 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1986 Ford Mustang V8-302 5.0L HO
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1986 Ford.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1986 Ford Mustang V8-302 5.0L HO
SEPTEMBER 1987 Recall - Fuel Line Retainer Clip Installation
Technical Service Bulletin Titles for 1986 Ford Mustang V8-302 5.0L HO
MAY 1992 Recall - Catalyst Inspection and/or Replacement
DECEMBER 1989 Recall - Emission Control System Modifications
Technical Service Bulletin Titles for 1986 Ford Mustang V8-302 5.0L HO
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
MAY 2001 Wire Harness - Terminal Repair Kit
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
JANUARY 1999 Fuel - Volatility Related Driveability Concerns
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
MAY 1996 Fuel - California Reformulated Gasoline
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
JANUARY 1996 A/T - A4LD Bellhousing & Pump Interchange
JANUARY 1996 A/T - A4LD Support Ring Identification
JANUARY 1996 A/T - A4LD, 4R44E/4R55E Pump Interchangeability
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 Ball Joint - Replacement Procedure Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 A/C Discharge Hose - Obsolete Part return
MAY 1994 Alignment - Camber Adjustment Kit
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
JANUARY 1994 A/T - A4LD Cooler Line Fittings
JANUARY 1994 A/T - AODE Cooler Return Line Filter Installation
JANUARY 1994 A/T - Binding Condition In Park
JANUARY 1994 A/T - E40D Second Gear Starts
JANUARY 1994 A/T - Pump Damage After Overhaul
DECEMBER 1993 Heated Backlite - Inoperative
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 A/T - AOD Diagnostic Information
NOVEMBER 1993 EGO Sensors - Silicone Contamination
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
JUNE 1993 Steering - Clunk/Rattle/Premature Tire Wear
MARCH 1993 A/C Coupling - Cleaning Procedures
DECEMBER 1992 A/T - A4LD No Reverse
AUGUST 1992 Engine - Metal to Metal Noise
AUGUST 1992 A/T - A4LD No 4th Gear
FEBRUARY 1992 A/T - A4LD Converter Channel Spring Addition
FEBRUARY 1992 Timing Belt - Warbling Noise
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
SEPTEMBER 1991 Power Window Regulator - Counterbalance Spring
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 A/T - A4LD No Movement After Rebuild
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 A/T - A4LD No Reverse After Rebuild
JULY 1991 A/T - AOD Direct Clutch Failure/Excessive Case Bore Wear
MAY 1991 Engine - No Start/Hard Start In Freezing Temperatures
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 A/T - AOD 4th Gear Complaints
MARCH 1991 A/T - Slips or No 3 or Reverse, 2-3 Flare
DECEMBER 1990 Speed Control - Diagnostic Tips
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Lug Nuts - Proper Torqueing Procedure
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
AUGUST 1990 Fuel Pump - Buzzing/Humming After Engine Shut Down
JULY 1990 Lower Body Stone Protection - Repair Procedure
JUNE 1990 Wheels - Loss Of Balance Weights
JUNE 1990 A/T - A4LD Front Seal Blow Out
MAY 1990 Body/Frame - Arc Welding Precautions
MAY 1990 A/T - A4LD Slipping or Soft Shifts After Rebuild
MARCH 1990 Air Supply Control Valve - Functional Check
