 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1985 Volvo 240 L4-2.3L SOHC VIN 88 B230F
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1985 Volvo.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1985 Volvo 240 L4-2.3L SOHC VIN 88 B230F
JULY 2006 Air Bag System - System Life Expectancy
DECEMBER 2005 A/T - Engine Coolant Contamination Detection
OCTOBER 2005 A/T, M/T, AWD - Approved Lubricants
JULY 2000 Seat Belt - Extensions
JANUARY 1998 A/C Compressor Pulley & Clutch - Replacing
JANUARY 1997 Tools - Replacing Trailing Arm Bushing
DECEMBER 1996 Body - Template for Modifying Windshield Frame
OCTOBER 1996 Engine Management Systems - Parts, Information
MAY 1996 Electrical - New Cable Terminals as a Replacement Part
NOVEMBER 1995 A/C - Supplement to Service Bulletin 8-87-217
JULY 1995 Paint - Approved Products
JUNE 1995 Windshield - Replacement with PUR Bonded Windshield
MAY 1995 A/C - Cleaning The Heater Unit Drainage Hose
APRIL 1995 A/C System - Retrofit Conversion from R12 to R134a
APRIL 1995 Body - New Repair Equipment and Chemicals
MARCH 1995 Body - Welding Precautions for Electronic Components
FEBRUARY 1995 A/C - Heater Unit Drain Hose Cleaning
FEBRUARY 1995 Body - Rear Floor Panel Available
FEBRUARY 1995 Body - Rear Floor Panel, Crossmember and Side Wells
FEBRUARY 1995 Engine Oil - Recommended
JANUARY 1995 Tools - New Address For Mono Tester Repairs
MAY 1994 Electrical Test - Measuring Voltage Drop Across Grounds
MARCH 1994 Tools - Engine, Oxygen Sensor, Temp Sensor
FEBRUARY 1994 A/C - Cleaning the Heater Unit Drainage Hose
FEBRUARY 1994 Pinion Seal - Revised & Installation
JANUARY 1994 Engine - Cold Start Condition
OCTOBER 1993 Camshaft/Intermediate Shaft - Revised Seal
SEPTEMBER 1993 A/C - New Heater Control Valve Supercedes Earlier Type
SEPTEMBER 1993 Power Antenna - Malfunction
JUNE 1993 Odometer - Information Sticker Used After Replacing
APRIL 1993 Brake Pads - Minimizing Brake Noise
APRIL 1993 Sunroof - Water Leaks
MARCH 1993 Three Way Converter - Replacement of Pressed Bolts
FEBRUARY 1993 Coolant Thermostat - Venting Nipple Location
JANUARY 1993 Oil - Abnormal Consumption
DECEMBER 1992 Sealed Crimping Sleeve - New
DECEMBER 1992 Windshield Wiper Motor - Grounding
NOVEMBER 1992 A/T - ZF 4 HP-22 Slipping/No Reverse/3-4 Shuttle Shift
NOVEMBER 1992 Ignition Cable Harness - Replacement
NOVEMBER 1992 Piston - Clearance In Used Engines
NOVEMBER 1992 Seat Belt - Extender Availability For Front Seats
OCTOBER 1992 Safety Instructions - Fluoroelastomer Seals
OCTOBER 1992 Safety Precaution - Fluoroelastomer (Viton®) Seals
SEPTEMBER 1992 A/T - ZF 4HP 22 Valve Body Identification
AUGUST 1992 Engine - Hard Cold Starting and Performance
MAY 1992 A/T - ZF Orifice Placement
MAY 1992 Carrier Plate Impulse Wheel - Damage
MAY 1992 Engine Oils - Suggested Usage
MAY 1992 Outside Mirror Glass - Replacement
FEBRUARY 1992 M/T - Improved Reverse Shift Quality
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
SEPTEMBER 1991 M/T - Replacing Short Dog Keys With Long Dog Keys
SEPTEMBER 1991 Rear Crankshaft Seal - Revised & Installation
AUGUST 1991 LH Fuel Injection Control Unit - Exchange
