 |
TSB (Technical Service Bulletins) and Factory Recall
+ Information that addresses safety, reliability, performance and comfort related problems with your car.
+ Special warranty provisions and extensions.
+ Fixes for common problems and updated factory repair procedures.
+ Illustrated Diagnosis and Repair Procedures.
View DEMO sample data
+ OEM Part Numbers;
+ Diagnostic Charts and Trouble Codes;
+ Component Locations and Diagrams;
+ Factory Maintenance Schedules;
+ And much more!
*** Get Full Technical Service Bulletins (TSBs) & More ***
|
 |
Automotive Recalls and Technical Service
Bulletins (TSB) for
1982 Chevrolet Monte Carlo V8-305 5.0L
This is Technical Service Bulletin and
Automotive Recall Titles.
The leading source for online automotive repair
information is a single vehicle access of this same information
including all the diagrams, repair information, and detailed technical service
bulletins/recalls for your 1982 Chevrolet.
[ Select a
different make | Select a different model |
Select a different year
]
Technical Service Bulletin Titles for 1982 Chevrolet Monte Carlo V8-305 5.0L
JULY 1987 Recall - Canister Purge TVS Replacement
JUNE 1983 Recall - Catalytic Converter Replacement
Technical Service Bulletin Titles for 1982 Chevrolet Monte Carlo V8-305 5.0L
APRIL 2007 Tires - Proper Inflation Pressure Information
APRIL 2007 Body - Polypropylene Energy Absorber Replacement
APRIL 2007 Engine - Sealant Usage/procedures
APRIL 2007 A/T - Dexron®-VI(R) Fluid Availability
MARCH 2007 Instruments - Reduced PRNDL Display Visibility
FEBRUARY 2007 Wheels/Tires - `Upsized` Wheel & Tire Information
FEBRUARY 2007 Engine, A/T - Shift/Driveability Concerns/MIL ON
JANUARY 2007 Locks - Key Code Securtiy Rules & Information
JANUARY 2007 Body - Hem Flange Repair
JANUARY 2007 Tires - Radial Force Variation (RFV) Information
JANUARY 2007 A/T - Grinding/Growling In PARK On An Incline
DECEMBER 2006 Restraints - Availability of Seat Belt Extenders
NOVEMBER 2006 Warranty - Claims Submission
NOVEMBER 2006 Engine - Unnecessary Flushing Services
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline
NOVEMBER 2006 Fuel System - TOP TIER Detergent Gasoline Usage
NOVEMBER 2006 M/T - Hydraulic Clutch Bleeding Procedure Improvement
OCTOBER 2006 Body - Metal Panel Adhesive Bonding Information
OCTOBER 2006 Interior - Eliminating Unwanted Odors
OCTOBER 2006 Tires - Tread Puncture Repair Procedures
SEPTEMBER 2006 Wheel Alignment - Recommendations/Requirements
SEPTEMBER 2006 Wheels - Pitting/Brake Dust On Chrome Wheels
SEPTEMBER 2006 Fuel System - GM Fuel System Treatment Plus(R)
SEPTEMBER 2006 Body - Distortion On Outer Glass Surfaces
SEPTEMBER 2006 Wheels - Changing Procedures/Precautions
AUGUST 2006 M/T - Normal Operating Characteristics
AUGUST 2006 Tires - Original Equipment Tire Characteristics
AUGUST 2006 Cooling System - Coolant Recycling Information
AUGUST 2006 Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
JULY 2006 Fuel System - E85 Fuel Usage Information
JUNE 2006 Windshield Wipers - Performance/Cleaning and Maintenance
JUNE 2006 Wheels - Aluminum Wheel Refinishing Recommendations
JUNE 2006 A/T - Dexron®(R) VI Fluid Availability