FEBRUARY 1990 Liftgate - Squeaks/Rattles
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 Engine - Rough Idling Condition
NOVEMBER 1989 A/T - AOD Separator Plate Gasket Changes
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Brakes - Noise Diagosis/Repair TSB Sumary
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 EVP Sensor - Manual Revision
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 Aluminum Wheel - Air Leaks
AUGUST 1989 Throttle Position Sensor - Application Chart
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 Fuel Injectors - Rotunda Injector Tester/Cleaner
JULY 1989 A/C - Pressure Cycling Switch Diagnostic Procedure
JULY 1989 Fuel Tank Sending Unit - Connector Replacement
JULY 1989 TPS Mounting Screws - Hard to Remove
JULY 1989 A/T - AOD Governor Pressure Leaks
JUNE 1989 Paint - Cosmetic Damage From Airborn Materials
JUNE 1989 Idle Fuel Mixture - Manual Revision
JUNE 1989 A/T - Rear Planet Failure/Lack Of Lubrication
JUNE 1989 Adhesives & Sealants - Availability and Usage
JUNE 1989 Emission Control System - Technician`s Glossary
MAY 1989 Fuel System - Technician`s Glossary
MAY 1989 A/T - AOD Case Thread Update
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 Engine - Normal Oil Consumption
MAY 1989 A/T - A4LD Delay In Reverse/Occasional No-Reverse
APRIL 1989 A/T - AOD No Manual Low Gear
MARCH 1989 Ignition System - Diagnostics Manual Correction
MARCH 1989 A/T - AOD 3-4 Accumulator Change
FEBRUARY 1989 Speed Control - Abnormal Operation When Hot
JANUARY 1989 Speedometer/Odometer - Inaccurate Readings
JANUARY 1989 MAP and BAP Sensor - Application Chart
JANUARY 1989 A/T - A4LD Overdrive Sun Gear Support Inspection
DECEMBER 1988 A/C Suction Accumulator - Manual Revision
DECEMBER 1988 Safety Belt - Tongue Cover Now Available
SEPTEMBER 1988 A/T - AOD Failure In Rear Of Transmission/No Lubrication
SEPTEMBER 1988 A/T - AOD Kills Engine In Reverse and/or Forward Gears
AUGUST 1988 Engine - Hesitation/Lack Of Power/Rough Idle
AUGUST 1988 Engine - Low Oil Pressure/Oil Sludge Build-Up
AUGUST 1988 A/T - Direct Clutch Failure/Erratic Reverse Engagement1
JULY 1988 EEC IV Emissions Diagnosis - Supplemental Information
JULY 1988 Safety Belts - Service Procedure, Manual Revision
JULY 1988 Vent Windows - May Stick to Weatherstrip
JULY 1988 A/T - A4LD Loose Fitting Valve In Valve Body
JULY 1988 A/T - A4LD Valve Body and Filter Change
JULY 1988 A/T - Sprag Rotation
JUNE 1988 Electronic Modules - Protection From Static Electricity
JUNE 1988 A/T - Harsh 1-2 Upshift or Slide Bump 1-2 Upshift
MAY 1988 A/T - AOD Loss of Governor Pressure Through Valve Body
APRIL 1988 A/T - A4LD No Upshift/Restricted Modulator
APRIL 1988 Engine - Oil Dipstick May Not Be Read Correctly
MARCH 1988 A/T - A4LD Erratic or No 3-4 Upshift
MARCH 1988 A/T - AOD Slip/Bump On Upshift/Downshift
MARCH 1988 Power Door Locks - Are Inoperative
FEBRUARY 1988 Front/Rear Stabilizer Bar Bushings - Squeak/Grunt Noise
FEBRUARY 1988 A/T - A4LD Slipping Under Acceleration
FEBRUARY 1988 A/T - AOD Burned Overdrive Band/End Play after Rebuild
JANUARY 1988 Convertible/T-Top - Water Leaks/Wind Noise
JANUARY 1988 Graphic Display - False or No Warnings
DECEMBER 1987 Engine - Intermittent/Constant High Idle Speed
DECEMBER 1987 A/T - A4LD Front Oil Pump-To-Converter Housing Bolts
