 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1990 Ford Truck Aerostar 2WD V6-245 4.0L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1990 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1990 Ford Truck Aerostar 2WD V6-245 4.0L
DECEMBER 1998 Recall - Fuel Tank Cracks, Extended Coverage
NOVEMBER 1995 Recall - Ignition Switch Replacement
MAY 1992 Recall - A/T A4LD Park Pawl Spring Update
FEBRUARY 1992 Recall - A/T A4LD Park Pawl Spring Replacement
SEPTEMBER 1990 Recall - EZ Access Seat Latch Replacement
DECEMBER 1989 Recall - Brake Master Cylinder Replacement
Technical Service Bulletin Titles for 1990 Ford Truck Aerostar 2WD V6-245 4.0L
JANUARY 1992 Campaign - Running Light Module, Extended Coverage
Technical Service Bulletin Titles for 1990 Ford Truck Aerostar 2WD V6-245 4.0L
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
AUGUST 2002 Audio System - Whining/Buzzing Noise From Speakers
NOVEMBER 2001 Engine Coolant - Propylene Glycol Recommendations
OCTOBER 2001 Engine - Carbon Knock On Acceleration
MAY 2001 Wire Harness - Terminal Repair Kit
APRIL 2001 Fuel Pump - Whine Heard Through Radio Speakers
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
DECEMBER 1999 Fuel Economy - Customer Expectation vs. Vehicle Usage
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
MAY 1999 Motor Oil - Viscosity Grade Recommendation
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
NOVEMBER 1998 Engine - Lean Driveability Symptoms
NOVEMBER 1998 Front Drive Axle - Fluid Leak From Vent
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brake Service - Service Tips
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Vehicle - Towing Behind RVs Guidelines
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
FEBRUARY 1998 Paint - Procedure/Products For Plastic Service Parts
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
SEPTEMBER 1997 Universal Joint - Greasable Design Availability
AUGUST 1997 Rear View Mirror - Reattachment
FEBRUARY 1997 Frame - Rivet Replacement with Bolts Service Tip
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
AUGUST 1996 Rear Axle - Whine/Howl At Light Throttle
JULY 1996 A/C System - Service TSB List
JUNE 1996 Differential - Chatter On Turns
MAY 1996 Fuel - California Reformulated Gasoline
MARCH 1996 Steering - Rapping or Clanging Noise
JANUARY 1996 A/T - A4LD Bellhousing & Pump Interchange
JANUARY 1996 A/T - A4LD Support Ring Identification
JANUARY 1996 A/T - A4LD, 4R44E/4R55E Pump Interchangeability
DECEMBER 1995 Door Lock Cylinder - Loose in Replacement Door
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
SEPTEMBER 1995 Temperature Gauge - Fluctuation/Inaccurate
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
AUGUST 1995 Air Conditioning - Poor Performance
AUGUST 1995 Body - Roof Panel and Drip Rail Repairs
AUGUST 1995 Replacement Sliding Door - Service Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
MAY 1995 Connector, DIS Ignition Revised
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 Rocker Panel - Front/Rear Rust Perforation
MARCH 1995 A/C - Adding Refrigerant Oil Service Tip
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 Electronic Fuel Gauge - Erratic Readings
JANUARY 1995 Rear Main Oil Seal Replacement - Service Tip
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Front Door Glass - Binds During Downward Travel
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
SEPTEMBER 1994 Sliding Door Weatherstrip - Worn or Damaged
SEPTEMBER 1994 Engine - Revised Torque Procedures and Specifications
AUGUST 1994 Rear View Mirror - Detaches From Windshield
JULY 1994 A/C Compressor - Service Tips
JULY 1994 Accelerator Cable - Service Procedures/Tips
JULY 1994 Passenger Seat Back - Rattles When Unoccupied
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 Engine - Multiple Oil Leaks
APRIL 1994 Fuel Injector Cleaner - Parts and Service Tips
MARCH 1994 A/T - A4LD Servo Cover Heat Shield
FEBRUARY 1994 Rear Crankshaft Oil Seal/Dipstick Tube - Leaks Oil
JANUARY 1994 A/T - A4LD Cooler Line Fittings
JANUARY 1994 A/T - Binding Condition In Park
JANUARY 1994 A/T - E40D Second Gear Starts
JANUARY 1994 A/T - Pump Damage After Overhaul
DECEMBER 1993 Heated Backlite - Inoperative
DECEMBER 1993 Power Steering System - Noisy
DECEMBER 1993 Starter Solenoids and Drives - Obsolete Parts Return
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 EGO Sensors - Silicone Contamination
NOVEMBER 1993 Engine Gasket Surface - Cleaning Procedures
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Trailer Tow Relay Module - Location Clarification
AUGUST 1993 Brake Computer Module - Obsolete Service Part Return
AUGUST 1993 Rear Anti-Lock Brakes - Adverse Characteristics
AUGUST 1993 A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
AUGUST 1993 A/T - A4LD Premature Converter Bushing Failure
JULY 1993 Antilock Brakes - Service Tips
JULY 1993 A/T - Increase In RPM During Light Throttle 2-3 Upshifts
JULY 1993 Bumper - Loose or Unattached Ends
JULY 1993 Muffler - Corrodes Prematurely
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
MAY 1993 Brakes - Sticking/Binding/Grabbing
