 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1986 Ford Truck F 250 2WD Pickup V8-6.9L DSL
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1986 Ford Truck.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1986 Ford Truck F 250 2WD Pickup V8-6.9L DSL
MAY 2001 Wire Harness - Terminal Repair Kit
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
DECEMBER 1998 Electrical - New Terminal Grease Released For Service
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - Soft Pedal Feel/Pull/Irregular Wear
MARCH 1998 Front Brake Caliper - Piston Boots Damaged
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
MARCH 1998 Diesel Engine - Hard Start/No Start Condition
FEBRUARY 1997 Frame - Rivet Replacement with Bolts Service Tip
FEBRUARY 1997 Frame - Popping or Creaking Noise
JANUARY 1997 Diesel Engine - Diagnostic Guide
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
NOVEMBER 1996 Ball Joint - Clunk Noise From Front End
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
DECEMBER 1995 Door Lock Cylinder - Loose in Replacement Door
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
MARCH 1995 Paint - Iron Particle Removal
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
SEPTEMBER 1994 Full Floating Rear Axles - Hub Seal Leaks
JULY 1994 R-12 Refrigerant - Substitutes
APRIL 1994 Differential - Oil Leaks At Pinion Nut
APRIL 1994 Frame/Crossmember - Snapping/Popping Noise
MARCH 1994 Engine - Stalls When Coming to A Stop
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
SEPTEMBER 1993 Paint - Peel Repair Procedures Update
MAY 1993 Engine - Rough Idle or Stumble
MARCH 1993 A/C Coupling - Cleaning Procedures
MARCH 1993 Paint to Match Parts - Generic Paint Procedure
MARCH 1993 Steering Gear - Leak At the Input Shaft
FEBRUARY 1993 Exhaust Air Pump Assembly - Obsolete Part Return
AUGUST 1992 Steering - Pulls Left When Braking
JUNE 1992 Starter Motor Brushes - Replacement Revision
MARCH 1992 Speed Control - Intermittent or Inoperative
FEBRUARY 1992 Front Drive Axle - Identification Tags
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
NOVEMBER 1991 A/T - Harsh/Delayed 1st - 2nd and 2nd - 3rd Gear Shifts
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
OCTOBER 1991 Clutch - Excessive Pedal Effort
OCTOBER 1991 Cooling Fan Clutch - Loose/Rattles
SEPTEMBER 1991 Brake Hoses - Wet Appearance
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
SEPTEMBER 1991 A/T - C6 Early Shifts, Stacked Shifts, No Upshifts
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
MAY 1991 Wheel - Mounting Surface Distorted Lug/Pilot Holes
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
MARCH 1991 Rear Axle Hub Seal - Lubricant Leaks
DECEMBER 1990 Speed Control - Diagnostic Tips
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 A/T - Harsh Reverse Engagements
AUGUST 1990 M/T - Clutch Fluid Leaks/Incomplete Release
JULY 1990 Lower Body Stone Protection - Repair Procedure
MAY 1990 Body/Frame - Arc Welding Precautions
MAY 1990 Wheel Cover - Centers Damaged By Stones
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
JANUARY 1990 Injection Pump - Updated Service Procedure
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 Diesel Engine - Redesigned Fuel Return System
DECEMBER 1989 Front Brakes - Premature Lining Wear/Hard Pedal
NOVEMBER 1989 A/T - AOD Separator Plate Gasket Changes
OCTOBER 1989 Steering - Pull or Drift
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Brakes - Noise Diagosis/Repair TSB Sumary