NOVEMBER 1987 Air Conditioning - Odor Service Procedure
NOVEMBER 1987 Polycast Wheels - Paint Chipping or Peeling
NOVEMBER 1987 Rotunda Gas Chek Kit - Requires Modification
NOVEMBER 1987 A/T - AOD New Overdrive Band Anchor Pin
OCTOBER 1987 TFI Module/PIP Sensor - New Diagnostic Procedure
OCTOBER 1987 Engine/Ignition - No Start Condition
SEPTEMBER 1987 A/T - Fluid Leak At the Cooler Line Connections
SEPTEMBER 1987 A/T, M/T - New `Mercon` Transmission Fluid
SEPTEMBER 1987 A/T - A4LD No 4th Gear/Overdrive Planetary Carrier
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 Fuel System - Injector Tester/Cleaner Service Tips
AUGUST 1987 A/T - A4LD Slips In 2nd or No 2nd Gear
AUGUST 1987 A/T - AOD No Fourth Gear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 Paint - Difficulty Matching Production Colors
JULY 1987 Wiring - Circuit Number/Color Code Charts
JULY 1987 A/T - A4LD Front Seal Blows Out
JULY 1987 PCV Valve - Recommended Replacement Schedule
JUNE 1987 Electric Fuel Pump - New Service Procedure
JUNE 1987 Engine - Knocking Noise
JUNE 1987 A/T - AOD High Pitched Noise In All Ranges
JUNE 1987 Manual Vent Windows - Hard to Open
MAY 1987 Oil Pan - Revised Shop Manual Removal/Installation
APRIL 1987 A/C - New `Tee` Type Service Adapter Tool
APRIL 1987 EGR Valve - New Service Part
APRIL 1987 Engine - Excessive Oil Consumption
APRIL 1987 Engine - Valve Train Clatter
APRIL 1987 Wiring - Positive Locking Micro-Pin Terminals
APRIL 1987 A/T - AOD Relief Valves For Valve Bodies
MARCH 1987 Engine - Stalling and/or A No Start Condition
MARCH 1987 AM/FM Cassette Radio - Dial Lighting Dim
MARCH 1987 Rear Brakes - Shudder/Vibration
MARCH 1987 A/T - A4LD Erratic Shifting/Fluid Leakage
MARCH 1987 A/T - A4LD Soft 3-4 Shift After Rebuild
MARCH 1987 A/T - Converter Clutch Solenoid Fluid Source I.D.
FEBRUARY 1987 Wiring - Electrical System Troubleshooting Tips
FEBRUARY 1987 Fuel Line Spring Lock Coupling - Service Procedures
FEBRUARY 1987 A/T - A4LD Late 1-2 Upshift After Rebuild
JANUARY 1987 EEC Universal Distributor - Drive Gear Removal Tool
JANUARY 1987 Interior Trim - Recommended Clean Up Tips
JANUARY 1987 Wiring - Continuity Testing of Connector Terminals
JANUARY 1987 Accessory Drive Belt - `V` Ribbed Belt Cracking
JANUARY 1987 A/T - 3-2 Too Sensitive, or No Part Throttle Downshift
JANUARY 1987 A/T - AOD No End Play/Overdrive Band Burned
DECEMBER 1986 Sheet Metal - Corrosion From Dealer Name Plate
DECEMBER 1986 A/T - A4LD Diagnostic Chart
DECEMBER 1986 A/T - AOD Torque Converter Identification
NOVEMBER 1986 Brake Booster - Request For Return of Assembly
NOVEMBER 1986 Processor - Request For Return of Assembly
NOVEMBER 1986 A/C Compressor Clutch Assembly - Service Caution
NOVEMBER 1986 A/T - A4LD Intermittent No Reverse Condition
NOVEMBER 1986 A/T - A4LD No Or Late Upshift after New Modulator
NOVEMBER 1986 A/T - A4LD Proper Overdrive Sprag Assembly Installation
OCTOBER 1986 Adhesive Backed Emblem - Loose/Missing
OCTOBER 1986 Ignition System - Poor Spark Output
OCTOBER 1986 Intake Manifold Bolts - Torque Sequence Correction
OCTOBER 1986 A/T - AOD Rough 1-2 Shift After Overhaul
OCTOBER 1986 A/T - Overdrive in 2nd Gear and Lockout/Binds in 1st
SEPTEMBER 1986 Exterior Moldings - Request For Return
SEPTEMBER 1986 Throttle Position Sensor - Request For Return
