 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1985 Ford Mustang V8-302 5.0L 4V HO
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1985 Ford.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1985 Ford Mustang V8-302 5.0L 4V HO
SEPTEMBER 1992 Recall - Seat Belt Tongue Sleeve Replacement
Technical Service Bulletin Titles for 1985 Ford Mustang V8-302 5.0L 4V HO
MAY 1991 Recall - Catalytic Converter Replacement
Technical Service Bulletin Titles for 1985 Ford Mustang V8-302 5.0L 4V HO
JANUARY 2007 M/T - Mercon(R) V ATF Usage Information
JULY 2006 A/T - Mercon V ATF Usage
MAY 2001 Wire Harness - Terminal Repair Kit
NOVEMBER 2000 A/T - In Line Fluid Filter Kit
NOVEMBER 1999 Wire Harness - Terminal Repair Kit/Wire Splice Procedure
SEPTEMBER 1999 A/C - Identification of Non Approved Refrigerants
JULY 1999 A/T - Transmission Flush and Fill Tool Available
SEPTEMBER 1998 Seat Leather - Cleaning Procedure Tips
JUNE 1998 A/C - Filtering Refrigerant After Compressor Replacement
APRIL 1998 Engine - New Gasket Sealer
MARCH 1998 Brakes - New Silicone Compound/Grease
MARCH 1998 Lug Nuts - Proper Installation/Torqueing Procedure
JANUARY 1998 A/T - A4LD/4R44E/5R55E New Center Support
OCTOBER 1997 A/T - Torque Converter Slip/DTC 628/P0741 Set
DECEMBER 1996 Torque Converter - Cleaning and Replacement Guidelines
NOVEMBER 1996 A/T Torque Converter - Leak Test Procedure
NOVEMBER 1996 Electrical Diode - Identification and Replacement
OCTOBER 1996 Windshield/Interior Glass - Fog/Film
OCTOBER 1996 Alternator - Discharge
AUGUST 1996 A/C - R12 Refrigerant Substitutes Service Tip
JULY 1996 A/C System - Service TSB List
MAY 1996 Fuel - California Reformulated Gasoline
JANUARY 1996 New Design Tie Rods - Revised Torque Requirements
JANUARY 1996 A/T - A4LD Bellhousing & Pump Interchange
JANUARY 1996 A/T - A4LD Support Ring Identification
JANUARY 1996 A/T - A4LD, 4R44E/4R55E Pump Interchangeability
SEPTEMBER 1995 Air Conditioning - Approved Flushing Procedures
SEPTEMBER 1995 Recycled Engine Coolant - Service Tips
AUGUST 1995 A/T - New Rotunda Fluid Changer Service Tip
JULY 1995 Ball Joint - Replacement Procedure Tip
JULY 1995 Temperature Gauge - Reads Low/Erratic
MARCH 1995 Brakes - Roughness During Application
MARCH 1995 Paint - Iron Particle Removal
JANUARY 1995 Air Conditioning - O Ring Removal Service Tip
DECEMBER 1994 Brake Rotor - Machining Equipment/Warranty Information
NOVEMBER 1994 Paint - Preparation Procedure And MSDS Information
JULY 1994 R-12 Refrigerant - Substitutes
JUNE 1994 A/C Discharge Hose - Obsolete Part return
MAY 1994 Alignment - Camber Adjustment Kit
APRIL 1994 Bumpers - Isolator and Bracket Assembly Replacement
JANUARY 1994 A/T - A4LD Cooler Line Fittings
JANUARY 1994 A/T - AODE Cooler Return Line Filter Installation
JANUARY 1994 A/T - Binding Condition In Park
JANUARY 1994 A/T - E40D Second Gear Starts
JANUARY 1994 A/T - Pump Damage After Overhaul
DECEMBER 1993 Heated Backlite - Inoperative
