 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1987 Ford Truck Aerostar V6-183 3.0L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1987 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1987 Ford Truck Aerostar V6-183 3.0L
OCTOBER 1991 Recall - Rear Liftgate Shock Ball Stud Replacement
JANUARY 1990 Recall - Seat Belt Inspection/Modification
NOVEMBER 1988 Recall - 88S55 Amended Labor Allowances
JULY 1988 Recall - Trailer Tow Package Modification
SEPTEMBER 1987 Recall - Fuel Line Retainer Clip Installation
Technical Service Bulletin Titles for 1987 Ford Truck Aerostar V6-183 3.0L
DECEMBER 1990 Campaign - Windshield Wiper Motor Gear Replacement
NOVEMBER 1989 Campaign - Crankshaft Pulley Replacement
NOVEMBER 1988 Campaign - Sliding Door Mechanism Modification
AUGUST 1988 Campaign - M61 Revised Labor For Brake Modification
JUNE 1988 Campaign - Front Disc Brake Modification
FEBRUARY 1988 Campaign - Heater/Engine Bypass Hose Replacement
Technical Service Bulletin Titles for 1987 Ford Truck Aerostar V6-183 3.0L
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
MARCH 2003 Engine - Oil Pan Gasket Replacement Revision
MAY 2001 Wire Harness - Terminal Repair Kit
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brake Service - Service Tips
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Air Conditioning - R12 to R134A Retrofit Kit
FEBRUARY 1998 Paint - Procedure/Products For Plastic Service Parts
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
AUGUST 1996 Rear Axle - Whine/Howl At Light Throttle
JULY 1996 A/C System - Service TSB List
MAY 1996 Fuel - California Reformulated Gasoline
JANUARY 1996 A/T - A4LD Bellhousing & Pump Interchange
JANUARY 1996 A/T - A4LD Support Ring Identification
JANUARY 1996 A/T - A4LD, 4R44E/4R55E Pump Interchangeability
DECEMBER 1995 Door Lock Cylinder - Loose in Replacement Door
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
AUGUST 1995 Body - Roof Panel and Drip Rail Repairs
AUGUST 1995 Replacement Sliding Door - Service Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
JUNE 1995 Windshield - Material Usage Procedure
MARCH 1995 Paint - Iron Particle Removal
MARCH 1995 Rocker Panel - Front/Rear Rust Perforation
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Front Door Glass - Binds During Downward Travel
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
SEPTEMBER 1994 Sliding Door Weatherstrip - Worn or Damaged
JULY 1994 R-12 Refrigerant - Substitutes
APRIL 1994 Fuel Injector Cleaner - Parts and Service Tips
FEBRUARY 1994 Rear Crankshaft Oil Seal/Dipstick Tube - Leaks Oil
JANUARY 1994 A/T - A4LD Cooler Line Fittings
JANUARY 1994 A/T - Binding Condition In Park
JANUARY 1994 A/T - E40D Second Gear Starts
JANUARY 1994 A/T - Pump Damage After Overhaul
DECEMBER 1993 Heated Backlite - Inoperative
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 EATC or Instrument Display - Dim or Blank
NOVEMBER 1993 EGO Sensors - Silicone Contamination
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Diagnostic Connector - Service Bay Diagnostic System
AUGUST 1993 Air Conditioning - Cooling Tube Does Not Fit
JULY 1993 Bumper - Loose or Unattached Ends
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
