 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1989 Volvo 780 L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1989 Volvo.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1989 Volvo 780 L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT
JULY 1999 Recall - Follow Up to Bulletin Number 82
Technical Service Bulletin Titles for 1989 Volvo 780 L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT
MARCH 1998 Campaign - Rerouting of Seat Cable Harnesses
Technical Service Bulletin Titles for 1989 Volvo 780 L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT
JULY 2006 Air Bag System - System Life Expectancy
DECEMBER 2005 A/T - Engine Coolant Contamination Detection
OCTOBER 2005 A/T, M/T, AWD - Approved Lubricants
APRIL 2003 Interior - Extended Airbag Service Life
JULY 2000 Seat Belt - Extensions
AUGUST 1998 Suspension - Installing Rear Shock Absorber Bearing
JULY 1998 Tools - Replacing Control Arm Bushing
MAY 1998 Airbag Sensor - Modifying
FEBRUARY 1998 ABS Wheel Sensor - Installation Tool
SEPTEMBER 1997 A/C - Unpleasent Odor On Startup
JUNE 1997 Power Steering Pressure Hose - Revised Clamp Required
MARCH 1997 Air Recirculation Intake Grille - Small Debris Entering
MARCH 1997 Jack - New Type, Mounting
AUGUST 1996 Coolant Pump - Bleed Hole Cleaning
AUGUST 1996 Tools - Installing Clutch and Pressure Plate
JUNE 1996 Parking Brake Cable Bracket - Replacement
NOVEMBER 1995 A/C - Supplement to Service Bulletin 8-87-217
NOVEMBER 1995 Electronic Management Systems - Guide To Fault Tracing
JULY 1995 Paint - Approved Products
JULY 1995 Warranty - Corrosion Inspection Claim
MAY 1995 Body - New Repair Equipment and Chemicals
MARCH 1995 A/C - Conversion, R12 to R134a
MARCH 1995 Body - Using Surge Protectors While Arc Welding
MARCH 1995 Body Fittings - Service Manual Change
MARCH 1995 Welding Precautions for Electrical Components
FEBRUARY 1995 Engine Oil - Recommended
FEBRUARY 1995 SRS Collision Sensor - Revised
FEBRUARY 1995 Throttle Switch/Mechanism - Adjustment
JANUARY 1995 Tools - New Address For Mono Tester Repairs
DECEMBER 1994 Power Seat - Height Adjuster
NOVEMBER 1994 Body - Changes in Service Manual Section 8
AUGUST 1994 Final Drive - Revisions, Identification and Repair
AUGUST 1994 Fuel & Ignition Systems - Fault Tracing
AUGUST 1994 TSB 28102 (May 1994) Information Update
JULY 1994 Window - Replacement, Manual Supplement
JUNE 1994 Alignment - New Wheel Angle Tolerances
MAY 1994 Electrical - Ground Test By Voltage Drop
MAY 1994 Fuel Control Unit - Updated to Improve Cold Starting
APRIL 1994 A/C - Condenser/Pressure Pipe Connections Changed
MARCH 1994 Tools - Engine, Oxygen Sensor, Temp Sensor
MARCH 1994 Turbocharger - Severe Idle Dip, Reduced Performance
FEBRUARY 1994 A/C - Improved Recirculation Function
FEBRUARY 1994 Brake Caliper - Rattling Sound
FEBRUARY 1994 Tools - Installation of Pinion Seal
JANUARY 1994 Engine - Cold Start Condition
NOVEMBER 1993 A/C - False Indication of Leak From High Pressure Hose
OCTOBER 1993 A/T - Failsafe Modes
OCTOBER 1993 Camshaft/Intermediate Shaft - Revised Seal
SEPTEMBER 1993 Power Antenna - Malfunction
JUNE 1993 Odometer - Information Sticker Used After Replacing
MAY 1993 Body - Replacement Parts Modifications
APRIL 1993 A/C - Replacement of Blower Motor
MARCH 1993 Engine Control Module LH - Cold Driveability Improvement
MARCH 1993 Engine Controls - Driveability Problems
MARCH 1993 Three Way Converter - Replacement of Pressed Bolts
FEBRUARY 1993 Coolant Thermostat - Venting Nipple Location