NOVEMBER 1993 Bumper Cover - Repair Materials Update
NOVEMBER 1993 Cooling System - New System Diagnostics
NOVEMBER 1993 Instrument Cluster Warning Lights - Dimly Lit
NOVEMBER 1993 A/T - AOD Diagnostic Information
NOVEMBER 1993 EGO Sensors - Silicone Contamination
OCTOBER 1993 Air Conditioning - Return of Obsolete Filter Kits
OCTOBER 1993 Glass - Iridescence or Mottling In Tempered Glass
SEPTEMBER 1993 Air Conditioning - Use of Correct Fluorescent Tracer Dye
MARCH 1993 A/C Coupling - Cleaning Procedures
DECEMBER 1992 A/T - A4LD No Reverse
AUGUST 1992 Engine - Metal to Metal Noise
AUGUST 1992 A/T - A4LD No 4th Gear
FEBRUARY 1992 A/T - A4LD Converter Channel Spring Addition
FEBRUARY 1992 Timing Belt - Warbling Noise
JANUARY 1992 A/T - Diagnostic Trouble Codes for 1983-1992
JANUARY 1992 A/T - EEC Trouble Codes
DECEMBER 1991 Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
OCTOBER 1991 A/C - New Refrigerant O-Rings
SEPTEMBER 1991 Power Window Regulator - Counterbalance Spring
SEPTEMBER 1991 Exterior Paint - Comprehensive Repair Procedures
AUGUST 1991 Radio/Two-Way Communications - Whine/Buzz
AUGUST 1991 A/T - A4LD No Movement After Rebuild
JULY 1991 A/C System - Chemical/Refrigerator Type Odor
JULY 1991 A/T - A4LD No Reverse After Rebuild
JULY 1991 A/T - AOD Direct Clutch Failure/Excessive Case Bore Wear
MAY 1991 Battery - No Engine Crank/Low Battery Charge
MAY 1991 Battery - Test Procedure
MAY 1991 A/C - R12 Refrigerant Service Tips
APRIL 1991 Door Latches - Adjustment/Modification Prohibition
APRIL 1991 Engine - Rough Idle/Hesitation/Backfire/Stalling
APRIL 1991 Vehicle - Welding Precautions
MARCH 1991 Electric Rear Window Defroster - Inoperative
MARCH 1991 A/T - AOD 4th Gear Complaints
MARCH 1991 A/T - Slips or No 3 or Reverse, 2-3 Flare
OCTOBER 1990 Brakes - Intermittent Brake Squeal
OCTOBER 1990 A/T - Engine Vacuum Testing
SEPTEMBER 1990 Driveability TSB`s - Summary
SEPTEMBER 1990 Ignition Timing Procedure - Manual Update
AUGUST 1990 Fuel Pump - Buzzing/Humming After Engine Shut Down
JULY 1990 Lower Body Stone Protection - Repair Procedure
JUNE 1990 Wheels - Loss Of Balance Weights
JUNE 1990 A/T - A4LD Front Seal Blow Out
MAY 1990 Body/Frame - Arc Welding Precautions
MAY 1990 A/T - A4LD Slipping or Soft Shifts After Rebuild
FEBRUARY 1990 Liftgate - Squeaks/Rattles
FEBRUARY 1990 Engine Coolant - Recycled Coolant Not Authorized
FEBRUARY 1990 A/T - Choosing the Right ATF
JANUARY 1990 Duraspark II Ignition - Revised Applications
DECEMBER 1989 A/C - Musty Odor Coming From Vents
DECEMBER 1989 Engine - Rough Idling Condition
NOVEMBER 1989 A/T - AOD Separator Plate Gasket Changes
OCTOBER 1989 A/T - Math Part II
SEPTEMBER 1989 Brakes - Noise Diagosis/Repair TSB Sumary
SEPTEMBER 1989 Wire Harness Terminal and Connector - Service Kit
SEPTEMBER 1989 Air Supply Control Valves Revision On Manual
SEPTEMBER 1989 EVP Sensor - Manual Revision
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