JUNE 1993 Speedometer - Service Replacements With Pre-Set Mileage
MAY 1993 Brakes - Sticking/Binding/Grabbing
APRIL 1993 Exterior Clearcoat - Cracking/Eroding/Peeling Off
APRIL 1993 A/T - A4LD 4-3 Gear Flare, No Engagement in O/D
MARCH 1993 A/C Coupling - Cleaning Procedures
DECEMBER 1992 A/T - A4LD No Reverse
OCTOBER 1992 Rear Brakes - Squeal Noise When Cold
AUGUST 1992 A/T - A4LD No 4th Gear
JULY 1992 Fuel Tank - Thud or Clunk Sound
JULY 1992 Rear Seat Headphone Speaker - Control Knob Available
JUNE 1992 A/C Compressor - Noise
JUNE 1992 Starter Motor Brushes - Replacement Revision
JUNE 1992 Nylon Fuel Lines - Servicing Procedure
FEBRUARY 1992 A/T - A4LD Converter Channel Spring Addition
JANUARY 1992 Four Wheel Drive (4 X 4) - General Information
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
SEPTEMBER 1991 Fuel Injector - New Cleaning Method
SEPTEMBER 1991 Brake Hoses - Wet Appearance
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 A/T - A4LD No Movement After Rebuild
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 A/T - A4LD No Reverse After Rebuild
JUNE 1991 Engine - Rear Seal Tool/Sealer Manual Revision
MAY 1991 A/T - Floor Shifter Binding
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
MAY 1991 Engine - Intermittent Knocking Noise At Idle
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Engine - Oil Leaks From Rear Of Engine
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 M/T - Clutch Hub Identification/Torque Revisions
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 A/T - Slips or No 3 or Reverse, 2-3 Flare
FEBRUARY 1991 Climate Control - Improper Operation
DECEMBER 1990 Speed Control - Diagnostic Tips
NOVEMBER 1990 Instrument Cluster - Dim or Blank Display
OCTOBER 1990 A/C System - Not Cooling Satisfactorily
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
AUGUST 1990 Exhaust System - Idle Boom Under Load
AUGUST 1990 Wiper Motor - Gear Service Kit Available
JULY 1990 Rear Suspension - Clapping Noise On Bumps
JUNE 1990 Exhaust System - Idle Boom At 750 RPM Under Load
JUNE 1990 Steering Column Support Brackets - Loose
JUNE 1990 A/T - A4LD Front Seal Blow Out
MAY 1990 Body/Frame - Arc Welding Precautions
MAY 1990 A/T - A4LD Slipping or Soft Shifts After Rebuild
APRIL 1990 Heater - Insufficient Heat To Front Seat Floor Area
MARCH 1990 Seat Belts - Cause Interior Trim Wear
FEBRUARY 1990 Front Door Window Regulator - Binding/Inoperative
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 EEC IV - Revised Pinpoint Test Steps
DECEMBER 1989 Engine - Rough Idling Condition
NOVEMBER 1989 A/C Controls - Sticking/Binding
NOVEMBER 1989 Emission Maintenance Warning Module - Service
OCTOBER 1989 Rear Brakes - Squeal and/or Sticking
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Brakes - Noise Diagosis/Repair TSB Sumary
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 EVP Sensor - Manual Revision
SEPTEMBER 1989 Key On Engine Off Self Test Procedure - Manual Revision
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 Throttle Position Sensor - Application Chart
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 Fuel Injectors - Rotunda Injector Tester/Cleaner
JULY 1989 Speakers - Sound Distortion/Erratic Operation