JUNE 2006 A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
MAY 2006 Electrical - Instrument Panel & General Wiring Repair
APRIL 2006 Audio System - Portable Audio Equipment Noise
APRIL 2006 Wheels/Tires - Slow Leaks From Aluminum Wheels
MARCH 2006 Body - Urethane Adhesives for Glass Applications
MARCH 2006 Tires/Wheels - Wheel Weight Usage Precautions
FEBRUARY 2006 A/T - Fluid Cooler Flushing
JANUARY 2006 Engine - Surface Conditioning Disc Usage Prohibition
JANUARY 2006 Fuel System - Fuel Injector Maintenance Cleaning
DECEMBER 2005 Tires/Wheels - Nitrogen Gas Usage for Filling Tires
OCTOBER 2001 A/T - Core Return Product Feedback Form
NOVEMBER 2000 Suspension - Chassis Lubrication Importance
JUNE 2000 ACDelco(R) Remanufactured Transmissions - Program Update
APRIL 2000 Warranty - GM Dealer Parts Procurement
JANUARY 2000 Child Restraint - Auxiliary Seat Belt
JANUARY 2000 Lap/Shoulder Belts - Dealer Installed Rear Kits
NOVEMBER 1999 IP Dimmer Control - Proper Setting
OCTOBER 1999 Cooling - Radiator Repair/Replacement Guidelines
SEPTEMBER 1999 Engine - AC Delco Remanufactured Engines
JUNE 1999 Warranty - OE Chrome Plated Aluminum Wheel ID
APRIL 1999 Instrument Panel - Upper Surface Reflection
MARCH 1999 Battery - Insulator Replacement & Caution
MARCH 1999 SIR - Operating Vehicle with Warning Light On
DECEMBER 1998 Warranty - Notice of Delayed Start Process
OCTOBER 1998 Drivetrain - Recommended Axle Lubricant
AUGUST 1998 Warranty - Parts Warranty Special Claims B and C
MAY 1998 Warranty - Request for Wholesale Authorization
APRIL 1998 Engine - Surface Conditioning Discs Precautions
MARCH 1998 VIN Plate - Replacement Policy and Procedure
FEBRUARY 1998 Warranty - GM Dealer Empowerment Program
FEBRUARY 1998 Warranty - New Vehicle/Replacement Battery
JANUARY 1998 Brakes - Rotor & Hub Flange Cleaning Tool Revision
JANUARY 1998 Suspension - Shock Absorber/Strut Replacement Guidlines
JANUARY 1998 Warranty - Enhanced Sublet Repair Policy
JANUARY 1998 Warranty - Repair/Replace Policies & Procedures
DECEMBER 1997 Engines - ACDelco Remanufactured
DECEMBER 1997 Parts Expediting - Reimbursement Policy
DECEMBER 1997 Warranty - Rail Dust Removal & Chemical Spotting Labor
NOVEMBER 1997 A/C - PureGuard 2 Operating Alert
NOVEMBER 1997 Labor - Revised Operation Z1241/Personal Property Damage
AUGUST 1997 A/T & M/T - AC Delco Remanufactured Transmissions
MAY 1997 Windshield - Two-Part Urethane Adhesive For Installation
APRIL 1997 A/C - Tool And Equipment Maintenance
APRIL 1997 Warranty - Required Claim Submission Procedures
FEBRUARY 1997 A/C - Systems With R12 Or R134a Service Issue
FEBRUARY 1997 Body - Sealer Tape For Collision Repairs
JANUARY 1997 Compact Disc Players - CD Changer Loading Procedures
JANUARY 1997 Warranty - Repair and Claims Procedures
DECEMBER 1996 Warranty - Claim Processing
NOVEMBER 1996 A/C Compressor Seal Washer - Reference Chart
NOVEMBER 1996 Key Code - Information
SEPTEMBER 1996 Odometer/Speedometer - ACDelco Service Center Locations
SEPTEMBER 1996 Warranty - Corporate Parts Return Program Instructions
JUNE 1996 Warranty - Goodwrench® Service Lifetime Service Guarantee
MAY 1996 Enhanced Emission Inspection Maintenance - Equipment