AUGUST 1991 M/T - New Driven Plates and Release Bearing
JUNE 1991 A/T - ZF4HP22 Clutch A (Foward) Failure
MAY 1991 Throttle Switch/Mechanism - Adjust, Clean, Center
MARCH 1991 Alignment - Revised Front Camber Specifications
MARCH 1991 Battery - Charging Voltage
MARCH 1991 Gear Lever - Rattle
FEBRUARY 1991 Tools - Measuring Brake Disc and Hub Runout
JANUARY 1991 Drive Shaft - Take-Off Vibration at Low Speed
JANUARY 1991 Fuel Injection Control Unit - Exchange
JANUARY 1991 Rear Axle - Lubricating Oil Recommendations
DECEMBER 1990 ATF Filter - Cleaning Deleted
DECEMBER 1990 Engine Oil - Viscosity Recommendation
OCTOBER 1990 A/T - Engine Vacuum Testing
OCTOBER 1990 A/T - ZF 4HP-22 Pressure Tap Locations
OCTOBER 1990 A/T - ZF4HP22 Pressure Fitting Modification
OCTOBER 1990 Seat Belt - Extender Available
SEPTEMBER 1990 A/C - New Blower Motor Fan Mounting
SEPTEMBER 1990 Paint - New Supplier
JULY 1990 Audio - Diagnostic Check List
JULY 1990 Body - Water Sealing/Holes In the Body From Accessories
JULY 1990 Tools - Charging Station/R-12 Recycling Units Available
JULY 1990 Tools - Special Tool (5407) Must Be Checked
JUNE 1990 Tools - Light Duty R12 Recovery/Recycling Unit Available
MAY 1990 Cooling System - Recycled Antifreeze
MAY 1990 Tools - Volvo Multifunction Tester Updates
MAY 1990 Unleaded Fuel - Usage In Earlier Models
APRIL 1990 First Gear/Needle Bearings - Revised
APRIL 1990 Tools - R12 Recycling Equipment
MARCH 1990 Tools - Replacement Parts or Repairs Made By Motometer
FEBRUARY 1990 A/T - Choosing the Right ATF
FEBRUARY 1990 A/T - Correct Fluid Applications
FEBRUARY 1990 CIS Valve - Check Procedures
FEBRUARY 1990 MTBE - Oxygenated Fuel Description
FEBRUARY 1990 Tools - Bulletin Indexes
JANUARY 1990 A/T - ZF4HP22 Burning A (Foward) Clutch
JANUARY 1990 EVAP Carbon Filter - Revised
JANUARY 1990 Warranty - Allowance For Federal Tax On Freon
OCTOBER 1989 A/T - Math Part II
OCTOBER 1989 A/T - ZF4HP22 Check Ball and Orifice Locations
OCTOBER 1989 A/T - ZF4HP22 Clutch Application Chart
OCTOBER 1989 Tools - Volvo Multifunction Tester
OCTOBER 1989 Warranty - Authorization For Goodwill Spending
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
SEPTEMBER 1989 Cam Gear P/S Racks - Bleeding
SEPTEMBER 1989 Glass - Replacement
SEPTEMBER 1989 P20 Service Literature Update
AUGUST 1989 A/C - New Type of O-Ring
AUGUST 1989 A/T - Math Formulas Part I
AUGUST 1989 Engine - Poor Driveability When Cold
AUGUST 1989 Sunroof - Leaks
APRIL 1989 Engine - Cold Starting Problems
MARCH 1989 A/C - Leakage at Compressor Filler Valve
OCTOBER 1988 Mirror - Popping Noise in Audio System
SEPTEMBER 1988 A/T - ZF 4HP-22 Clutch A (Foward) Failure
SEPTEMBER 1988 Turbo Charger - Diagnostics
JULY 1988 Corrosion - Inspection Procedure
JULY 1988 Ignition System (Chrysler) - New Cable Harness
JUNE 1988 Valve Cover - Oil Leakage
MAY 1988 Backup Lens - Replacement
MAY 1988 Tools - New and Modified
APRIL 1988 Body - New Adhesive
MARCH 1988 Fuel Injectors - Require Regular Maintenance
FEBRUARY 1988 Fuel Filter - Revised With Modified Nut Attachment
OCTOBER 1987 Door - Wind Noise/Door Arch Weatherstrip
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