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 Diesel Engine - Idle Surge/Hard/No Start
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 A/C - Pressure Cycling Switch Diagnostic Procedure
JULY 1989 Fuel Tank Sending Unit - Connector Replacement
JUNE 1989 Paint - Cosmetic Damage From Airborn Materials
JUNE 1989 Adhesives & Sealants - Availability and Usage
JUNE 1989 Emission Control System - Technician`s Glossary
JUNE 1989 Valve Stem Oil Shield - Eliminated
MAY 1989 A/T - AOD Case Thread Update
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 Engine - Normal Oil Consumption
MAY 1989 Tires - Best Pressure For Load Application
APRIL 1989 Drivetrain - Lubricant Usage
FEBRUARY 1989 Speed Control - Abnormal Operation When Hot
JANUARY 1989 Speedometer/Odometer - Inaccurate Readings
DECEMBER 1988 Cooling system - Coolant Water/Anti-Freeze Ratio
DECEMBER 1988 Cylinder Head - Coolant Leak
DECEMBER 1988 A/C Suction Accumulator - Manual Revision
DECEMBER 1988 Engine - Expansion Plug Replacement
DECEMBER 1988 Fuel Tank Filler Cap - New Design Available
DECEMBER 1988 Oil Cooler Bundle - Debris Inside
DECEMBER 1988 Safety Belt - Tongue Cover Now Available
AUGUST 1988 Clutch System - Diagnosis/Service Tips
JULY 1988 EEC IV Emissions Diagnosis - Supplemental Information
JULY 1988 Safety Belts - Service Procedure, Manual Revision
JULY 1988 Vent Windows - May Stick to Weatherstrip
JUNE 1988 Brake Caliper - Rattling Noise
JUNE 1988 Suspension - Performance Concerns With Campers
JUNE 1988 Height Sensing Proportioning Valve - Manual Correction
MAY 1988 Crankshaft Rear Oil Seal - Oil Leakage
MAY 1988 Glow Plug Diagnostics - Shop Manual Correction
MAY 1988 Intake Manifold - Oil Seepage
APRIL 1988 Crankcase Vent Tube - Revised Parts and Procedure
APRIL 1988 Full Float Hub Seal - Lubricant Leak
MARCH 1988 A/T - C6 Fluid Leakage Misdiagnosis
MARCH 1988 Cylinder Head Gasket - Improved Design
MARCH 1988 Manual Vent Windows - Difficult to Open
MARCH 1988 Power Door Locks - Are Inoperative
DECEMBER 1987 Brakes - Shudder and Vibration On Application
NOVEMBER 1987 Air Conditioning - Odor Service Procedure
NOVEMBER 1987 Crankshaft Removal and Installation - Revision
NOVEMBER 1987 A/T - AOD New Overdrive Band Anchor Pin
NOVEMBER 1987 Driveline - Clunk/Grunt Noise On Start Up
NOVEMBER 1987 A/T - C6 No. 9 Thrust Washer Failure
OCTOBER 1987 Cab/Pick Up Box - Alignment
OCTOBER 1987 Engine/Ignition - No Start Condition
SEPTEMBER 1987 Suspension - Vehicle Lean or Spring Sag
SEPTEMBER 1987 A/T, M/T - New `Mercon` Transmission Fluid
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 Cylinder Honing - Supplemental Service Procedure
AUGUST 1987 Diesel Engine - New Valve Rocker Arm Assembly
AUGUST 1987 Engine - Valley Pan Gasket Installation Tip
AUGUST 1987 M/T - Gear Clash and Hard Shifting
AUGUST 1987 New Shut-Off Solenoid/Fuel Injection Governor Cover
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 Paint - Difficulty Matching Production Colors
JULY 1987 Wiring - Circuit Number/Color Code Charts
JUNE 1987 Crankshaft Wear Sleeve - Improved Installation Tool
JUNE 1987 Front Drive Axle - Leaks Lubricant From Vent
JUNE 1987 M/T - T-19 Difficulty Starting Up A Grade
JUNE 1987 Body/Frame - Booming Noise
JUNE 1987 Electric Fuel Pump - New Service Procedure
JUNE 1987 Manual Vent Windows - Hard to Open
MAY 1987 Diesel Engine - Supplemental Diagnostic Tips
APRIL 1987 Fuel Gauge - Always Reads Full
APRIL 1987 Tape Player - Ignition Noise Through Speakers
APRIL 1987 Wheels- Lug Nuts Bind On Studs
APRIL 1987 Wiring - Positive Locking Micro-Pin Terminals