AUGUST 1989 Throttle Position Sensor - Application Chart
AUGUST 1989 A/T - Math Formulas Part I
JULY 1989 A/C - Pressure Cycling Switch Diagnostic Procedure
JULY 1989 Fuel Tank Sending Unit - Connector Replacement
JULY 1989 TPS Mounting Screws - Hard to Remove
JULY 1989 A/T - AOD Governor Pressure Leaks
JUNE 1989 Paint - Cosmetic Damage From Airborn Materials
JUNE 1989 A/T - Rear Planet Failure/Lack Of Lubrication
JUNE 1989 Adhesives & Sealants - Availability and Usage
JUNE 1989 Emission Control System - Technician`s Glossary
MAY 1989 Fuel System - Technician`s Glossary
MAY 1989 Electrical/Electronic/Fuel Induction - Glossary
MAY 1989 A/T - A4LD Delay In Reverse/Occasional No-Reverse
APRIL 1989 A/T - AOD No Manual Low Gear
MARCH 1989 Ignition System - Diagnostics Manual Correction
MARCH 1989 A/T - AOD 3-4 Accumulator Change
JANUARY 1989 Speedometer/Odometer - Inaccurate Readings
JANUARY 1989 MAP and BAP Sensor - Application Chart
JANUARY 1989 A/T - A4LD Overdrive Sun Gear Support Inspection
DECEMBER 1988 Safety Belt - Tongue Cover Now Available
SEPTEMBER 1988 A/T - AOD Failure In Rear Of Transmission/No Lubrication
SEPTEMBER 1988 A/T - AOD Kills Engine In Reverse and/or Forward Gears
AUGUST 1988 Engine - Low Oil Pressure/Oil Sludge Build-Up
AUGUST 1988 A/T - Direct Clutch Failure/Erratic Reverse Engagement1
JULY 1988 EEC IV Emissions Diagnosis - Supplemental Information
JULY 1988 Safety Belts - Service Procedure, Manual Revision
JULY 1988 Vent Windows - May Stick to Weatherstrip
JULY 1988 A/T - A4LD Loose Fitting Valve In Valve Body
JULY 1988 A/T - A4LD Valve Body and Filter Change
JULY 1988 A/T - Sprag Rotation
JUNE 1988 Electronic Modules - Protection From Static Electricity
JUNE 1988 A/T - Harsh 1-2 Upshift or Slide Bump 1-2 Upshift
MAY 1988 A/T - AOD Loss of Governor Pressure Through Valve Body
APRIL 1988 A/T - A4LD No Upshift/Restricted Modulator
APRIL 1988 Engine - Oil Dipstick May Not Be Read Correctly
MARCH 1988 A/T - A4LD Erratic or No 3-4 Upshift
MARCH 1988 A/T - AOD Slip/Bump On Upshift/Downshift
MARCH 1988 Power Door Locks - Are Inoperative
FEBRUARY 1988 Front/Rear Stabilizer Bar Bushings - Squeak/Grunt Noise
FEBRUARY 1988 A/T - A4LD Slipping Under Acceleration
FEBRUARY 1988 A/T - AOD Burned Overdrive Band/End Play after Rebuild
JANUARY 1988 Convertible/T-Top - Water Leaks/Wind Noise
JANUARY 1988 Graphic Display - False or No Warnings
DECEMBER 1987 A/T - A4LD Front Oil Pump-To-Converter Housing Bolts
NOVEMBER 1987 Air Conditioning - Odor Service Procedure
NOVEMBER 1987 Polycast Wheels - Paint Chipping or Peeling
NOVEMBER 1987 Rotunda Gas Chek Kit - Requires Modification
NOVEMBER 1987 A/T - AOD New Overdrive Band Anchor Pin
OCTOBER 1987 TFI Module/PIP Sensor - New Diagnostic Procedure
OCTOBER 1987 Engine/Ignition - No Start Condition
SEPTEMBER 1987 A/T - Fluid Leak At the Cooler Line Connections
SEPTEMBER 1987 A/T, M/T - New `Mercon` Transmission Fluid
SEPTEMBER 1987 EEC IV Pinpoint Test - Shop Manual Correction