JANUARY 1996 Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
DECEMBER 1995 Enhanced Emission I/M - Program Update
JULY 1995 Vehicle - AC Delco Locator Service, Electronics Exchange
JUNE 1995 Fuel - Reformulated/Oxygenated Gasolines
JUNE 1995 Vehicle - Use of a Diagnostic Worksheet
MAY 1995 Contaminated R12 Refrigerant - Testing & Handling
APRIL 1995 Coolant - Information on Propylene Glycol Usage
MARCH 1995 A/T - Dexron® III Fluid Introduction
MARCH 1995 Tools - A/C Leak Detector Maintenance Kit Availability
FEBRUARY 1995 I/M Emissions Diagnostic Manual -Program
FEBRUARY 1995 Warranty - Diagnostic Claim Processing Revisions
JANUARY 1995 I/M 240 Program - Equipment Purchase
DECEMBER 1994 Brakes, Front - Pulsation Diagnosis, Correction, Repair
DECEMBER 1994 Enhanced IM240 Program - Implementation Plan
NOVEMBER 1994 Glass - Adhesive Caulking Kit Revisions
OCTOBER 1994 I/M 240 Repairs - Obtaining Technical Assistance
OCTOBER 1994 PROM/MEMCAL - Identification Marks
SEPTEMBER 1994 A/C Refrigerant - Contamination
SEPTEMBER 1994 Campaign - Product Bulletin Numbering System
AUGUST 1994 Parts - Expediting Procedures
JULY 1994 Electrical - New Nickel Tape Shields Harnesses
JULY 1994 Tires - Speed Rated Information
JULY 1994 Warranty - Corporate Parts Return Program
APRIL 1994 Emission - Enhanced Inspection Maintenance Programs
MARCH 1994 P/S - Reduced Assist When Cold
FEBRUARY 1994 Anti-Lock Brake - Aftermarket Products Usage Precaution
FEBRUARY 1994 Warranty - Recycled Engine Coolant Policy
JANUARY 1994 A/C - Retrofitting R-12 Vehicles to R-134A
DECEMBER 1993 Steering - System Bleed Procedures
OCTOBER 1993 Fuel - How Fuel Economy Is Determined
JULY 1993 A/T - 200/200C/200R4, 325/3254L, 700-R4 No 2nd Gear
JULY 1993 A/T - THM Late or No Upshifts
JULY 1993 Audio - Radio Frequency Interference (RFI) Diagnosis/ID
JULY 1993 Wheels - Sealing Leaking Cast Aluminum
JUNE 1993 A/T - THM 350/350C Rattling Noise
JUNE 1993 Tools - Introduction Of The Fuel Injector Tester
MAY 1993 Isolation Diodes - Replacement Information
MARCH 1993 Door Locks - Binding or Sticking or Key Hard to Insert
FEBRUARY 1993 Fuel System - Factors That Affect Economy/Mileage
OCTOBER 1992 Engine - Miss, Hesitation, or Roughness
OCTOBER 1992 Fuels - Effect of Volatility on Driveability
AUGUST 1992 A/C - Use of Alternate Refrigerants In CFC 12
FEBRUARY 1992 A/T - THM 350C Bind-Up On 2-3 Shift
NOVEMBER 1991 A/T - How To Use A Pressure Gauge
AUGUST 1991 A/T - Evaluating Peened Spacer Plates
AUGUST 1991 ECM/PCM - Damaged and/or Misdiagnosed
JUNE 1991 State Emissions Testing Information
MAY 1991 Paint - High Volume Low Pressure Paint Application
APRIL 1991 A/C - Refrigerant Loss Prevention
APRIL 1991 A/T - Diagnosing Converter Lock-Up Problems
APRIL 1991 Instrument Panel - Upper Surface Cleaning
MARCH 1991 Cooling System - Use of Recycled Engine Coolant
FEBRUARY 1991 Battery - Parasitic Draw Test
FEBRUARY 1991 Power Steering - Reduced Assist At Low Temperatures
DECEMBER 1990 Brakes - Change In Brake Feel After Rotor Refinishing
NOVEMBER 1990 Wiper Blades - Chattering on Windshield
OCTOBER 1990 A/T - Engine Vacuum Testing
OCTOBER 1990 Electrical Connectors - Service Procedure