JULY 1989 A/C - Pressure Cycling Switch Diagnostic Procedure
JULY 1989 TPS Mounting Screws - Hard to Remove
JUNE 1989 Paint - Cosmetic Damage From Airborn Materials
JUNE 1989 Adhesives & Sealants - Availability and Usage
JUNE 1989 Emission Control System - Technician`s Glossary
MAY 1989 A/T - A4LD Premature Clutch Wear
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 Engine - Normal Oil Consumption
MAY 1989 Tires - Best Pressure For Load Application
MAY 1989 A/T - A4LD Delay In Reverse/Occasional No-Reverse
APRIL 1989 Drivetrain - Lubricant Usage
APRIL 1989 Rear Axle - Cover Leaks
MARCH 1989 Engine - Intermittent Miss At Idle or Cruise
MARCH 1989 Front Body Side Window - Uneven
MARCH 1989 Ignition System - Diagnostics Manual Correction
FEBRUARY 1989 Safety Belt - Catches On Fuel Filler Door Release Handle
FEBRUARY 1989 Speed Control - Abnormal Operation When Hot
JANUARY 1989 Speedometer/Odometer - Inaccurate Readings
JANUARY 1989 MAP and BAP Sensor - Application Chart
JANUARY 1989 A/T - A4LD Overdrive Sun Gear Support Inspection
DECEMBER 1988 A/C Suction Accumulator - Manual Revision
DECEMBER 1988 Rear Crankshaft Seal - Oil Leaks
DECEMBER 1988 Safety Belt - Tongue Cover Now Available
OCTOBER 1988 M/T - Hard to Shift Gears In Cold Weather
OCTOBER 1988 A/T - Driveline Clicking Or Popping Noise
SEPTEMBER 1988 Engine - No Start or Hard Start Condition
AUGUST 1988 Engine - Hesitation/Lack Of Power/Rough Idle
AUGUST 1988 A/T - Direct Clutch Failure/Erratic Reverse Engagement1
JULY 1988 EEC IV Emissions Diagnosis - Supplemental Information
JULY 1988 Safety Belts - Service Procedure, Manual Revision
JULY 1988 Engine - Stumble or Stall At Low Speeds
JULY 1988 Vent Windows - May Stick to Weatherstrip
JULY 1988 A/T - A4LD Loose Fitting Valve In Valve Body
JULY 1988 A/T - A4LD Valve Body and Filter Change
JULY 1988 A/T - Sprag Rotation
JUNE 1988 Brake Caliper - Rattling Noise
JUNE 1988 Electronic Modules - Protection From Static Electricity
JUNE 1988 Wheelcovers - Clicking/Squawking Noises
JUNE 1988 Rear Brakes - Drag
APRIL 1988 A/T - A4LD No Upshift/Restricted Modulator
APRIL 1988 Cylinder Head/Block - Coolant Leak At Mating Surface
APRIL 1988 Engine - Oil Dipstick May Not Be Read Correctly
APRIL 1988 Radio Antenna Mounting Screws - Loose
APRIL 1988 Vehicle Storage - Maintenance Tips
MARCH 1988 Driveshaft - Clicking/Popping Noise
MARCH 1988 Manual Vent Windows - Difficult to Open
MARCH 1988 A/T - A4LD Erratic or No 3-4 Upshift
MARCH 1988 Speedometer Display - Parts Return
FEBRUARY 1988 A/T - A4LD Slipping Under Acceleration
DECEMBER 1987 Engine - Intermittent/Constant High Idle Speed
DECEMBER 1987 Doors and Ignition - Lock Service Tips
DECEMBER 1987 Vinyl Tape Stripes - Poor Adhesion
DECEMBER 1987 A/T - A4LD Front Oil Pump-To-Converter Housing Bolts
NOVEMBER 1987 Air Conditioning - Odor Service Procedure
NOVEMBER 1987 Rotunda Gas Chek Kit - Requires Modification
NOVEMBER 1987 Driveline - Clunk/Grunt Noise On Start Up
NOVEMBER 1987 A/T - Clunk/Grunt From Driveline
OCTOBER 1987 A/T - A4LD Front Oil Pump to Converter Housing Bolt
OCTOBER 1987 TFI Module/PIP Sensor - New Diagnostic Procedure
OCTOBER 1987 Engine/Ignition - No Start Condition