SEPTEMBER 1987 A/T - A4LD No 4th Gear/Overdrive Planetary Carrier
SEPTEMBER 1987 A/T - Front Bushing Wear
AUGUST 1987 Fuel System - Injector Tester/Cleaner Service Tips
AUGUST 1987 A/T - A4LD Slips In 2nd or No 2nd Gear
AUGUST 1987 A/T - AOD No Fourth Gear
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 Wiring - Circuit Number/Color Code Charts
JULY 1987 A/T - A4LD Front Seal Blows Out
JULY 1987 PCV Valve - Recommended Replacement Schedule
JUNE 1987 Electric Fuel Pump - New Service Procedure
JUNE 1987 Engine - Knocking Noise
JUNE 1987 A/T - AOD High Pitched Noise In All Ranges
JUNE 1987 Manual Vent Windows - Hard to Open
APRIL 1987 A/C - New `Tee` Type Service Adapter Tool
APRIL 1987 EGR Valve - New Service Part
APRIL 1987 Tires - Michelin TRX Availability
APRIL 1987 A/T - AOD Relief Valves For Valve Bodies
MARCH 1987 Engine - Stalling and/or A No Start Condition
MARCH 1987 AM/FM Cassette Radio - Dial Lighting Dim
MARCH 1987 Rear Brakes - Shudder/Vibration
MARCH 1987 A/T - A4LD Erratic Shifting/Fluid Leakage
MARCH 1987 A/T - A4LD Soft 3-4 Shift After Rebuild
MARCH 1987 A/T - Converter Clutch Solenoid Fluid Source I.D.
FEBRUARY 1987 Wiring - Electrical System Troubleshooting Tips
FEBRUARY 1987 A/T - A4LD Late 1-2 Upshift After Rebuild
JANUARY 1987 EEC Universal Distributor - Drive Gear Removal Tool
JANUARY 1987 Wiring - Continuity Testing of Connector Terminals
JANUARY 1987 Accessory Drive Belt - `V` Ribbed Belt Cracking
JANUARY 1987 A/T - 3-2 Too Sensitive, or No Part Throttle Downshift
JANUARY 1987 A/T - AOD No End Play/Overdrive Band Burned
DECEMBER 1986 A/T - A4LD Diagnostic Chart
DECEMBER 1986 A/T - AOD Torque Converter Identification
NOVEMBER 1986 A/T - A4LD Intermittent No Reverse Condition
NOVEMBER 1986 A/T - A4LD No Or Late Upshift after New Modulator
NOVEMBER 1986 A/T - A4LD Proper Overdrive Sprag Assembly Installation
OCTOBER 1986 A/T - AOD Rough 1-2 Shift After Overhaul
OCTOBER 1986 A/T - Overdrive in 2nd Gear and Lockout/Binds in 1st
SEPTEMBER 1986 A/T - C3/A4LD - Upshift/Downshift Slippage/Leaks
SEPTEMBER 1986 Radio - Ignition Noise/Alternator Whine
SEPTEMBER 1986 Rear Brakes - Squealing Noise
SEPTEMBER 1986 Oil Level Indicator - Intermittent Operation
AUGUST 1986 Electric Fuel Pump - Ground Wire Location
AUGUST 1986 Engine - Poor Fuel Economy/Poor Heater Performance
AUGUST 1986 Fuel Pump/Sender - Erratic Operation Prevention
AUGUST 1986 Seat Back - (Passenger Front) Movement When Braking
AUGUST 1986 T-Roof - Service Procedures
JULY 1986 A/T - AOD Main Control Valve Body Gasket
JULY 1986 A/T - Pressure Tap Locations
JUNE 1986 A/T - Synthetic Fluid Availability
JUNE 1986 Alternator - No or Low Output
JUNE 1986 Engine - Cranks/No Start/Stalls At Idle
JUNE 1986 Tires - Field Service Locations/Representatives
JUNE 1986 Wheel Stud - Removal Procedure
MAY 1986 Brake Caliper Pin - New Service Part
MAY 1986 Manifold Heat Control Valve - Rattles
MAY 1986 Aluminum Wheels - Wear/Corrosion Damage
