 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1989 Volvo 240 L4-2.3L SOHC VIN 88 B230F
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1989 Volvo.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1989 Volvo 240 L4-2.3L SOHC VIN 88 B230F
JULY 2006 Air Bag System - System Life Expectancy
DECEMBER 2005 A/T - Engine Coolant Contamination Detection
OCTOBER 2005 A/T, M/T, AWD - Approved Lubricants
APRIL 2003 Interior - Extended Airbag Service Life
JULY 2000 Seat Belt - Extensions
JANUARY 1998 A/C Compressor Pulley & Clutch - Replacing
JANUARY 1998 Tools - Scan Tool Repair Adress Incorrect in Manual
JULY 1997 Engine Performance - Poor Driveability
JANUARY 1997 Tools - Replacing Trailing Arm Bushing
DECEMBER 1996 Body - Template for Modifying Windshield Frame
OCTOBER 1996 Engine Management Systems - Parts, Information
MAY 1996 Electrical - New Cable Terminals as a Replacement Part
NOVEMBER 1995 A/C - Supplement to Service Bulletin 8-87-217
JULY 1995 Paint - Approved Products
JULY 1995 Warranty - Corrosion Inspection Claim
JUNE 1995 Windshield - Replacement with PUR Bonded Windshield
MAY 1995 A/C - Cleaning The Heater Unit Drainage Hose
APRIL 1995 A/C System - Retrofit Conversion from R12 to R134a
APRIL 1995 Body - New Repair Equipment and Chemicals
MARCH 1995 Body - Welding Precautions for Electronic Components
FEBRUARY 1995 A/C - Heater Unit Drain Hose Cleaning
FEBRUARY 1995 Body - Rear Floor Panel Available
FEBRUARY 1995 Body - Rear Floor Panel, Crossmember and Side Wells
FEBRUARY 1995 Engine Oil - Recommended
FEBRUARY 1995 Throttle Switch/Mechanism - Adjustment
JANUARY 1995 Tools - New Address For Mono Tester Repairs
MAY 1994 Body - Front Panel Has Been Modified
MAY 1994 Electrical Test - Measuring Voltage Drop Across Grounds
MAY 1994 Fuel Control Unit - Updated to Improve Cold Starting
MAY 1994 Temperature Sensor - Service Manual Correction
MARCH 1994 Tools - Engine, Oxygen Sensor, Temp Sensor
FEBRUARY 1994 A/C - Cleaning the Heater Unit Drainage Hose
FEBRUARY 1994 Pinion Seal - Revised & Installation
DECEMBER 1993 Coolant Temperature Gauge - False Hot Reading
OCTOBER 1993 A/T - Failsafe Modes
OCTOBER 1993 Camshaft/Intermediate Shaft - Revised Seal
SEPTEMBER 1993 A/C - New Heater Control Valve Supercedes Earlier Type
SEPTEMBER 1993 Power Antenna - Malfunction
AUGUST 1993 Engine Controls - Stalls, Hesitation, Poor Driveability
JUNE 1993 Odometer - Information Sticker Used After Replacing
APRIL 1993 Brake Pads - Minimizing Brake Noise
APRIL 1993 Sunroof - Water Leaks
MARCH 1993 Engine Control Module LH - Cold Driveability Improvement
MARCH 1993 Engine Controls - Driveability Problems
MARCH 1993 Three Way Converter - Replacement of Pressed Bolts
FEBRUARY 1993 Coolant Thermostat - Venting Nipple Location
FEBRUARY 1993 Scan Tool - Usage During Trouble Code Diagnostics
JANUARY 1993 Oil - Abnormal Consumption
DECEMBER 1992 Sealed Crimping Sleeve - New
DECEMBER 1992 Windshield Wiper Motor - Grounding
NOVEMBER 1992 A/C - Performance Improvement
NOVEMBER 1992 A/T - ZF 4 HP-22 Slipping/No Reverse/3-4 Shuttle Shift
NOVEMBER 1992 Ignition Cable Harness - Replacement
NOVEMBER 1992 Piston - Clearance In Used Engines
NOVEMBER 1992 Seat Belt - Extender Availability For Front Seats
OCTOBER 1992 Safety Instructions - Fluoroelastomer Seals
OCTOBER 1992 Safety Precaution - Fluoroelastomer (Viton®) Seals
SEPTEMBER 1992 A/T - Intermittent Electrical Problems
SEPTEMBER 1992 A/T - ZF 4HP 22 Valve Body Identification
AUGUST 1992 Engine - Hard Cold Starting and Performance
MAY 1992 A/T - ZF Orifice Placement
MAY 1992 Carrier Plate Impulse Wheel - Damage
MAY 1992 Engine Oils - Suggested Usage
MAY 1992 Outside Mirror Glass - Replacement
FEBRUARY 1992 M/T - Improved Reverse Shift Quality
DECEMBER 1991 ABS - Warning Lamp ON
DECEMBER 1991 Fuel System - Cold Start Valve, Fault Tracing Correction