MARCH 1987 Cylinder Bore Taper - Revised Specification
MARCH 1987 Engine - Lacks Power At Full Throttle
MARCH 1987 M/T - T19 Leaks Fluid
MARCH 1987 Windshield Wipers - Blades Skip and Leave Unwiped Areas
FEBRUARY 1987 Steering - Pulling or Drifting
FEBRUARY 1987 Wiring - Electrical System Troubleshooting Tips
FEBRUARY 1987 Engine Oil Consumption - Diagnostic Procedure
FEBRUARY 1987 Fuel Line Spring Lock Coupling - Service Procedures
JANUARY 1987 Air Intake System - Water Entry
JANUARY 1987 Engine - Reduced Power or Seizure
JANUARY 1987 Fuel Return Lines - Leakage
JANUARY 1987 Interior Trim - Recommended Clean Up Tips
JANUARY 1987 Wiring - Continuity Testing of Connector Terminals
JANUARY 1987 Pick Up Box - Accessory Installation Guidelines
DECEMBER 1986 Front Tires - Irregular Wear Pattern
DECEMBER 1986 Sheet Metal - Corrosion From Dealer Name Plate
DECEMBER 1986 Stereo Cassette - Ignition Noise/Alternator Whine
DECEMBER 1986 Tire Wear - Toe Set Prior Vehicle Service
NOVEMBER 1986 Tilt Steering Column - Release Lever Feels Loose
NOVEMBER 1986 Brake Booster - Request For Return of Assembly
NOVEMBER 1986 Processor - Request For Return of Assembly
NOVEMBER 1986 Axle - Rear Axle Hub Seals Leak
NOVEMBER 1986 A/T - Slipping Or No Third Gear After Overhaul
OCTOBER 1986 Clutch - Improper Parts Substitution
OCTOBER 1986 Clutch/Dash Panel - High Effort/Cracking
OCTOBER 1986 M/T - T19 Reverse Shifter Pivot Arm Screw - New Tool
SEPTEMBER 1986 Exterior Moldings - Request For Return
SEPTEMBER 1986 Throttle Position Sensor - Request For Return
SEPTEMBER 1986 M/T - Shift Lever Return Request
SEPTEMBER 1986 Rear Locking Differential - Noise On Turns
AUGUST 1986 Fuel Pump/Sender - Erratic Operation Prevention
JULY 1986 Driveline - Vibration/Boom
JULY 1986 Specifications Issue Technical Service Bulletin
JULY 1986 A/T - AOD Main Control Valve Body Gasket
JULY 1986 Front Spring Shackle - Frame Interference
JULY 1986 Radio - Ignition Noise/Alternator Whine On AM Band
JUNE 1986 Fuel Line Coupler - High Installation Effort
JUNE 1986 A/T Vacuum Diaphragm - Return
JUNE 1986 A/T - Synthetic Fluid Availability
JUNE 1986 Alternator - No or Low Output
MAY 1986 Alternator Bracket - Parts Return
MAY 1986 Engine - Oil Change Interval and Soot Levels
MAY 1986 Diesel Dynamic Timing - Timing Meter Calibration
APRIL 1986 Front Disc Brakes - Squealing Noise
APRIL 1986 Engine - Spark Knock/Hesitation/Surge/Stumble
MARCH 1986 Roof Panel - Oilcanning Noise
MARCH 1986 Steering - Vehicle Drifting/Pulling
FEBRUARY 1986 Alternator - Electrical and Vacuum Manual Correction
FEBRUARY 1986 Antitheft Devices - Installation Precautions
FEBRUARY 1986 Crankshaft Seal - Leaks, Air Pressure Test
FEBRUARY 1986 Engine Compartment Wiring - New Connectors
JANUARY 1986 Maintenance - Manual Revision
DECEMBER 1985 Diesel Engine - Extended Idling Oil Dilution
DECEMBER 1985 Engine - Oil Level Checking Procedure
DECEMBER 1985 Door Glass Run Assembly - Drops Out of Channel
NOVEMBER 1985 Fuel System Spring Lock Fitting - Proper Assembly
OCTOBER 1985 Auxiliary Battery Relay - Improved Design
OCTOBER 1985 Front Drive Axle - Retaining Nut Revision
OCTOBER 1985 Height Sensing Proportioning Valve - Service Procedure
OCTOBER 1985 M/T - T18/19 Shift Tower/Shift Gate Revision
SEPTEMBER 1985 Front Drive Axle - Spindle Seal Premature Wear
SEPTEMBER 1985 Steering - Drift/Pull
AUGUST 1985 A/T - AOD Description of Changes
AUGUST 1985 A/T - C5 Description of Changes
JANUARY 1985 A/T - AOD Changes To 1986 Transmissions
|