SEPTEMBER 1990 A/T - Torque Converter Identification
JULY 1990 A/T - 200, 325, 2004R, 3254L GM Servos
JULY 1990 Brakes - Poor Rotor Finish/Hard Pedal Feel
APRIL 1990 Aftermarket Accessories - Installation Guidelines
APRIL 1990 Battery - Parasitic Current Drain Diagnosis
APRIL 1990 Coolant - Used Anti-Freeze Policy
APRIL 1990 Oil Filters (Small 75 mm) - Leakage Prevention
MARCH 1990 MAP - Revised Check Chart for DTC`s 33, 34, 63, 64
FEBRUARY 1990 A/T - Choosing the Right ATF
FEBRUARY 1990 A/T Rear Case Bushing - Removal & Installation Procedure
OCTOBER 1989 A/T - Math Part II
OCTOBER 1989 Fuel - Use of Gasoline Containing 15 Percent MTBE
SEPTEMBER 1989 A/C - CFC Reduction & Refrigerant Recovery Recycling
SEPTEMBER 1989 A/T - New Spacer Plate Identification Tab
SEPTEMBER 1989 A/T - Twenty Steps To Successful Repairs
SEPTEMBER 1989 Brakes - Light Brake Drag While Driving
SEPTEMBER 1989 ECM - Packard 32 Way Connector Identification
AUGUST 1989 A/T - Math Formulas Part I
AUGUST 1989 Cooling System - Reconstituted Anti-Freeze Information
JUNE 1989 A/T - THM 200/200C No Passing Gear Above 35 MPH
MAY 1989 Electrical - Wiring Repair Temp Range Precaution
APRIL 1989 A/C - R12 Loss From Loose or Missing Access Fitting Caps
MARCH 1989 A/T - Delayed Park/Neutral to Drive Engagement
MARCH 1989 Audio - Poor AM or FM Radio Reception
FEBRUARY 1989 Brakes - On-Car Rotor Turning Tool
JANUARY 1989 Wheels - Air Leak, Cast Aluminim Wheel Porosity
NOVEMBER 1988 A/T - THM 200C Ball Capsule Versus Cup Plug in TC
NOVEMBER 1988 Battery - Diagnosis and Charging
OCTOBER 1988 M/T - Neutral/Drive Gear Rattle
SEPTEMBER 1988 Alignment - The Importance of Four Wheel Alignment
SEPTEMBER 1988 Seat - Rear Lap/Shoulder Belt Kits
AUGUST 1988 Brakes - Pulsations and Rotor Surface Refinish
JULY 1988 A/T - Sprag Rotation
JULY 1988 A/T - THM Steel Clutch Piston Inspection
JULY 1988 Engine Controls - Electrostatic Discharge Damage
JUNE 1988 Cooling System - Leaks
JUNE 1988 Dash Board - Cleaning of Upper Panel Surfaces
JUNE 1988 Engine - Rough/Unstable/Incorrect Idle
JUNE 1988 Wheels - Installation of After Market Styled Wheels
MAY 1988 A/T - Sporadic Engagement of Torque Converter Clutch
APRIL 1988 Vehicle - Warm Temperature Driveability Summary
MARCH 1988 A/T - No Upshift/Governor Contamination
FEBRUARY 1988 A/T - Checking Pressure Switches For Leaks
OCTOBER 1987 A/T - THM 200 & 2004R New Transmission Oil Pan Gasket
OCTOBER 1987 A/T - THM 200-R4 1ST and 2ND Gear Noise
OCTOBER 1987 EVAP Canister Control Valve - Diagnostic Procedure
OCTOBER 1987 Side Roof Rail Weatherstrip - New Design
SEPTEMBER 1987 A/T - Front Bushing Wear
SEPTEMBER 1987 A/T - THM 350C No Torque Converter Clutch Engagement
SEPTEMBER 1987 A/T - Updated Oil Pump Assemblies
SEPTEMBER 1987 Engine Controls - ECM May Contain Wrong PROM
AUGUST 1987 A/T - Slipping or No-Shift/Metal Sealing Rings
JULY 1987 A/T - THM 200/200C No Reverse
JUNE 1987 A/T - Methods to Check for Restricted Exhaust
MAY 1987 ECM - Revised Replacement Procedure
MAY 1987 Engine - Hesitation on Light Acceleration
APRIL 1987 A/T - THM 350/350C Starts In Second Gear After Rebuild
MARCH 1987 A/T - Converter Clutch Solenoid Fluid Source I.D.