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
APRIL 1993 A/T - A4LD 4-3 Gear Flare, No Engagement in O/D
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Fuel Line - Knocking Noises
JANUARY 1993 Cooling System - Proper Fluid Concentrations
DECEMBER 1992 Cooling Fan Blade - Revised Design Available
DECEMBER 1992 Engine - Repair Tips to Avoid Potential Damage
DECEMBER 1992 Fuel Pump - Noise/Whine
DECEMBER 1992 A/T - A4LD No Reverse
NOVEMBER 1992 A/C Compressor - Oil Recovery & Measuring Procedure
OCTOBER 1992 Rear Brakes - Squeal Noise When Cold
SEPTEMBER 1992 A/C Clutch - Slips At High Ambient Temperature
SEPTEMBER 1992 A/T - A4LD Parts Return of Obsolete Shift Cable
AUGUST 1992 A/C Compressor - Oil Recovery/Measuring Procedures
AUGUST 1992 Noise/Vibration/Ride Harshness - Diagnostic Chart
AUGUST 1992 A/T - A4LD No 4th Gear
JULY 1992 Front Brakes - Popping or Clunking Noise
JULY 1992 Rear Seat Headphone Speaker - Control Knob Available
JUNE 1992 A/C Compressor - Noise
JUNE 1992 Starter Motor Brushes - Replacement Revision
JUNE 1992 Nylon Fuel Lines - Servicing Procedure
JUNE 1992 Speedometer - Indicates High Speed When Cold
MAY 1992 Fuel System - Fuel Stabilizer For Extended Storage
MAY 1992 Transfer Case - E4WD Fluid Leaks
FEBRUARY 1992 A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
FEBRUARY 1992 A/T - A4LD Converter Channel Spring Addition
FEBRUARY 1992 Safety Belts - Front/Rear Twisted at `D` Ring
JANUARY 1992 Four Wheel Drive (4 X 4) - General Information
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 Ignition Pinpoint Tests - Service Tips
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Brake Hoses - Wet Appearance
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
SEPTEMBER 1991 M/T - Crunching Shifting From 2nd to 3rd Gear
SEPTEMBER 1991 M/T Clutch Housing - Fluid Inside
AUGUST 1991 Transfer Case - (E4WD) Noise/Vibration
AUGUST 1991 Driveline (E4WD) - Popping/Tires Chirping/Wheel Hop
AUGUST 1991 A/T - A4LD No Movement After Rebuild
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 Rear Pinion Angle Offset - Manual Correction
JULY 1991 A/T - A4LD No Reverse After Rebuild
JUNE 1991 Fuel Gauge - Intermittently Shows Increase In Fuel Level
JUNE 1991 IDM and Spark Timing Diagnosis - Manual Revision
MAY 1991 A/T - Floor Shifter Binding
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 M/T - M50D Hard Shift Condition
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Rocker Cover Gasket - Installation Revision
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 A/T - Slips or No 3 or Reverse, 2-3 Flare
FEBRUARY 1991 Climate Control - Improper Operation
DECEMBER 1990 Antilock Control Test Step 4B - Manual Revision
DECEMBER 1990 Steering Gear - Removal/Installation Revision
DECEMBER 1990 Cooling System - Excessive Coolant Overflow
DECEMBER 1990 Speed Control - Diagnostic Tips
NOVEMBER 1990 Instrument Cluster - Dim or Blank Display
OCTOBER 1990 A/C System - Not Cooling Satisfactorily
OCTOBER 1990 A/T - A4LD Delayed Upshift or No Upshift
OCTOBER 1990 Audio Systems - Authorized Service Centers
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Seat Belt - Shoulder Strap Webbing Twisted
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
SEPTEMBER 1990 Speed Sensor Resistance Reading - Manual Revision
AUGUST 1990 Octane Adjust Diagnostic Information - Addition
JULY 1990 Rear Suspension - Clapping Noise On Bumps
JULY 1990 Brake Caliper - Lubrication Of Top & Bottom Groove
JUNE 1990 Front Alignment - Specifications
JUNE 1990 A/T - A4LD Disassembly/Assembly Revision
JUNE 1990 Steering Column Support Brackets - Loose
JUNE 1990 A/T - A4LD Front Seal Blow Out
MAY 1990 Body/Frame - Arc Welding Precautions
MAY 1990 A/T - A4LD Slipping or Soft Shifts After Rebuild
APRIL 1990 Heater - Insufficient Heat To Front Seat Floor Area
APRIL 1990 Seats - Optional Under Seat Storage Bin
MARCH 1990 EDIS System Diagnostic Procedures - Manual Revision
MARCH 1990 Distributorless Ignition - Diagnostics To Be Published
MARCH 1990 VECI Decal - Initial Index
FEBRUARY 1990 Front Door Window Regulator - Binding/Inoperative
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
JANUARY 1990 Seat Shoulder/Lap Belt - Production Updates
JANUARY 1990 Ford RTV Sealer - Shelf Life
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 EEC IV - Revised Pinpoint Test Steps
DECEMBER 1989 Steering Wheel - Removal Precautions
NOVEMBER 1989 Fuel Pump/Sender - Defective Parts Return
NOVEMBER 1989 Door Window Bracket Assembly - Part Return
NOVEMBER 1989 A/C Compressor Shaft Seal - Leaks
NOVEMBER 1989 Brakes - False or Dropping Pedal
NOVEMBER 1989 Exhaust System - Alignment
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
MAY 1989 Power Steering Pump - New Design Fitting At Pump Outlet
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 A/T - A4LD Delay In Reverse/Occasional No-Reverse
JANUARY 1989 A/T - A4LD Overdrive Sun Gear Support Inspection
JUNE 1988 Electronic Modules - Protection From Static Electricity
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JANUARY 1985 A/T - A4LD/C3 Front Pump Support Inspection
|
