 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1990 Mercury Cougar/XR7 V6-232 3.8L SC
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1990 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1990 Mercury Cougar/XR7 V6-232 3.8L SC
NOVEMBER 1995 Recall - Ignition Switch Replacement
MAY 1991 Recall - Windshield Wiper Motor Inspection
Technical Service Bulletin Titles for 1990 Mercury Cougar/XR7 V6-232 3.8L SC
FEBRUARY 1994 Recall - Catalytic Converter/PCM Replacement
Technical Service Bulletin Titles for 1990 Mercury Cougar/XR7 V6-232 3.8L SC
DECEMBER 1993 Campaign - Throttle Lever Grommet Replacement
OCTOBER 1992 Campaign - Front Disc Rotor and Pad Replacement
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
OCTOBER 1990 Campaign - Brake Rotor/Pad Replacement
Technical Service Bulletin Titles for 1990 Mercury Cougar/XR7 V6-232 3.8L SC
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
OCTOBER 2000 Climate Control - Blower Control Service Tips
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
NOVEMBER 1998 Engine - Lean Driveability Symptoms
SEPTEMBER 1998 A/C Evaporator Core - Water Drips Onto Floor
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
DECEMBER 1997 Blower Motor - Chirping/Squeaking
AUGUST 1997 Rear View Mirror - Reattachment
APRIL 1997 Rear Axle - Whining/Howling Noise
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
JUNE 1996 Differential - Chatter On Turns
MAY 1996 Fuel - California Reformulated Gasoline
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
DECEMBER 1995 Engine - Rocker Arm Squeak/Chirp/Knock Noise
NOVEMBER 1995 Air Conditioning - Water Drips On Floor
OCTOBER 1995 Power Windows - Groaning Noise
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
SEPTEMBER 1995 Temperature Gauge - Fluctuation/Inaccurate
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
APRIL 1995 Wiper Motor - Upgraded Service Kits
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
MARCH 1995 Windshield/Backlite - Sealer Drips on Interior Trim
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 A/T - AOD Harsh 4-3 Kickdown/Valve Body Repair
JANUARY 1995 A/T - Drive Axle and Wheel Lug Nut Torque Specifications
DECEMBER 1994 Antitheft System - Recap of TSB`s/Service Tips
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
OCTOBER 1994 Front Seat Track Covers - Come Off When Moved Rearward
AUGUST 1994 Rear View Mirror - Detaches From Windshield
JULY 1994 A/C Compressor - Service Tips
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 A/C - Evaporator Core and Case Assembly Application
JUNE 1994 Axle - Rear Axle Cover Vent Hose Lubricant Leakage
MAY 1994 Engine - Rocker Arm Squeak/Chirp/Knock
MAY 1994 Keyless Entry - Key Pad Illumination Non Functional
APRIL 1994 Evaporator Core - Replacement
JANUARY 1994 A/C - Water Leaks From the Floor Ducts
JANUARY 1994 Air Conditioning - Poor Performance
JANUARY 1994 Fuel Pressure Regulator - Obsolete Part Return
JANUARY 1994 A/T - AODE Cooler Return Line Filter Installation
DECEMBER 1993 Heated Backlite - Inoperative
DECEMBER 1993 Power Steering System - Noisy
DECEMBER 1993 Starter Solenoids and Drives - Obsolete Parts Return
DECEMBER 1993 A/C Evaporator Tube - Refrigerant Leaks
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 A/T - AOD Diagnostic Information
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
NOVEMBER 1993 Moon Roof - Wind Noise When Fully Open
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Body - Collision Repair Manual Revision
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Engine - Stalls/Hesitates/Long Cranking Times
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Rear Brakes - Pedal Pulsation
MARCH 1993 Front Seat - Feels Loose
FEBRUARY 1993 Rear Axle - Moan or Slow Beating Noise At 55 MPH
JANUARY 1993 Power Door Lock - Inoperative
JANUARY 1993 Cooling System - Proper Fluid Concentrations
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
NOVEMBER 1992 A/C Compressor - Oil Recovery & Measuring Procedure
NOVEMBER 1992 A/T - AOD Gear Whine
OCTOBER 1992 Alarm System - False Security Alarm
SEPTEMBER 1992 A/C Clutch - Slips At High Ambient Temperature
SEPTEMBER 1992 Automatic Ride Control - Diagnostic Test Revision
AUGUST 1992 A/C Compressor - Oil Recovery/Measuring Procedures
AUGUST 1992 A/C Compressor - Moan At Idle to 1,500RPM
JUNE 1992 Starter Motor Brushes - Replacement Revision
JUNE 1992 A/C - Condensation Enters Passenger Compartment
JUNE 1992 Brakes - Roughness/Runout Check
MAY 1992 Front Door Glass - Separates From the Glass Bracket
FEBRUARY 1992 A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
FEBRUARY 1992 Brakes - Roughness/Pulsation/Steering Wheel Shake
FEBRUARY 1992 Radio - Buzz/Whine and Ignition Noise
JANUARY 1992 Horn Pad - High Operating Effort
JANUARY 1992 Oil Pan Front Cover Gasket - Leaks Oil
JANUARY 1992 Power Seat - Operation Slow/Stalled/Inoperative