JANUARY 1987 A/T - 200/200C No Passing Gear/Check Ball Mislocated
JANUARY 1987 A/T - THM200C Erratic Shift Patterns
DECEMBER 1986 A/T - 200/2004R, 325/3254L Harsh or Soft 2-3 Shift
NOVEMBER 1986 A/T - Slipping Or No Third Gear After Overhaul
NOVEMBER 1986 Coolant Sensor - Service Kit
JULY 1986 A/T - 2004R/200C, 325 Soft 1-2 Shift
JULY 1986 A/T - Pressure Tap Locations
MAY 1986 A/T - 125, 200C/200 4R, 700 R4 Hidden Residue Build Up
MAY 1986 A/T - THM 350 Cracked Case
APRIL 1986 Engine - Stops Running When Shifted to Reverse/Drive
MARCH 1986 A/T - Converter Clutch Shudder
FEBRUARY 1986 A/T - Governor Pressure Switches
FEBRUARY 1986 A/T - Understanding Identification Information
FEBRUARY 1986 Fuel Injectors - Remanufactured for TBI Systems
JANUARY 1986 A/T - Rapid Converter Pump Bushing Wear
JANUARY 1986 A/T - Sticking Throttle Valves
DECEMBER 1985 Lock Cylinders - Inoperative/Proper Lubricant Usage
NOVEMBER 1985 A/C - Compressor Assembly Availability
NOVEMBER 1985 Fuel System - Integrator/Block Learn Operation
JULY 1985 A/T - TV Cable Identification (700-R4 Light Duty)
MAY 1985 Alignment - Chassis Spring Shims, Trim Height Correction
APRIL 1985 A/T - New Control Valve Assembly Identification
APRIL 1985 Fuel - No Start, Driveability, Excessive Alcohol Content
APRIL 1985 P/S - Rack & Pinion O-Ring Seal Fitting Leaks
APRIL 1985 Seat Belts - Extender Availability
MARCH 1985 Maintenance - Updated Minimum Acceptable Oil Levels
MARCH 1985 Paint - Basecoat/Clearcoat Repair Systems
FEBRUARY 1985 A/C - Refrigerant Hose & Clamp Repairs
FEBRUARY 1985 A/T - Updated Side Cover Or Bottom Pan Removal
FEBRUARY 1985 Brakes - Manual Clarified, Caliper To Knuckle Clearance
FEBRUARY 1985 Throttle Position Sensor - Specifications
FEBRUARY 1985 Throttle Position Sensor - Updated Specifications
FEBRUARY 1985 Wheels - Locking Wheel Nuts Impact On Tire Balance
FEBRUARY 1985 Wheels - Procedure For Removing Tight Fitting Wheels
JANUARY 1985 A/T - 200/2004R, 325/3254L No Reverse/First Gear Only
JANUARY 1985 A/T - 200C Coastdown Clunk Condition
JANUARY 1985 A/T - 200C/2004R Updated Servo Cover Retaining Ring
JANUARY 1985 A/T - 200C/2004R, 700-R4 Lip Seal Packages Part Numbers
JANUARY 1985 A/T - No Converter Clutch Apply When Unit Is Hot
JANUARY 1985 A/T - Recurrent Sticking Valves/In Line Filters
JANUARY 1985 A/T - THM 200 Pumps And Valve Bodies Interchangeability
JANUARY 1985 A/T - THM 200C In Reverse Range Engine Stops Running
JANUARY 1985 A/T - THM 200C Servicing Converter Clutch Apply Screen
JANUARY 1985 A/T - THM 350C Third Gear Switch Shorting On Pan
JANUARY 1985 Wheels - Wire Wheel Cover Noisy At Low Speeds
DECEMBER 1984 A.I.R. - Stainless Steel Pipes and Check Valves Revised
DECEMBER 1984 Battery - Add On Electrical Equipment, Side Terminals
DECEMBER 1984 Coolant - Radiator Hose Clamp Replacement Precaution
NOVEMBER 1984 Fuel - Line O Rings Precaution