FEBRUARY 1993 Scan Tool - Usage During Trouble Code Diagnostics
JANUARY 1993 Catalytic Converter - Replacement On EGR Equipped Cars
JANUARY 1993 Heater - New Design Fan Housing
JANUARY 1993 Oil - Abnormal Consumption
DECEMBER 1992 Body - Whistle/Wiper Well Cover Panel Sealing strip
DECEMBER 1992 Sealed Crimping Sleeve - New
NOVEMBER 1992 A/T - ZF 4 HP-22 Slipping/No Reverse/3-4 Shuttle Shift
NOVEMBER 1992 Door Switch - Revised
NOVEMBER 1992 Piston - Clearance In Used Engines
NOVEMBER 1992 Seat Belt - Extender Availability For Front Seats
OCTOBER 1992 Safety Instructions - Fluoroelastomer Seals
OCTOBER 1992 Safety Precaution - Fluoroelastomer (Viton®) Seals
OCTOBER 1992 Tank Sending Unit - Replacement For Tanks W/Metal Flange
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
SEPTEMBER 1992 A/T - ZF 4HP 22 Valve Body Identification
AUGUST 1992 Engine - Hard Cold Starting and Performance
JUNE 1992 Wheel Hub Assembly - Check/Replace Update
MAY 1992 A/T - ZF Orifice Placement
MAY 1992 Carrier Plate Impulse Wheel - Damage
MAY 1992 Differential Housing - Upper Bushing R&R Correction
MAY 1992 Differential Housing - Upper Bushing Service Correction
MAY 1992 Engine Oils - Suggested Usage
MAY 1992 Outside Mirror Glass - Replacement
APRIL 1992 Steering Column - Popping Noise Reference Bulletin
APRIL 1992 Steering Column - Reference Bulletin for Popping Noise
FEBRUARY 1992 ABS - Troubleshooting Tips
FEBRUARY 1992 M/T - Improved Reverse Shift Quality
JANUARY 1992 A/C - Fan Motor Whining/Humming at Low Speed
JANUARY 1992 Cruise Control - Correction to Fault Tracing
JANUARY 1992 Cruise Control - Correction to Fault Tracing in Manual
DECEMBER 1991 ABS - Warning Lamp ON
DECEMBER 1991 Rear Axle Toothed Wheel/Inductive Pickup - Clearance
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
NOVEMBER 1991 Interior - Noise From Seats and Panels
OCTOBER 1991 Radio - Noise Interference
SEPTEMBER 1991 A/C - Control Panel Modification to Fit Earlier Models
SEPTEMBER 1991 M/T - Replacing Short Dog Keys With Long Dog Keys
SEPTEMBER 1991 Windshield Moulding - Noise
AUGUST 1991 Alignment - Camber & Caster Adjustment
AUGUST 1991 LH Fuel Injection Control Unit - Exchange
AUGUST 1991 M/T - New Driven Plates and Release Bearing
JULY 1991 SRS - Correction to Manual
JUNE 1991 A/T - ZF4HP22 Clutch A (Foward) Failure
MAY 1991 Throttle Switch/Mechanism - Adjust, Clean, Center
APRIL 1991 Front Brake Caliper - Revised
MARCH 1991 Battery - Charging Voltage
FEBRUARY 1991 Tools - Measuring Brake Disc and Hub Runout
JANUARY 1991 Alignment - Revised Front Toe Specification
JANUARY 1991 Drive Shaft - Take-Off Vibration at Low Speed
JANUARY 1991 Fuel Injection Control Unit - Exchange
JANUARY 1991 Fuel Tank Sender Ground Lead - Modification
JANUARY 1991 Rear Axle - Lubricating Oil Recommendations
DECEMBER 1990 ATF Filter - Cleaning Deleted
DECEMBER 1990 Engine Oil - Viscosity Recommendation
DECEMBER 1990 Radio - Interference On AM Band
NOVEMBER 1990 A/C - Check for Chafing Hoses & Pipes
NOVEMBER 1990 Battery Ground Cable - New Routing
OCTOBER 1990 A/T - Engine Vacuum Testing
OCTOBER 1990 A/T - ZF 4HP-22 Pressure Tap Locations
OCTOBER 1990 A/T - ZF4HP22 Pressure Fitting Modification
OCTOBER 1990 Gislaved and Nord Frost Tires - Warranty Information
OCTOBER 1990 Seat Belt - Extender Available
OCTOBER 1990 Warranty - Coverage In New York
SEPTEMBER 1990 Paint - New Supplier
SEPTEMBER 1990 Suspension - Self-Levelling Shock Absorber Operation
