 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1987 Mercury Cougar/XR7 V6-232 3.8L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1987 Mercury.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1987 Mercury Cougar/XR7 V6-232 3.8L
MAY 1992 Recall - Catalyst Inspection and/or Replacement
JANUARY 1992 Recall - Catalyst Inspection/Replacement
OCTOBER 1990 Recall - Emission System Modification
Technical Service Bulletin Titles for 1987 Mercury Cougar/XR7 V6-232 3.8L
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
MAY 2001 Wire Harness - Terminal Repair Kit
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
MAY 1996 Fuel - California Reformulated Gasoline
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
JANUARY 1995 A/T - Drive Axle and Wheel Lug Nut Torque Specifications
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
JULY 1994 R-12 Refrigerant - Substitutes
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
JANUARY 1994 A/T - AODE Cooler Return Line Filter Installation
DECEMBER 1993 Heated Backlite - Inoperative
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 A/T - AOD Diagnostic Information
NOVEMBER 1993 EATC or Instrument Display - Dim or Blank
NOVEMBER 1993 EGO Sensors - Silicone Contamination
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
MARCH 1993 A/C Coupling - Cleaning Procedures
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 TAD and EGR Control - Location Correction
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Power Window Regulator - Counterbalance Spring
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 A/T - AOD Direct Clutch Failure/Excessive Case Bore Wear
MAY 1991 EATC - Redesigned Replacement Control Head
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 A/T - AOD 4th Gear Complaints
DECEMBER 1990 EEC IV Code 45 Diagnostic Procedure - Revised
DECEMBER 1990 Speed Control - Diagnostic Tips
NOVEMBER 1990 Instrument Cluster - Dim or Blank Display
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Seat Track - Sticking/Slow/Inoperative
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 Idle Speed Control Schematics - Revision
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
AUGUST 1990 Fuel Pump - Buzzing/Humming After Engine Shut Down
JULY 1990 Lower Body Stone Protection - Repair Procedure
JUNE 1990 Wheels - Loss Of Balance Weights
MAY 1990 Body/Frame - Arc Welding Precautions
MARCH 1990 ISC Actuator Pinpoint Test K - Manual Revision
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 EEC IV Quick Test - Continuous Self-Test Chart
DECEMBER 1989 Engine - Rough Idling Condition
NOVEMBER 1989 A/T - AOD Separator Plate Gasket Changes
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Ignition Key Warning Switch - Replacement Procedure
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 EVP Sensor - Manual Revision
SEPTEMBER 1989 Heated Backlite Grid - Manual Updates
SEPTEMBER 1989 Key On Engine Off Self Test Procedure - Manual Revision
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 Aluminum Wheel - Air Leaks
AUGUST 1989 Throttle Position Sensor - Application Chart
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 Fuel Injectors - Rotunda Injector Tester/Cleaner
JULY 1989 Speakers - Sound Distortion/Erratic Operation
JULY 1989 A/C - Pressure Cycling Switch Diagnostic Procedure
JULY 1989 Fuel Tank Sending Unit - Connector Replacement
JULY 1989 TPS Mounting Screws - Hard to Remove
JULY 1989 A/T - AOD Governor Pressure Leaks