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
SEPTEMBER 1991 M/T - Replacing Short Dog Keys With Long Dog Keys
AUGUST 1991 LH Fuel Injection Control Unit - Exchange
AUGUST 1991 M/T - New Driven Plates and Release Bearing
JULY 1991 SRS - Correction to Manual
JUNE 1991 A/T - ZF4HP22 Clutch A (Foward) Failure
MAY 1991 Throttle Switch/Mechanism - Adjust, Clean, Center
MARCH 1991 Alignment - Revised Front Camber Specifications
MARCH 1991 Battery - Charging Voltage
MARCH 1991 Gear Lever - Rattle
FEBRUARY 1991 Tools - Measuring Brake Disc and Hub Runout
JANUARY 1991 Drive Shaft - Take-Off Vibration at Low Speed
JANUARY 1991 Fuel Injection Control Unit - Exchange
JANUARY 1991 Rear Axle - Lubricating Oil Recommendations
DECEMBER 1990 ATF Filter - Cleaning Deleted
DECEMBER 1990 Diagnostic System - Prone to Disturbance
DECEMBER 1990 Engine Oil - Viscosity Recommendation
NOVEMBER 1990 Wheel Cover/Emblem - Replacement
OCTOBER 1990 A/T - Engine Vacuum Testing
OCTOBER 1990 A/T - ZF 4HP-22 Pressure Tap Locations
OCTOBER 1990 A/T - ZF4HP22 Pressure Fitting Modification
OCTOBER 1990 Gislaved and Nord Frost Tires - Warranty Information
OCTOBER 1990 Seat Belt - Extender Available
OCTOBER 1990 Warranty - Coverage In New York
SEPTEMBER 1990 A/C - New Blower Motor Fan Mounting
SEPTEMBER 1990 Paint - New Supplier
JULY 1990 Audio - Diagnostic Check List
JULY 1990 Body - Water Sealing/Holes In the Body From Accessories
JULY 1990 Engine Controls - Update to Service Manual TP 31361/1
JULY 1990 Strut Tower - Mounting Holes Changed
JULY 1990 Tools - Charging Station/R-12 Recycling Units Available
JULY 1990 Tools - Special Tool (5407) Must Be Checked
JUNE 1990 Tools - Light Duty R12 Recovery/Recycling Unit Available
MAY 1990 Cooling System - Recycled Antifreeze
MAY 1990 Tools - Volvo Multifunction Tester Updates
MAY 1990 Unleaded Fuel - Usage In Earlier Models
APRIL 1990 First Gear/Needle Bearings - Revised
APRIL 1990 Tools - R12 Recycling Equipment
MARCH 1990 SRS - Deployment/Handling/Ordering/Replacement
MARCH 1990 Tools - Replacement Parts or Repairs Made By Motometer
FEBRUARY 1990 A/T - Choosing the Right ATF
FEBRUARY 1990 A/T - Correct Fluid Applications
FEBRUARY 1990 CIS Valve - Check Procedures
FEBRUARY 1990 MTBE - Oxygenated Fuel Description
FEBRUARY 1990 Tools - Bulletin Indexes
JANUARY 1990 A/T - ZF4HP22 Burning A (Foward) Clutch
JANUARY 1990 EVAP Carbon Filter - Revised
JANUARY 1990 Speedometer Connector - Sealing
JANUARY 1990 Warranty - Allowance For Federal Tax On Freon
NOVEMBER 1989 Tools - New Special Tools Available
OCTOBER 1989 A/T - Math Part II
OCTOBER 1989 A/T - ZF4HP22 Check Ball and Orifice Locations
OCTOBER 1989 A/T - ZF4HP22 Clutch Application Chart
OCTOBER 1989 Engine Controls - Fault Tracing
OCTOBER 1989 Tools - Volvo Multifunction Tester
OCTOBER 1989 Warranty - Authorization For Goodwill Spending
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
SEPTEMBER 1989 Cam Gear P/S Racks - Bleeding
SEPTEMBER 1989 Glass - Replacement
SEPTEMBER 1989 P20 Service Literature Update
SEPTEMBER 1989 Warranty - Claim Resubmission
AUGUST 1989 A/C - New Type of O-Ring
AUGUST 1989 A/T - Math Formulas Part I
AUGUST 1989 Sunroof - Leaks
MARCH 1989 A/C - Leakage at Compressor Filler Valve
OCTOBER 1988 Mirror - Popping Noise in Audio System
SEPTEMBER 1988 A/T - ZF 4HP-22 Clutch A (Foward) Failure
SEPTEMBER 1988 Canadian Warranty Poster
SEPTEMBER 1988 Turbo Charger - Diagnostics
SEPTEMBER 1988 U.S. Warranty Poster
JUNE 1988 M/T - Slips Out of 1st Gear
JUNE 1988 Valve Cover - Oil Leakage
MAY 1988 Backup Lens - Replacement
MAY 1988 Tools - New and Modified
APRIL 1988 Body - New Adhesive
FEBRUARY 1988 Water Pump - Checking
NOVEMBER 1987 Crankshaft and Main Bearings - Modifications
SEPTEMBER 1987 A/T - Front Bushing Wear
SEPTEMBER 1987 SRS - Identification Number Recording
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 2631 - 07/01/87
|