SEPTEMBER 1990 Windshield Washer Jets - New Filter
AUGUST 1990 Front, Rear Brake Pad - Parts List
AUGUST 1990 M/T - Revised Hydraulic Pistons and O-Rings
JULY 1990 ABS Hydraulic Modulator - Revised
JULY 1990 Audio - Diagnostic Check List
JULY 1990 Tools - Charging Station/R-12 Recycling Units Available
JULY 1990 Tools - Special Tool (5407) Must Be Checked
JUNE 1990 A/C - Center Dash Air Vent Repair
JUNE 1990 SRS - Replacing Crash Sensor, Labor Revision
JUNE 1990 SRS Tool - Resistance Measurement
JUNE 1990 Tools - Light Duty R12 Recovery/Recycling Unit Available
MAY 1990 A/C - Evaporator Condensate Drainage
MAY 1990 CU & AC Dash Controls - New Indicating Panel
MAY 1990 Cooling System - Recycled Antifreeze
MAY 1990 SRS Crash Sensor - Manual Revision
MAY 1990 Tools - Volvo Multifunction Tester Updates
MAY 1990 Unleaded Fuel - Usage In Earlier Models
APRIL 1990 A/C - Evaporator Condensate Drainage Modification
APRIL 1990 Brakes - Resonance In Steering Wheel During Braking
APRIL 1990 First Gear/Needle Bearings - Revised
APRIL 1990 Suspension - Tips For Installation of Nivomat Shocks
APRIL 1990 Tools - R12 Recycling Equipment
MARCH 1990 SRS - Deployment/Handling/Ordering/Replacement
MARCH 1990 Tools - Replacement Parts or Repairs Made By Motometer
FEBRUARY 1990 A/T - Choosing the Right ATF
FEBRUARY 1990 A/T Fluid - Correct Applications
FEBRUARY 1990 CIS Valve - Check Procedures
FEBRUARY 1990 CIS Valve - Checking Procedures
FEBRUARY 1990 MTBE - Oxygenated Fuel Description
FEBRUARY 1990 Tools - Bulletin Indexes
FEBRUARY 1990 Tools - Modification of Rear Cranshaft Seal Tool
FEBRUARY 1990 Tools - P70 Wheel Nut Torque
JANUARY 1990 A/T - ZF4HP22 Burning A (Foward) Clutch
JANUARY 1990 EVAP Carbon Filter - Revised
JANUARY 1990 Radio - Buzzing Noise
JANUARY 1990 Speedometer Connector - Sealing After Repairs
JANUARY 1990 Warranty - Allowance For Federal Tax On Freon
NOVEMBER 1989 A/C - Odor Elimination
NOVEMBER 1989 Tools - New Special Tools Available
OCTOBER 1989 A/T - Math Part II
OCTOBER 1989 A/T - ZF4HP22 Check Ball and Orifice Locations
OCTOBER 1989 A/T - ZF4HP22 Clutch Application Chart
OCTOBER 1989 Engine Controls - Fault Tracing
OCTOBER 1989 Interior - Front Seat Height
OCTOBER 1989 Tools - Volvo Multifunction Tester
OCTOBER 1989 Turbo Charger - Check List Form
OCTOBER 1989 Warranty - Authorization For Goodwill Spending
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
SEPTEMBER 1989 Antitheft Alarm - Fault Tracing (Watchdog 2)
SEPTEMBER 1989 Cam Gear P/S Racks - Bleeding
SEPTEMBER 1989 Glass - Replacement
SEPTEMBER 1989 Warranty - Claim Resubmission
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 I/P, Knee Bolster Member - Modification
JUNE 1989 Steering Column - Revised Clicking Noise Elimination
OCTOBER 1988 Instrument Panel - New Design Wood Paneling
OCTOBER 1988 Mirror - Popping Noise in Audio System
SEPTEMBER 1988 A/T - ZF 4HP-22 Clutch A (Foward) Failure
SEPTEMBER 1988 Canadian Warranty Poster
SEPTEMBER 1988 Turbo Charger - Diagnostics
SEPTEMBER 1988 U.S. Warranty Poster
JUNE 1988 M/T - Slips Out of 1st Gear
JUNE 1988 Valve Cover - Oil Leakage
MAY 1988 Tools - New and Modified
APRIL 1988 Body - New Adhesive
FEBRUARY 1988 Cooling System - Checking Excessive Coolant Loss
NOVEMBER 1987 Crankshaft and Main Bearings - Modifications
SEPTEMBER 1987 A/T - Front Bushing Wear
SEPTEMBER 1987 SRS - Identification Number Recording
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JUNE 1981 Emissions - Venting Turbo Exhaust from Shop
|