OCTOBER 1984 Vehicle - Add On Equipment Precaution
SEPTEMBER 1984 A/T - Identification Information
SEPTEMBER 1984 Carburetor - New Float Level Gauges
JULY 1984 Power Antenna Mast - Lubrication
JUNE 1984 Battery - Dead/No Crank After Overnight Set
JUNE 1984 Engine - Loss of Engine Oil Pressure After Oil Change
JUNE 1984 Rocker Cover - Oil Leaks
MAY 1984 Aluminum Wheels - Cleaning/Painting/Coating
MAY 1984 Engine - Rough/Lean Idle/Rich Acceleration
APRIL 1984 A/T - Oil Pump Rotor and Slide Service Procedure
APRIL 1984 A/T - THM 200-R4 Fluid leaks
APRIL 1984 Brake System - Service Information
APRIL 1984 Wiper Blades - Chatter/Uneven Wipe
MARCH 1984 A/T - Revised Link Detent Lever to Manual Valve
MARCH 1984 Engine - Oil Recommendations
MARCH 1984 Paint - Anti Chip Coatings
MARCH 1984 Power Antenna Rod/Cable - Service Package
FEBRUARY 1984 RTV Sealer and Gasket Eliminator - Usage
JANUARY 1984 Wire Wheel Cover - Snapping/Creaking Noise
DECEMBER 1983 Radios/Electronics - Static Electricity Damage
NOVEMBER 1983 A/T Selective Washer - Revised Implementation Date
NOVEMBER 1983 Alternator Belt - Thrown Off, Worn, Glazed, or Broken
NOVEMBER 1983 Main Bearing Bolt Torque - Manual Revision
NOVEMBER 1983 Temperature Gauge - Incorrect Reading Indication
OCTOBER 1983 Differential Pinion Cross Shaft - R&R When Broken
SEPTEMBER 1983 Threadlocking Compound - Packaging Change
JULY 1983 Power Antenna - Service Parts Ordering Information
JULY 1983 Radio - No AM Band Reception
JULY 1983 TCC - Elimination of the Valve Train
JUNE 1983 Catalytic Converters - Plugging Diagnosis
JUNE 1983 Dual Bed Cat Converters - Revised Repair Procedure
MAY 1983 Accelerator Pumps, Viton® - Available
MAY 1983 Front Door Hinge - Check Link Roller
MAY 1983 Rear Compartment Weatherstrip - Ooze-Out
MAY 1983 Rear Compartment Weatherstrip Ooze-Out - Service
APRIL 1983 A/T Pump Body Assembly - Revised
APRIL 1983 Tools - Proper Use of Timing Belt Tension Gauge
MARCH 1983 A/T - No Fourth Gear
MARCH 1983 A/T - Sun Gear Shell and Thrust Washer Identification
MARCH 1983 Canister Control Valves - Revised Mounting Procedure
MARCH 1983 Fuel Injector - Electrical Damage Prevention
MARCH 1983 Idle Speed Control Assembly - Repair Kit
FEBRUARY 1983 Manifold Bolt - Installation Update
JANUARY 1983 A/T - Throttle Valve Cable Adjustment
DECEMBER 1982 Battery - Delco Freedom Battery Diagnosis and Charging
DECEMBER 1982 Engine - Minimizing Crossfire Between Cylinders
DECEMBER 1982 Engine - Mobil Oil Corporation Engine Oil Press Release
DECEMBER 1982 Engine Coolant - Usage
DECEMBER 1982 Fuel Pump - Intermittent Operation
DECEMBER 1982 TCC - Engages at Incorrect Speed
NOVEMBER 1981 Emissions - Federal Altitude Requirements/Adjustments
NOVEMBER 1981 Vehicle - Federal Altitude Requirements
FEBRUARY 1981 Oxygen Sensors - Silica Contamination
FEBRUARY 1978 HEI System - Description and Diagnosis Chart
|