MAY 1986 Engine Vacuum System - Starting/Driveability Problems
MAY 1986 Power Steering Pump -Fluid Leaks At Dipstick Cap
MAY 1986 A/T - AOD Reverse Drum Changes
APRIL 1986 Stabilizer Bar - Squeak/Grunt/Crunch Noise
MARCH 1986 Turbocharger - Boost Pressure Specifications
FEBRUARY 1986 A/C Evaporator - Cold Air Leaks/Cold Air Radiation
FEBRUARY 1986 Front Suspension - Noise/Rattle
FEBRUARY 1986 Ignition Timing - Spout Connector Locations
FEBRUARY 1986 M/T - Shift Lever Loose/Broken
FEBRUARY 1986 Antitheft Devices - Installation Precautions
FEBRUARY 1986 Engine - Hesitation/Stumbles
FEBRUARY 1986 Rear Axle Wheel Bearing Noise - Diagnostic Tips
FEBRUARY 1986 A/T - AOD New Information/Clutch Return Spring Tension
FEBRUARY 1986 A/T - AOD Rebuild Tips
FEBRUARY 1986 Crankshaft Seal - Leaks, Air Pressure Test
JANUARY 1986 Engine - Stalls On Deceleration Or At Idle
JANUARY 1986 Ignition Coil - Stumbles/Stalls/Noise In Radio
JANUARY 1986 Ignition System - Weak/No Spark
JANUARY 1986 Ignition System Resistance - Manual Revision
JANUARY 1986 Throttle Valve - Control Pressure Specification Revision
DECEMBER 1985 EEC Electrical Connectors - Driveability Concerns
DECEMBER 1985 A/T - AOD Fluid Leak
DECEMBER 1985 A/T - AOD Planetary Gear Set Deterioration
NOVEMBER 1985 Aluminum Wheel - New Improved Wrench Adapter
NOVEMBER 1985 Engine - Hard Start/No Start/Runs Rough
NOVEMBER 1985 Hubcap - Loose/Missing
NOVEMBER 1985 Polycast Wheels - Center Cap Loose/Falls Off
NOVEMBER 1985 Polycast Wheels - Trim Rings Cannot Be Installed
OCTOBER 1985 EEC IV - Self Test Service Code 42 Diagnostic Tip
OCTOBER 1985 Heater - Floor Duct Air Distribution Imbalance
OCTOBER 1985 Throttle Position Sensor - Diagnostic Tips
SEPTEMBER 1985 Radio/Cassette - Stereo/Mono Switching
SEPTEMBER 1985 Windshield - Chattering Noise
AUGUST 1985 Engine Compartment Wiring - Connector Service
AUGUST 1985 Air Cleaner - Abrasion From Hood Insulator Pad
AUGUST 1985 M/T - Gear Rattle Noise 3rd and 4th Gear
JULY 1985 EEC IV Power Relay - Shop Manual Revisions/Updates
JULY 1985 A/T - AOD Orifice Control Valve Plug Retainer
JULY 1985 Paint - Peeling From The Body Side Protection
JULY 1985 TP Sensor - Poor Engine Performance/Mileage
JULY 1985 Distributor - Engine Miss/Low Power
JULY 1985 EGR Solenoids - Contamination
JULY 1985 Ignition Coil - Possible Damage From Antitheft Devices
JULY 1985 PCM - Incorrect Part Number Identification
JUNE 1985 A/C - Orifice Tube Replacement Service Kit
JUNE 1985 Door Locks - Inoperative Due to Rustproofing
JUNE 1985 EEC IV - Invalid/Erratic Service Codes
JUNE 1985 EEC IV MAP Sensor - New Part Numbers/Applications
JUNE 1985 Electric Cooling Fan - Usage Chart
JUNE 1985 A/T - AOD Service Tip/Manual Update
JUNE 1985 Door Hinge - Squeaks During Opening/Closing
JUNE 1985 Fuel Pump - Noise
JUNE 1985 Paint - Revised Prices
JUNE 1985 TFI/MAP Connectors - No Start Condition
JUNE 1985 Wiring - Diagram Symbol Explanantion