AUGUST 1987 Steering Gear - Checking Balance/Hydraulic Pump Pressure
JULY 1987 2631 - 07/01/87
JUNE 1987 Corrosion Inspection - Limits Enforcement
MAY 1987 Temperature Compensating Board - Revised
MAY 1987 Valve Cover Gaskets - Asbestos Free Design Installation
MARCH 1987 Clutch Cable - Adjustment Procedure
FEBRUARY 1987 Water Cooled Turbocharger - Installation
DECEMBER 1986 Wheel Bearings - New Type Outer Front Bearing
SEPTEMBER 1986 Engine - Unstable Idling, Undesirable DIP In RPM
SEPTEMBER 1986 Suspension - Noise
AUGUST 1986 Fuel Gauge Sender - Installing Revised Component
AUGUST 1986 Fuel Pump - Noise
AUGUST 1986 Fuel Pump - Noisy
AUGUST 1986 Prepump Wiring Harness - Available With Gasoline Engine
JUNE 1986 Body - Corrosion Inspection
JUNE 1986 Fuel Pump - Noise, Hesitation and Lack of Power
MAY 1986 LH Injector O-Ring - Removal and Installation
APRIL 1986 Tools - Ignition System & Idle Mixture Check
MARCH 1986 Battery & Alternator - Erratic Charging Output
MARCH 1986 LH Injector O-Ring - Replacement
FEBRUARY 1986 Cooling System - High Engine Temperature At High Speed
FEBRUARY 1986 Engine - No Start Diagnosis
FEBRUARY 1986 Fuel Pump Hose - Revised, Resistant to Impurities
JANUARY 1986 Electronic Cruise Control - Fault Tracing
JANUARY 1986 Engine - Cold Start
JANUARY 1986 Tools - Bushing Removal/Installation
DECEMBER 1985 Brake Disc - Change In Warranty Policy
DECEMBER 1985 Plastic Lens Assemblies - Cleaning
NOVEMBER 1985 Engine - Difficult Cold Starting
OCTOBER 1985 Special Tools and Equipment Information
OCTOBER 1985 Tools - Designed for Use On 1985 and 1986 MY Vehicle
OCTOBER 1985 Tools - Headlight Alignment Equipment
OCTOBER 1985 Tools - Multimeter Warranty Repair Procedures
SEPTEMBER 1985 A/C - Unexpectedly Changes from Refrigeration to Heat
SEPTEMBER 1985 Power Steering Pump - Misaligned
SEPTEMBER 1985 Radio - Digital Clock Function
SEPTEMBER 1985 Tools - 30 mm Camshaft Bearing Surface Reamer
SEPTEMBER 1985 Tools - For Vehicles With ZF4HP22 Transmissions
JULY 1985 Camshaft Bearing - Scored/Abnormal Wear
JULY 1985 Cruise Control - Use Thread Lock When Securing Bolts
JULY 1985 Exhaust - Flange Nuts
JULY 1985 Exhaust - Replacement Flange Nuts
JULY 1985 Power Steering Pump - Magnet Prevents Premature Wear
JULY 1985 Power Steering Pump - Noise
JUNE 1985 A/C - Remove Clamp to Prevent Hose Break
JUNE 1985 Tools - Spare Parts Listing
MAY 1985 Ignition - Replacement of Hall Switch
MAY 1985 Tools - CO Adjustment and Function Test
APRIL 1985 Bulb Failure Warning Light Integrity Sensor - Revised
APRIL 1985 Front End - Vibration
APRIL 1985 Ignition System - Fault Tracing
APRIL 1985 Tail Light Sockets - Revised
MARCH 1985 Monotester/Multimeter - Adjusted Pricing
MARCH 1985 Tools - Volvo Monotester
FEBRUARY 1985 Hub Grease Cap - Revised
FEBRUARY 1985 Recall Completion Sticker Utilization
JANUARY 1985 Cam Gear Power Steering Gear - Leaks
JANUARY 1985 Engine - Oil Sample Analysis
JANUARY 1985 Engine Controls - Basic Ignition Setting
JANUARY 1985 Paint Codes - Cross Reference
NOVEMBER 1984 Rear Axle - Change to Correct Oil
OCTOBER 1984 Engine Oil - Recommendations
|