JUNE 1989 Paint - Cosmetic Damage From Airborn Materials
JUNE 1989 Memory Seat Sensors - Procedure Revision
JUNE 1989 Pin Point Test B/Keyless Door Entry System - Revision
JUNE 1989 A/T - Rear Planet Failure/Lack Of Lubrication
JUNE 1989 Adhesives & Sealants - Availability and Usage
JUNE 1989 Emission Control System - Technician`s Glossary
JUNE 1989 Windshield - Revised Installation Procedure
MAY 1989 A/T - AOD Case Thread Update
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 Engine - Normal Oil Consumption
APRIL 1989 A/T - AOD No Manual Low Gear
MARCH 1989 Distributor Gear - Service Tips
MARCH 1989 Electronic Fuel Gauge - Will Not Display Full
MARCH 1989 Ignition System - Diagnostics Manual Correction
MARCH 1989 Engine Mounts - Parts Application/Usage
MARCH 1989 Memory Seat - Diagnostic Manual Supplement
MARCH 1989 A/T - AOD 3-4 Accumulator Change
FEBRUARY 1989 Speed Control - Abnormal Operation When Hot
JANUARY 1989 Speedometer/Odometer - Inaccurate Readings
JANUARY 1989 MAP and BAP Sensor - Application Chart
DECEMBER 1988 A/C Suction Accumulator - Manual Revision
DECEMBER 1988 Safety Belt - Tongue Cover Now Available
NOVEMBER 1988 Engine - Bucks/Jerks During Deceleration
SEPTEMBER 1988 Engine - No Start or Hard Start Condition
SEPTEMBER 1988 Speakers - Popping Noise When Operating The Windows
SEPTEMBER 1988 A/T - AOD Failure In Rear Of Transmission/No Lubrication
SEPTEMBER 1988 A/T - AOD Kills Engine In Reverse and/or Forward Gears
AUGUST 1988 A/C Temperature Display - Brightness Variation
AUGUST 1988 Engine - Hesitation/Lack Of Power/Rough Idle
AUGUST 1988 Steel Wheels - Available For Snow Tires
JULY 1988 EEC IV Emissions Diagnosis - Supplemental Information
JULY 1988 Safety Belts - Service Procedure, Manual Revision
JULY 1988 Vent Windows - May Stick to Weatherstrip
JULY 1988 A/T - Sprag Rotation
JUNE 1988 Electronic Modules - Protection From Static Electricity
JUNE 1988 A/T - Harsh 1-2 Upshift or Slide Bump 1-2 Upshift
MAY 1988 A/T - AOD Loss of Governor Pressure Through Valve Body
APRIL 1988 Engine - Oil Dipstick May Not Be Read Correctly
APRIL 1988 Vehicle Storage - Maintenance Tips
MARCH 1988 Chassis Components - Cosmetic Surface Rust
MARCH 1988 A/T - AOD Slip/Bump On Upshift/Downshift
MARCH 1988 Power Door Locks - Are Inoperative
MARCH 1988 Speedometer Display - Parts Return
FEBRUARY 1988 Blower Motor Wheel - New Solid Hub Design
FEBRUARY 1988 Front/Rear Stabilizer Bar Bushings - Squeak/Grunt Noise
FEBRUARY 1988 Sliding Roof Panel - Wind Noise/Water Leaks
FEBRUARY 1988 Steering Wheel - Clunk/Looseness
FEBRUARY 1988 A/T - AOD Burned Overdrive Band/End Play after Rebuild
JANUARY 1988 Graphic Display - False or No Warnings
DECEMBER 1987 Engine - Intermittent/Constant High Idle Speed
DECEMBER 1987 Doors and Ignition - Lock Service Tips
DECEMBER 1987 Power Door Locks - Inoperative
DECEMBER 1987 Vinyl Tape Stripes - Poor Adhesion
NOVEMBER 1987 A/T - AOD/A4LD Shift Cable Locks In PARK Mode
NOVEMBER 1987 Air Conditioning - Odor Service Procedure
NOVEMBER 1987 Rotunda Gas Chek Kit - Requires Modification
NOVEMBER 1987 A/T - AOD New Overdrive Band Anchor Pin
NOVEMBER 1987 Wheels/Tires - Vibration/Shake Diagnostic Procedure
OCTOBER 1987 TFI Module/PIP Sensor - New Diagnostic Procedure
OCTOBER 1987 Engine/Ignition - No Start Condition
OCTOBER 1987 Front/Rear Alignment - Specifications
OCTOBER 1987 Instrument Cluster Bulbs - Replacement Precaution
SEPTEMBER 1987 A/T - Fluid Leak At the Cooler Line Connections