SEPTEMBER 1986 M/T - Shift Lever Return Request
SEPTEMBER 1986 A/T - C3/A4LD - Upshift/Downshift Slippage/Leaks
SEPTEMBER 1986 Radio - Ignition Noise/Alternator Whine
SEPTEMBER 1986 Rear Brakes - Squealing Noise
SEPTEMBER 1986 Rear Locking Differential - Noise On Turns
SEPTEMBER 1986 Oil Level Indicator - Intermittent Operation
AUGUST 1986 Fuel Pump/Sender - Erratic Operation Prevention
AUGUST 1986 Seat Back - (Passenger Front) Movement When Braking
AUGUST 1986 T-Roof - Service Procedures
JULY 1986 Specifications Issue Technical Service Bulletin
JULY 1986 A/T - AOD Main Control Valve Body Gasket
JULY 1986 Electronic Clock - Revised Diagnostic Procedure
JULY 1986 Engine - Hesitation/Hard Starting
JULY 1986 Fuel System - Gasoline Testing Kit
JULY 1986 A/T - Pressure Tap Locations
JUNE 1986 Fuel Spring Lock Coupling - Shop Manual Correction
JUNE 1986 A/T Vacuum Diaphragm - Return
JUNE 1986 A/T - Synthetic Fluid Availability
JUNE 1986 Alternator - No or Low Output
JUNE 1986 Engine - Cranks/No Start/Stalls At Idle
JUNE 1986 Tires - Field Service Locations/Representatives
JUNE 1986 Wheel Stud - Removal Procedure
MAY 1986 Alternator Bracket - Parts Return
MAY 1986 Brake Caliper Pin - New Service Part
MAY 1986 Aluminum Wheels - Wear/Corrosion Damage
MAY 1986 Engine Vacuum System - Starting/Driveability Problems
MAY 1986 A/T - AOD Reverse Drum Changes
APRIL 1986 Stabilizer Bar - Squeak/Grunt/Crunch Noise
APRIL 1986 Engine - Black Exhaust Smoke/Rough Idle
MARCH 1986 Front Door Hinge Roller - Breakage
MARCH 1986 Turbocharger - Boost Pressure Specifications
FEBRUARY 1986 Alternator/Regulator - Integral Design Service Procedure
FEBRUARY 1986 Ignition Timing - Spout Connector Locations
FEBRUARY 1986 M/T - Shift Lever Loose/Broken
FEBRUARY 1986 A/C - Missing Suction Side Service Port
FEBRUARY 1986 Antitheft Devices - Installation Precautions
FEBRUARY 1986 Engine Compartment Wiring - New Connectors
FEBRUARY 1986 A/T - AOD New Information/Clutch Return Spring Tension
FEBRUARY 1986 A/T - AOD Rebuild Tips
FEBRUARY 1986 Crankshaft Seal - Leaks, Air Pressure Test
JANUARY 1986 Ignition Coil - Stumbles/Stalls/Noise In Radio
JANUARY 1986 Ignition System - Weak/No Spark
JANUARY 1986 Ignition System Resistance - Manual Revision
JANUARY 1986 Throttle Valve - Control Pressure Specification Revision
DECEMBER 1985 EEC Electrical Connectors - Driveability Concerns
DECEMBER 1985 A/T - AOD Planetary Gear Set Deterioration
NOVEMBER 1985 Engine - Hard Start/No Start/Runs Rough
NOVEMBER 1985 Polycast Wheels - Trim Rings Cannot Be Installed
OCTOBER 1985 Distributor Rotor - Engine Bucking/Surging
OCTOBER 1985 Speedometer Gear - Application Charts
OCTOBER 1985 Paint - Codes and Cross Reference
OCTOBER 1985 Throttle Position Sensor - Diagnostic Tips
SEPTEMBER 1985 Radio/Cassette - Stereo/Mono Switching
AUGUST 1985 A/T - AOD Description of Changes
AUGUST 1985 A/T - C5 Description of Changes
JANUARY 1985 A/T - A4LD/C3 Front Pump Support Inspection
JANUARY 1985 A/T - AOD Burned Or Slipping Direct Clutch
JANUARY 1985 A/T - AOD Changes To 1986 Transmissions
JANUARY 1985 A/T - AOD Identifying Valve Bodies
JANUARY 1985 A/T - C3 Slipping or No Drive Condition
JANUARY 1985 A/T - C5 Changes For 1986
JANUARY 1985 A/T - Shudder or Vibration During Coastdown 4-3 Shift
|