OCTOBER 1987 Instrument Cluster Bulbs - Replacement Precaution
SEPTEMBER 1987 Suspension - Vehicle Lean or Spring Sag
SEPTEMBER 1987 A/T, M/T - New `Mercon` Transmission Fluid
SEPTEMBER 1987 Parking/Turn/Side Marker - Moisture Inside Lens
SEPTEMBER 1987 A/T - A4LD No 4th Gear/Overdrive Planetary Carrier
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - A4LD Slipping On Upshifts And Downshifts
AUGUST 1987 Fuel System - Injector Tester/Cleaner Service Tips
AUGUST 1987 Fuel Injectors - Mismarked Stock
AUGUST 1987 A/T - A4LD Slips In 2nd or No 2nd Gear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 A/C Controls - Vacuum Schematic Corrections
JULY 1987 Paint - Difficulty Matching Production Colors
JULY 1987 Wiring - Circuit Number/Color Code Charts
JULY 1987 A/C Controls - Sticking or Binding
JULY 1987 A/T - A4LD Front Seal Blows Out
JULY 1987 Engine - Rough Idling
JULY 1987 Front Disc Brake - Groaning/Grinding Noise
JULY 1987 Instrument Cluster - Diagnosis of Warning Light
JULY 1987 Plastic Bumper - Painting Procedure
JUNE 1987 Fuel Gauge - Manual Revision/Diagnostic Tips
JUNE 1987 Electric Fuel Pump - New Service Procedure
JUNE 1987 Manual Vent Windows - Hard to Open
MAY 1987 Crankshaft Pulley - Noise/Vibration
MAY 1987 Exhaust - Sulfur Smell
MAY 1987 Production Build Date Stamp - Relocation
MAY 1987 Engine - Correct Oil Fill Level Markings
APRIL 1987 Parking Brake - Popping Noise
APRIL 1987 Wiring - Positive Locking Micro-Pin Terminals
MARCH 1987 Engine - Stalling and/or A No Start Condition
MARCH 1987 Fuel System - Filler Pipe Seal Shrinkage
MARCH 1987 Heater - Insufficient Heat to the Front Floor
MARCH 1987 A/T - A4LD Engine RPM Increases On Downshift
MARCH 1987 Engine Idle - Revised Setting Procedure
MARCH 1987 A/T - A4LD Erratic Shifting/Fluid Leakage
MARCH 1987 A/T - Converter Clutch Solenoid Fluid Source I.D.
FEBRUARY 1987 Sliding Windows - Water Leaks
FEBRUARY 1987 Wiring - Electrical System Troubleshooting Tips
FEBRUARY 1987 A/T - A4LD Late 1-2 Upshift After Rebuild
JANUARY 1987 A/T - A4LD Multiple Problem Diagnosis/Repair
JANUARY 1987 Instrument Panel - Squeaks and Rattles
JANUARY 1987 Interior Trim - Recommended Clean Up Tips
JANUARY 1987 Shop Tips to Prevent Repeat Repairs
JANUARY 1987 Engine Piston - Knock/Scuff Condition
JANUARY 1987 Engine Serial Numbers - Location
JANUARY 1987 Roof Panel - Seam Sealer Application
DECEMBER 1986 A/C - Insufficient Cooling During Stop and Go Driving
DECEMBER 1986 Aluminum Oil Pan - Heli-Coil Repair of Drain Plug
DECEMBER 1986 Front Tires - Irregular Wear Pattern
DECEMBER 1986 Radio - Rear Remote Control Inoperative
DECEMBER 1986 Sliding Door - Rattles On Rough Roads
DECEMBER 1986 Sliding Door Center Track - Paint Flaking
DECEMBER 1986 Tail Lamp - Water In Lamp Assembly
NOVEMBER 1986 Bodyside/Liftgate Modular Windows - Water Leaks
NOVEMBER 1986 Engine - No Start/Lamps Inoperative
NOVEMBER 1986 Engine Oil - Recommended Usage
NOVEMBER 1986 Footwell Lamp - Lens Retention
NOVEMBER 1986 Seat Belt - (Right Hand) Inadequate Webbing Length
NOVEMBER 1986 A/T - A4LD Intermittent No Reverse Condition
JULY 1986 A/T - Pressure Tap Locations
JANUARY 1985 A/T - A4LD/C3 Front Pump Support Inspection
JANUARY 1985 A/T - C3 Slipping or No Drive Condition
|