MAY 1985 A/T - AOD No Forward Drive Condition
MAY 1985 Tailgate - Hinge/Latch Release Adjustment Revision
MAY 1985 Front/Rear Suspension - Spring Usage
MAY 1985 Brakes - Rotor Service Update
MAY 1985 Radio - Revised Removal & Replacement Procedure
MAY 1985 Spark Plug/Coil Wire - Resistance, Manual Correction
APRIL 1985 Heater Core - Leakage Diagnostic Tips
APRIL 1985 Ignition System - Octane Rod Replacement Deletion
APRIL 1985 Radio - Improper Stereo Light Operation
APRIL 1985 Spark Plugs - Shorting/Altered Scope Pattern
APRIL 1985 Engine - No Start Condition
APRIL 1985 Engine - No Start/Idles Rough/Knock When Cold
APRIL 1985 Starter - Remains Energized With Engine Running
MARCH 1985 A/C - Spring Lock Coupling Service
MARCH 1985 A/T, M/T - Fluid Usage Chart
MARCH 1985 Fuel Filter - Replacement Information
MARCH 1985 Low Oil Level Indicator Lamp - Comes On or Flickers
MARCH 1985 EVP Sensors - Non Interchangeable
MARCH 1985 Engine Control - Self Test Revision
MARCH 1985 M/T - T5 Gear Clash on Rapid Shifts When Cold
MARCH 1985 Oil Leak - Rotunda Black Light Diagnostic Procedures
FEBRUARY 1985 A/T - AOD Main Control Revisions
FEBRUARY 1985 Battery - Premature Discharging Diagnostics
FEBRUARY 1985 Distributor Stator - Replacement Procedure
FEBRUARY 1985 Door/Vent Windows - Excessive Efforts to Open
FEBRUARY 1985 Emission Diagnosis - Manual Revisions
FEBRUARY 1985 Front End - Clunk/Pop Noise On Turns
FEBRUARY 1985 Speed Control - Diagnostic Procedure Revision
FEBRUARY 1985 Wiring - Circuit Color Code Elimination
FEBRUARY 1985 Accessory Drive Belt - Squealing Noise
FEBRUARY 1985 Power Steering Pump - Leakage At Dipstick Cap
FEBRUARY 1985 Window Regulator Handle - Improved Attachment
JANUARY 1985 Seat/Shoulder Belts - General Service Information
JANUARY 1985 Chassis Components - Cosmetic Surface Rust
JANUARY 1985 Fuel System - Liquid/Vapor Leak Detection
JANUARY 1985 Speed Control - New Rotunda Tester Information
JANUARY 1985 Steering Rack - New Service Procedure
JANUARY 1985 A/T - A4LD Slipping or Shudder In Reverse
JANUARY 1985 A/T - A4LD/C3 Front Pump Support Inspection
JANUARY 1985 A/T - AOD Burned Or Slipping Direct Clutch
JANUARY 1985 A/T - AOD Identifying Valve Bodies
JANUARY 1985 A/T - APOD No Forward after Coast Down From 4th Gear
JANUARY 1985 A/T - C3 Slipping or No Drive Condition
JANUARY 1985 A/T - Shudder or Vibration During Coastdown 4-3 Shift
JANUARY 1985 M/T - 6 Spd Gear Rattle Noise
DECEMBER 1984 Fuel System - Pressure Test Gauge Tool Update
DECEMBER 1984 Steering Gear Mount - New Design
DECEMBER 1984 Intake Heat Control Valve - Ticking Noise
NOVEMBER 1984 Manual Revision - Door, Hinge and Weatherstrip Removal
NOVEMBER 1984 Radio - Popping Noise When Turned ON
OCTOBER 1984 Rear Axle - New Axle Service Identification Tag
OCTOBER 1984 A/T - AOD Revision to Shop Manual
SEPTEMBER 1984 A/T - AOD Production Changes
AUGUST 1984 Fleet Colors - Revised Paint Code Numbers
FEBRUARY 1984 EEC Harness - Engine Stalls/Stumble
|