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 Ignition Pinpoint Tests - Service Tips
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Power Window Regulator - Counterbalance Spring
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
SEPTEMBER 1991 Radio Speakers - Distorted Sound
AUGUST 1991 Tape Player - Hissing Noise
AUGUST 1991 A/T - AOD Delayed Shift Times
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 Cowl - Water Leaks On Passenger Side Front Floor
JULY 1991 A/T - AOD Direct Clutch Failure/Excessive Case Bore Wear
JUNE 1991 Exhaust - Moan/Vibration At 2,100 RPM
JUNE 1991 Fuel Gauge - Intermittently Shows Increase In Fuel Level
JUNE 1991 IDM and Spark Timing Diagnosis - Manual Revision
JUNE 1991 Octane Adjust Shorting Bar - Revised Procedures
JUNE 1991 Supercharger - Diagnostic Procedures Revision
MAY 1991 A/T - AOD Harsh/Rough Shifts
MAY 1991 Fixed Antenna - Whistling Wind Noise
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 Gaskets - Loctite®(R) 510 High Temperature Gasket Maker
MAY 1991 Passive Restraint - Service Part Information
MAY 1991 A/C - R12 Refrigerant Service Tips
MAY 1991 Engine - Detonation/Hard Start/Rough Idle/Stall
MAY 1991 Paint - Paint Blistering or Peeling Off Bumper Covers
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Passive Restraint Track Dust Seals - Torn
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Refrigerant System Leak Testing - Manual Update
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 Wiper Arm - Adjustment Procedure
MARCH 1991 A/T - AOD 4th Gear Complaints
FEBRUARY 1991 A/T - AOD Noise/Delayed Shifts/No Engagements
JANUARY 1991 Intake Manifold - Revised Torque Specifications
DECEMBER 1990 Horn/Speed Control Switch Assembly - Revision
DECEMBER 1990 Keyless Entry System - Connector Color Codes Revised
DECEMBER 1990 Passive Restraint System - Chattering Noise
DECEMBER 1990 Radio - Poor AM/FM Reception
DECEMBER 1990 Horn Button - High Operation Effort
DECEMBER 1990 Speed Control - Diagnostic Tips
NOVEMBER 1990 Parking Brake Release Button - Separates From Handle
NOVEMBER 1990 Instrument Cluster - Dim or Blank Display
NOVEMBER 1990 Temperature Gauge - Not Functioning Correctly
OCTOBER 1990 Audio Systems - Authorized Service Centers
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Seat Track - Sticking/Slow/Inoperative
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 EEC IV EGR Pinpoint Test - Manual Correction
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
SEPTEMBER 1990 Ride Control Test Fault Codes - Revised
SEPTEMBER 1990 Rotunda EVO System Tester - Revised Information
SEPTEMBER 1990 Speed Control - Manual Revision
SEPTEMBER 1990 Speed Sensor Resistance Reading - Manual Revision
SEPTEMBER 1990 Split Fold Down Rear Seat - Manual Update
AUGUST 1990 Fuel Pump - Buzzing/Humming After Engine Shut Down
AUGUST 1990 Engine - No Crank Condition
JULY 1990 Lower Body Stone Protection - Repair Procedure
JULY 1990 Speedometer Needle - Fluctuation
JUNE 1990 Wheels - Loss Of Balance Weights
JUNE 1990 Electronic Chime Diagnosis - Manual Revision
JUNE 1990 Speed Control - Clicking/Buzzing Noise
MAY 1990 Body/Frame - Arc Welding Precautions
MARCH 1990 Intercooler/Components - Manual Revision
MARCH 1990 Suspension Specification - Manual Revision
MARCH 1990 Rear Speakers - Sound Is Distorted
MARCH 1990 VECI Decal - Initial Index
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
JANUARY 1990 Hood Lift Retainers - Loose/Broken
JANUARY 1990 VMM Oil Change Indicator - Reset Procedure
JANUARY 1990 Seat Shoulder/Lap Belt - Production Updates
JANUARY 1990 Ford RTV Sealer - Shelf Life
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 Hood Lift - Loose/Broken, New Service Procedure
DECEMBER 1989 Ignition Lock - Ignition Key Hard to Remove
NOVEMBER 1989 Fuel Pump/Sender - Defective Parts Return
NOVEMBER 1989 Door Window Bracket Assembly - Part Return
NOVEMBER 1989 A/T - AOD Separator Plate Gasket Changes
NOVEMBER 1989 A/C Compressor Shaft Seal - Leaks
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Ignition Key Warning Switch - Replacement Procedure
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
SEPTEMBER 1989 Outside Mirror Glass - Replacement Revision
AUGUST 1989 Aluminum Wheel - Air Leaks
AUGUST 1989 EEC Connector - Color Code Changes
AUGUST 1989 Running Lights - Flicker On and Off
AUGUST 1989 Outside Mirror Replacement - Manual Correction
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 A/T - AOD Governor Pressure Leaks
JUNE 1989 A/T - AOD 3-4 Shift Accumulator Deletion
JUNE 1989 Emission Control System - Technician`s Glossary
MAY 1989 Power Steering Pump - New Design Fitting At Pump Outlet
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MARCH 1989 A/T - AOD 3-4 Accumulator Change
JUNE 1988 Electronic Modules - Protection From Static Electricity
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
|
