning - Lack of Cooling
OCTOBER 1991 Brake Pedal - Excessive Travel or Pedal Fade
SEPTEMBER 1991 A/C - Lack of Heating/Cooling Performance
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Full Floating Hub - Improved Seal/Dust Deflector
SEPTEMBER 1991 Brake Hoses - Wet Appearance
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
SEPTEMBER 1991 M/T - Crunching Shifting From 2nd to 3rd Gear
SEPTEMBER 1991 M/T Clutch Housing - Fluid Inside
AUGUST 1991 M/T - Gear Noise/Rattle
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 Rear Axle - Correct Routing
JULY 1991 A/T - E4OD Forward Clutch Spring Positioning
JULY 1991 Rear Brakes - Vibration/Shudder Diagnosis
JULY 1991 Transfer Case - Borg Warner 1345 Manual Revision
JULY 1991 A/T - Delayed Engagement In Reverse & Drive
JUNE 1991 Headlamp Switch - Auxiliary Lamp Precautions
JUNE 1991 A/T - E4OD Diagnostics Revision/Correction
JUNE 1991 EEC IV Quick Test - Manual Revision
JUNE 1991 Heater Hose Installation - Manual Revision
JUNE 1991 Horn Relay - Location Revision
JUNE 1991 IDM and Spark Timing Diagnosis - Manual Revision
JUNE 1991 Ignition System - Diagnostic Procedures Revision
JUNE 1991 Key On Engine Off Self Test Code 79/539 - Revision
JUNE 1991 Trailer Tow Relay Circuits 14 and 37 - Manual Revision
JUNE 1991 Engine - Lack of Power/No Start Diagnosis
JUNE 1991 Steering/Suspension - Light Steering/Wander
MAY 1991 Headlamp Switch - Auxiliary Lamp Wiring Precautions
MAY 1991 Wheel - Mounting Surface Distorted Lug/Pilot Holes
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 M/T - M50D Hard Shift Condition
MAY 1991 M/T Transmission Shift Lever - Buzz/Vibration
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 A/T - In Line Service Check Valve Usage
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 A/T - Electronics Diagnostic and Repair Chart
MARCH 1991 Paint - Color Code Chart Revision
MARCH 1991 Rear Axle Hub Seal - Lubricant Leaks
MARCH 1991 Bendix® Steering Gear - High Steering Effort
JANUARY 1991 A/T - E40D Quick Tests
DECEMBER 1990 EEC IV Pinpoint Test H - Manual Correction
DECEMBER 1990 Speed Control - Diagnostic Tips
OCTOBER 1990 Audio Systems - Authorized Service Centers
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 Engine - Oil Fill Capacities
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
FEBRUARY 1990 A/T - Choosing the Right ATF
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Check Ball Locations And Function
AUGUST 1989 A/T - E4OD Description
AUGUST 1989 A/T - Math Formulas Part I
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
|