SEPTEMBER 1987 A/T, M/T - New `Mercon` Transmission Fluid
SEPTEMBER 1987 Front/Rear Suspension - Spring Application Charts
SEPTEMBER 1987 Keyless Entry System - Diagnostic Procedure Correction
SEPTEMBER 1987 Paint - Lower Body Accent Stripe Poor Adhesion
SEPTEMBER 1987 Parking/Turn/Side Marker - Moisture Inside Lens
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 Engine - Rough Idle/Runs Rich/Stalls At Idle
AUGUST 1987 Fuel System - Injector Tester/Cleaner Service Tips
AUGUST 1987 Seat - Progammable Processor Self Test Feature
AUGUST 1987 Fuel Injectors - Mismarked Stock
AUGUST 1987 Keyless Entry System - Autolock Inoperative
AUGUST 1987 A/T - AOD No Fourth Gear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 Paint - Difficulty Matching Production Colors
JULY 1987 Wiring - Circuit Number/Color Code Charts
JULY 1987 A/T - AOD Valve Body Shoulder Bolt Locations
JULY 1987 Aluminum Wheels - Vibration/Shake
JULY 1987 Headlamp - Lens Moisture Diagnosis/Tips
JUNE 1987 Electric Fuel Pump - New Service Procedure
JUNE 1987 A/T - AOD High Pitched Noise In All Ranges
JUNE 1987 Manual Vent Windows - Hard to Open
MAY 1987 Engine - Light Surging/Bucking On Deceleration
MAY 1987 Main Control Assembly - Special Attaching Bolts
MAY 1987 Paint - Paint Stripes Peel
MAY 1987 Production Build Date Stamp - Relocation
MAY 1987 Engine - Correct Oil Fill Level Markings
MAY 1987 Oil Pan - Revised Shop Manual Removal/Installation
APRIL 1987 A/C - New `Tee` Type Service Adapter Tool
APRIL 1987 EGR Valve - New Service Part
APRIL 1987 Wiring - Positive Locking Micro-Pin Terminals
APRIL 1987 A/T - AOD Relief Valves For Valve Bodies
MARCH 1987 Moon Roof - Revised Removal/Installation
MARCH 1987 AM/FM Cassette Radio - Dial Lighting Dim
MARCH 1987 Hood Hinge - Squeaking and/or Rattling Noise
MARCH 1987 Windshield A Pillar Moulding - Clicking Noise
FEBRUARY 1987 M/T - Hummer 5 Speed Mainshaft Revision
FEBRUARY 1987 Steering - Pull or Drift
FEBRUARY 1987 Steering Gear - Attaching Hardware
FEBRUARY 1987 Wiring - Electrical System Troubleshooting Tips
FEBRUARY 1987 Fuel Line Spring Lock Coupling - Service Procedures
FEBRUARY 1987 Parking/Turn Lamp Assembly - Moisture Inside
JANUARY 1987 EEC Universal Distributor - Drive Gear Removal Tool
JANUARY 1987 Interior Trim - Recommended Clean Up Tips
JANUARY 1987 Wiring - Continuity Testing of Connector Terminals
JANUARY 1987 Accessory Drive Belt - `V` Ribbed Belt Cracking
JANUARY 1987 Paint - Color Chart/Supplier Cross Reference List
JANUARY 1987 Power Door Lock - Activated By Courtesy Lights
JANUARY 1987 A/T - 3-2 Too Sensitive, or No Part Throttle Downshift
JANUARY 1987 A/T - AOD No End Play/Overdrive Band Burned
DECEMBER 1986 Sheet Metal - Corrosion From Dealer Name Plate
DECEMBER 1986 A/T - AOD Torque Converter Identification
NOVEMBER 1986 A/C Compressor Clutch Assembly - Service Caution
NOVEMBER 1986 Front License Plate Bracket - Installation
OCTOBER 1986 Adhesive Backed Emblem - Loose/Missing
OCTOBER 1986 A/T - AOD Rough 1-2 Shift After Overhaul
OCTOBER 1986 A/T - Overdrive in 2nd Gear and Lockout/Binds in 1st
SEPTEMBER 1986 Sheet Metal - Theft Prevention Standard
JULY 1986 Fuel Sender - Revised Testing Procedure
JULY 1986 A/T - Pressure Tap Locations
MAY 1986 A/T - AOD Reverse Drum Changes
FEBRUARY 1986 A/T - AOD New Information/Clutch Return Spring Tension
FEBRUARY 1986 A/T - AOD Rebuild Tips
NOVEMBER 1985 Aluminum Wheel - New Improved Wrench Adapter
|
